| Most common failures | No# failures |
|---|
| Horn not working |1.6.2a| | 6 |
| Parking brake: efficiency below requirements |3.7.B.7| | 6 |
| Registration plate lamp issues | 6 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Nearside Headlamp not working on main beam |1.7.5a| | 3 |
| Offside Headlamp not working on main beam |1.7.5a| | 3 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Headlamp aim out of alignment | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Nearside Front Side repeater not working |1.4.A.2c| | 2 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Windscreen washer control missing |8.2.1a| | 1 |
| Front Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Front Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Front Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Braking system leaking |3.6.A.1| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Nearside Rear Panhard rod locating pin retaining device missing |2.4.G.3b| | 1 |
| Offside Rear Panhard rod locating pin retaining device missing |2.4.G.3b| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Windscreen wiper blade missing |8.2.2| | 1 |
| Bonnet cannot be secured in the closed position |8.4.1| | 1 |
| Offside Rear Drive shaft which forms part of the suspension coupling gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.4.G.4e| | 1 |
| Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Offside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Dipswitch operation does not extinguish all main beam headlamps leaving at least one pair of dipped beam headlamps |1.7.4b| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Indicator switch faulty |1.4.A.1| | 1 |
| Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Rear Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Outer Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| brake disc contaminated by oil |3.5.1h| | 1 |
| Parking brake lever releases when knocked |3.1.6a| | 1 |
| Offside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Headlamp not working on main beam BOTH (4.1.1 (a) (ii)) | 1 |
| Offside Front coil spring broken |2.4.C.1a| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |