| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 8 |
| Brake pipe excessively corroded | 8 |
| Windscreen wiper does not clear the windscreen effectively | 3 |
| Registration plate lamp issues | 3 |
| Brake hose excessively deteriorated | 3 |
| Nearside front brake binding |3.7.B.1| | 2 |
| Nearside Headlamp insecure |1.7.3| | 2 |
| Parking brake: efficiency below requirements |3.7.B.7| | 2 |
| Offside Headlamp insecure |1.7.3| | 2 |
| Registration plate issues | 2 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 2 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front position lamp|s| not working side light |1.1.A.3b| | 1 |
| Offside Outer Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 1 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Side repeater missing |1.4.A.2b| | 1 |
| Offside Side repeater missing |1.4.A.2b| | 1 |
| Battery insecure |1.9.1| | 1 |
| Hazard warning switch insecure |1.4.B.1d| | 1 |
| Centre Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Offside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Nearside Front Ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Brake load sensing valve seized |3.6.E.3| | 1 |
| Offside Front brake caliper leaking |3.6.A.1| | 1 |
| Nearside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Nearside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Front Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Offside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect kick up to right (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect kick up to right (4.1.2 (c)) | 1 |
| Central Rear Braking system leaking |3.6.A.1| | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Speedometer cannot be illuminated (7.8 (c) (ii)) | 1 |
| Rear Brake pivot has restricted free movement load sensing valve. (1.1.15 (e)) | 1 |
| Offside Front Passengers seat with a defective structure (6.2.6 (a) (i)) | 1 |
| Windscreen washer not working | 1 |
| Rear Brake load sensing valve seized and ABS not fitted or inoperative (1.1.17 (c) (ii)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Front Anti-roll bar insecure and impairing directional stability (5.3.3 (a) (ii)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |