| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 24 |
| Brake pipe excessively corroded | 16 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 15 |
| Registration plate lamp issues | 13 |
| Windscreen wiper does not clear the windscreen effectively | 11 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 10 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 10 |
| Parking brake: efficiency below requirements |3.7.B.7| | 9 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 9 |
| Brake hose excessively deteriorated | 8 |
| Offside Stop lamp not working |1.2.1b| | 7 |
| Rear parking brake recording little or no effort | 6 |
| Brakes imbalanced across an axle | 6 |
| Registration plate issues | 6 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 4 |
| Horn not working |1.6.2a| | 4 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 4 |
| Service brake: efficiency below requirements |3.7.B.7| | 4 |
| Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 3 |
| Nearside Headlamp not working on main beam |1.7.5a| | 3 |
| Offside front brake binding |3.7.B.1| | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 3 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 3 |
| Offside Rear Stop lamp not working |1.2.1b| | 3 |
| Nearside Rear Stop lamp not working |1.2.1b| | 2 |
| Emissions not tested |7.3.A.1| | 2 |
| Side repeater incorrect colour |1.4.A.2f| | 2 |
| Stop lamp not working |1.2.1b| | 2 |
| Service brake: efficiency below requirements |3.7.C.1a| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 2 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Front Upper Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 2 |
| Mechanical brake component has restricted free movement | 2 |
| Offside Rear Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 2 |
| Service brake is causing the vehicle to swerve to the nearside |3.7.C.2| | 2 |
| Offside Front Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Nearside Front Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Windscreen has damage | 2 |
| Offside Rear fog lamp missing |1.3.2a| | 2 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Steering system excessively tight |2.2.D.1| | 2 |
| Rear Stop lamp not working |1.2.1b| | 2 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Brake load sensing valve linkage seized |3.6.E.3| | 2 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 2 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Nearside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Inner Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front suspension has a suspension lower ball joint securing nut not locked |2.5.B.1a| | 1 |
| Inner Rear Statutory seat belt of the wrong type. |5.1.1| | 1 |
| Offside Rear Front position lamp|s| not working |1.1.A.3b| | 1 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Front brake disc has restricted free movement |3.5.1j| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Steering box insecure |2.2.B.1a| | 1 |
| Offside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Intermediate drop arm insecure |2.2.B.1a| | 1 |
| Exhaust catalytic converter missing where one was fitted as standard |7.1.3| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Windscreen wiper blade insecure | 1 |
| Brake valve leaking |3.6.A.1| | 1 |
| Nearside Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Front Headlamp does not operate immediately when selected on dipped beam |1.7.4a| | 1 |
| Front Steering wheel retaining device insecure |2.1.6| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Rear Upper Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Upper Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Rear Brake actuating linkage mounting prescribed area is excessively corroded |3.3.A.2| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Front passenger seat insecure |6.2.3| | 1 |
| Nearside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Exhaust engine idle speed too high |7.3.A.2a| | 1 |
| Offside Driver`s seat insecure |6.2.A.1| | 1 |
| Nearside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Offside brake caliper has restricted free movement |3.5.1k| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Rear brake binding | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Front Exhaust system not adequately supported |7.1.1| | 1 |
| Speedometer cannot be illuminated. |6.7.3| | 1 |
| Steering wheel locking device insecure |2.1.6| | 1 |
| Nearside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view (3.3 (b) (ii)) | 1 |
| Windscreen washer not working | 1 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength coil spring mounting plate (5.3.6 (a) (i)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor pan (5.3.6 (a) (i)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassi rail (5.3.6 (a) (i)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength out rigger (5.3.6 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wheel arch (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension arm damaged and seriously weakened trailing arm (5.3.3 (b) (i)) | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill (7.1.1 (a) (i)) | 1 |
| Nearside Rear Parking (secondary brake) on a single line braking system grabbing severely (1.3.1 (c)) | 1 |
| Offside Rear Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Offside Rear Brake pipe at imminent risk of failure or fracture (1.1.11 (a)) | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 1 |
| Rear Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Suspension component mounting prescribed area is excessively corroded o/s and n/s inner sills |2.4.A.3| | 1 |
| Offside Front Inner Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Nearside Front Service brake excessively binding |1.2.1 |f|| | 1 |
| Nearside Front Front passenger door does not latch securely closed |6.2.3 |a|| | 1 |
| Nearside Inner Suspension component mounting prescribed area is inadequately repaired sill |5.3.6 |a| |i|| | 1 |
| Nearside Rear Towbar excessively corroded within 30cm of towbar mounting wheel arch |6.1.6 |i| |i|| | 1 |
| Nearside Rear Tie bar/rod severely distorted |2.4.G.1| | 1 |
| Nearside Front Upper Ball joint damaged and unserviceable |2.2.C.1d| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Offside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Dipswitch operation does not extinguish all main beam headlamps leaving at least one pair of dipped beam headlamps |1.7.4b| | 1 |
| Offside Front Shock absorber insecure |2.7.2b| | 1 |
| Nearside Front Shock absorber insecure |2.7.2b| | 1 |
| Rear Brake linkage has restricted free movement |3.5.1k| | 1 |
| Nearside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
| Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Headlamp switch faulty |1.7.1| | 1 |
| Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Nearside Rear Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Offside Rear Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Windscreen wiper blade missing |8.2.2| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Exhaust engine idle speed too high |7.3.D.1| | 1 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Nearside Outer Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Nearside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Offside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Upper Brake hose excessively damaged |3.6.B.4d| | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Rear Statutory seat belt missing |5.1.1| | 1 |
| Upper Steering system fouling |2.2.D.2a| | 1 |
| Offside Front Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Headlamp insecure |1.7.3| | 1 |
| Front Steering system excessively tight |2.2.D.1| | 1 |
| Nearside Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Front Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Upper Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Rear passenger seat cannot be secured in the upright position. |6.2.3| | 1 |
| Offside Front Upper Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
| Offside Rear Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Offside Rear Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Outer Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Outer Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Nearside Outer Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Offside Outer Rear Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Outer Front Lower Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Offside Obligatory mirror missing |8.1.1| | 1 |
| Emissions not tested |7.0| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Centre Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Service brake grabbing severely |3.7.C.2| | 1 |
| Nearside Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Intermediate drop arm insecure |2.2.B.1a| | 1 |
| Offside Front An item not tested |Manual| | 1 |
| Nearside Rear Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Offside Rear Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Nearside Front Headlamp not in good working order |not working| |1.2.4a| | 1 |
| Offside Front coil spring incomplete |2.4.C.1a| | 1 |
| Offside Rear Brake pipe kinked |3.6.B.2b| | 1 |
| Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |