| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 11 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 8 |
| Parking brake: efficiency below requirements |3.7.B.7| | 8 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 7 |
| Rear parking brake recording little or no effort | 6 |
| Horn not working |1.6.2a| | 5 |
| Registration plate issues | 4 |
| Windscreen wiper does not clear the windscreen effectively | 4 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 3 |
| Brakes imbalanced across an axle | 3 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 3 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 3 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Registration plate lamp issues | 2 |
| Battery insecure |1.9.1| | 2 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 2 |
| Nearside Side repeater not working |1.4.A.2c| | 2 |
| Front brake disc in such a condition that it is seriously weakened | 2 |
| Nearside Front Seat belt retracting mechanism defective |5.2.5b| | 2 |
| Nearside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 2 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Offside Front Direction indicator not working |1.4.A.2c| | 2 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Service brake: efficiency below requirements |3.7.C.1a| | 2 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Offside Side repeater excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Centre Rear Statutory seat belt missing |5.1.1| | 1 |
| Front Windscreen wiper control missing |8.2.1a| | 1 |
| Front Windscreen washer control missing |8.2.1a| | 1 |
| Bonnet retaining device excessively deteriorated |8.4.2| | 1 |
| Front Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 1 |
| Nearside Front Torsion bar attachment bracket cracked |2.4.E.4b| | 1 |
| Nearside Front Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Offside Front Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Offside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Brake pedal has insufficient reserve movement |3.3.A.5| | 1 |
| Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front Outer Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Outer Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Front Steering rack insecure to the extent there is excessive movement at the mountings (2.1.3 (a) (ii)) | 1 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Front Side repeater insecure |1.4.A.2b| | 1 |
| Nearside Side repeater insecure |1.4.A.2b| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Nearside Rear An item not tested |Manual| | 1 |
| Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Rear brake binding | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Front Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Offside Front Drivers door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Offside Front Rear fog lamp does not emit a steady red light (4.5.4 (a)) | 1 |
| Offside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Fuel cap/sealing device missing (6.1.3 (b) (i)) | 1 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Anti-roll bar attachment bracket/mounting worn and its strength is seriously reduced |2.4.G.1| | 1 |
| Offside Front Anti-roll bar attachment bracket modified and seriously weakened |2.4.A.2| | 1 |
| Nearside Rear Upper Macpherson strut insecure |2.4.G.1| | 1 |
| Offside Outer Front Anti-roll bar attachment bracket/mounting worn and its strength is seriously reduced |2.4.G.1| | 1 |
| Nearside Rear Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Lower Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition excessive corrosion |7.1.4| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings upper strut assembly and seat belt anchorage |6.1.B.2| | 1 |
| Offside Rear Upper Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings strut assembly and seatbelt anchorage |6.1.B.2| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Rear Upper Shock absorber insecure |2.7.2b| | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front Seat belt buckle not functioning as intended buckle does not lock in clasp (7.1.2 (d)) | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
| Offside Front Brake hose leaking |3.6.A.1| | 1 |
| Offside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Steering column will not lock in a fixed position |adjustable type| |2.1.2a| | 1 |
| Fuel cap/sealing device ineffective |6.1.3 |b| |i|| | 1 |
| Offside Front Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Macpherson strut pin or bush excessively worn o/s/f top strut mounting. |5.3.4 |a| |i|| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
| Offside Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
| Nearside front brake recording little or no effort |3.7.B.5a| | 1 |
| Offside front brake recording little or no effort |3.7.B.5a| | 1 |
| Brake pedal does not operate a brake fitted to each wheel |3.3.A.3| | 1 |
| Fuel system component insecure |7.2.1| | 1 |
| Offside Outer Rear Front drive shaft coupling is insecure |2.5.C.1c| | 1 |
| Nearside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
| Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Nearside Front Main beam tell-tale missing (4.9.1 (a) (ii)) | 1 |
| Nearside Rear Leaf spring shackle bracket corroded and seriously weakened (5.3.1 (b) (i)) | 1 |
| Offside Rear Leaf spring shackle bracket corroded and seriously weakened (5.3.1 (b) (i)) | 1 |
| Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Nearside Front Anti-roll bar pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
| Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Nearside Rear Shock absorber detached |2.7.2b| | 1 |
| Offside Rear Shock absorber detached |2.7.2b| | 1 |
| Offside Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bearing |2.4.G.2| | 1 |
| Offside Rear brake caliper leaking |3.6.A.1| | 1 |
| Nearside Front brake caliper securing device loose |3.5.1j| | 1 |