| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 73 |
| Brake pipe excessively corroded | 52 |
| Registration plate lamp issues | 48 |
| Windscreen wiper does not clear the windscreen effectively | 40 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 20 |
| Offside Stop lamp not working |1.2.1b| | 20 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 20 |
| Parking brake lever has no reserve travel |3.1.6b| | 17 |
| Parking brake: efficiency below requirements |3.7.B.7| | 15 |
| Registration plate issues | 14 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 11 |
| Nearside Stop lamp not working |1.2.1b| | 11 |
| Rear parking brake recording little or no effort | 10 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 10 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 8 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 7 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 7 |
| Offside Rear Stop lamp not working |1.2.1b| | 7 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 7 |
| Rear brake binding | 5 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 5 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 5 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 5 |
| Rear Exhaust system not adequately supported |7.1.1| | 5 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 4 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 4 |
| Front brake disc in such a condition that it is seriously weakened | 4 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 4 |
| Service brake: efficiency below requirements |3.7.C.1a| | 4 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 4 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 4 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 4 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 4 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 4 |
| Brakes imbalanced across an axle | 4 |
| Rear brake disc in such a condition that it is seriously weakened | 4 |
| Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 4 |
| Rear fog lamp missing |1.3.2a| | 3 |
| Offside Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 3 |
| Offside Front Wheel bearing has excessive play |5.1.3 |a| |i|| | 3 |
| Front Exhaust system not adequately supported |7.1.1| | 3 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 3 |
| Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 3 |
| Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 3 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 3 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 3 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 3 |
| Nearside Rear Stop lamp not working |1.2.1b| | 3 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 3 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 3 |
| Front position lamp|s| incorrect colour |1.1.A.3e| | 2 |
| Nearside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
| Offside Front Position lamp not working |4.2.1 |a|| | 2 |
| Nearside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Parking brake operation is causing the vehicle to swerve to the offside |3.7.C.3a| | 2 |
| Brake performance not tested |3.7.A.1| | 2 |
| Rear Mechanical brake component has restricted free movement | 2 |
| Nearside front brake binding |3.7.B.1| | 2 |
| Windscreen has damage | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 2 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 2 |
| Nearside Front Service brake excessively fluctuating (1.2.1 (e)) | 2 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Offside Rear Brake pivot has restricted free movement |3.5.1k| | 2 |
| Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Exhaust system not adequately supported |7.1.1| | 2 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 2 |
| Centre Exhaust system not adequately supported |7.1.1| | 2 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 2 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 2 |
| Centre Stop lamp has less than 50% of the light sources illuminating |1.2.1b| | 2 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 2 |
| Driver`s airbag obviously defective |5.4.1| | 2 |
| Front Exhaust has a major leak of exhaust gases flexi joint (6.1.2 (a)) | 2 |
| Nearside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 2 |
| Rear Brake pivot has restricted free movement |3.5.1k| | 2 |
| Offside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Power steering fluid level below minimum |2.3.1| | 2 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 2 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 2 |
| Nearside Rear Parking brake inoperative on one side |1.4.1 |a|| | 2 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 2 |
| Emissions not tested (8.2.1.2 (d)) | 2 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 2 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Side repeater missing |1.4.A.2b| | 1 |
| Rear Electrical wiring insecure towing socket and wiring |1.9.2a| | 1 |
| Front position lamp|s| incorrect colour both |1.1.A.3e| | 1 |
| Rear fog lamp switch missing |1.3.1a| | 1 |
| Side repeater missing both |1.4.A.2b| | 1 |
| Side repeater missing both sides |1.4.A.2b| | 1 |
| Nearside Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Exhaust has a major leak of exhaust gases flexi section |7.1.2| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded inner sill |5.2.6| | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush d bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush d bush |2.4.G.2| | 1 |
| Offside Front Headlamp has a product on the lens so that the light output is severely reduced |4.1.4 |b|| | 1 |
| Spare wheel insecure in carrier |6.1.5 |b| |i|| | 1 |
| Offside Front Wheel bearing rough when rotated |5.1.3 |b| |i|| | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced inner sill |7.1.1 |a| |i|| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Nearside Rear Inner Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting sill (6.2.2 (d) (i)) | 1 |
| Offside Rear Inner Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting sill (6.2.2 (d) (i)) | 1 |
| Offside Front coil spring broken |2.4.C.1a| | 1 |
| Offside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Brake clevis joint has restricted free movement |3.5.1k| | 1 |
| Rear Exhaust has a major leak of exhaust gases Joint (6.1.2 (a)) | 1 |
| Rear Exhaust silencer insecure (8.1.1 (b) (i)) | 1 |
| Nearside Rear Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Offside Front Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner sill (6.2.2 (d) (i)) | 1 |
| Exhaust has a major leak of exhaust gases Down-Pipe Flexi-Joint leaking |6.1.2 |a|| | 1 |
| Horn not working |1.6.2a| | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement anti rollbar D bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement anti rollbar D bush |2.4.G.2| | 1 |
| Offside Rear Fluid suspension leaking |2.4.D.2| | 1 |
| Nearside Front Lower Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear reflector missing (4.8.2 (a) (ii)) | 1 |
| Offside Front Lower Shock absorbers has a serious fluid leak (5.3.2 (b)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Offside Front Lower Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced chassis (6.1.1 (c) (i)) | 1 |
| Offside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced chassis (6.1.1 (c) (i)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Rear Anti-roll bar linkage pin or bush excessively worn d bush (5.3.4 (a) (i)) | 1 |
| Rear Exhaust system insecure (6.1.2 (a)) | 1 |
| Nearside Front Inner Steering rack has excessive free play detected at the steering wheel (steering rack fitted) rack end (2.3 (a) (i)) | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Inner Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Central Rear Upper Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Front Headlamp light source and lamp not compatible HID kit fitted (4.1.4 (c)) | 1 |
| Offside Front Seat belt webbing significantly weakened drivers belt (7.1.2 (b) (ii)) | 1 |
| Front Fluid leaking continuously posing a serious risk to road safety (8.4.1 (a) (ii)) | 1 |
| Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Rear Service brake excessively binding parking brake axle pivot seized (1.2.1 (f)) | 1 |
| Front Headlamp has a product on the light source so that the light output is severely reduced BOTH . (4.1.4 (b)) | 1 |
| Nearside Front Upper Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Inner Seat belt anchorage prescribed area strength or continuity significantly reduced TO REAR . (7.1.1 (a) (i)) | 1 |
| Nearside Rear Inner Seat belt anchorage prescribed area is inadequately repaired TO CENTRE . (7.1.1 (a) (i)) | 1 |
| Offside Front Inner Seat belt anchorage prescribed area strength or continuity significantly reduced TO REAR . (7.1.1 (a) (i)) | 1 |
| Offside Rear Inner Seat belt anchorage prescribed area is inadequately repaired TO CENTRE (7.1.1 (a) (i)) | 1 |
| Nearside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Sill corroded and holed (5.3.6 (a) (i)) | 1 |
| Offside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Sill corroded and holed (5.3.6 (a) (i)) | 1 |
| Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Rear Lower Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner sill (6.2.2 (d) (i)) | 1 |
| Offside Front Lower Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner sill (6.2.2 (d) (i)) | 1 |
| Nearside Front Lower Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner sill (6.2.2 (d) (i)) | 1 |
| Nearside Front Wheel bearing has excessive play rough when rotated (5.1.3 (a) (i)) | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner sill below A post |6.1.B.2| | 1 |
| Brake linkage has restricted free movement |3.5.1k| | 1 |
| Power steering malfunctioning |2.3.3a| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Front suspension has excessive play in a upper suspension ball joint upper wishbone |2.5.B.1a| | 1 |
| Offside Inner Seat belt anchorage likely to become detached in the event of a collision sill (7.1.1 (a) (ii)) | 1 |
| Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Central Exhaust system not adequately supported Mounting Broken |7.1.1| | 1 |
| Offside Rear Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced SILL (6.1.1 (c) (i)) | 1 |
| Nearside Parking (secondary brake) on a single line braking system has inadequate effort at a wheel (1.3.1 (a) (i)) | 1 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |
| Offside Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Nearside Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Offside Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Nearside Front Lower Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Offside Front Lower Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Offside Front Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Nearside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt insecure (6.1.7 (g) (ii)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i)) | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Nearside Rear Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Rear Anti-roll bar linkage pin or bush excessively worn both (5.3.4 (a) (i)) | 1 |
| Rear Anti-roll bar pin or bush excessively worn both (5.3.4 (a) (i)) | 1 |
| Nearside Front Outer Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill (6.2.2 (d) (i)) | 1 |
| Nearside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill |6.1.B.2| | 1 |
| Offside Front Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill |6.1.B.2| | 1 |
| Front brake disc excessively scored |3.5.1h| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Rear Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Rear Tie bar/rod attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front All position lamps not working |1.1.A.3b| | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Offside Rear Tie bar/rod insecure |2.4.G.1| | 1 |
| Offside Headlamp has a product on the light source so that the light output is severely reduced |4.1.4 |b|| | 1 |
| Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Offside Front Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Headlamp has a product on the lens so that the light output is severely reduced both (4.1.4 (b)) | 1 |
| Brake pedal anti-slip provision incomplete |3.3.A.1b| | 1 |
| Offside Brake cable has a seized clevis joint pivot |3.5.1c| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Offside Rear Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill (6.2.2 (d) (i)) | 1 |
| Nearside Inner Seat belt anchorage prescribed area is excessively corroded sills |5.2.6| | 1 |
| Offside Inner Seat belt anchorage prescribed area is excessively corroded sills |5.2.6| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 1 |
| Nearside Front brake caliper leaking |3.6.A.1| | 1 |
| Offside Front Inner Body component corroded and likely to cause injury sill (6.2.1 (a) (i)) | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear Valve stem seriously damaged |5.2.3 |j|| | 1 |
| Offside Rear Valve stem seriously damaged |5.2.3 |j|| | 1 |
| Brake pivot has restricted free movement REAR AXLE |1.1.15 |e|| | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Front Headlamp light source and lamp not compatible both sides (4.1.4 (c)) | 1 |
| Headlamp aim projected beam image is obviously incorrect Both lens misted (4.1.2 (c)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Offside Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Offside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength SILL (5.3.6 (a) (i)) | 1 |
| Offside Rear Anti-roll bar has excessive play in a ball joint DROPLINK |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar has excessive play in a pin/bush D BUSH |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush D BUSH |2.4.G.2| | 1 |
| Rear Brake performance not tested |3.7.A.1| | 1 |
| Offside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Front Headlamp has a product on the lens so that the light output is severely reduced both sides (4.1.4 (b)) | 1 |
| Nearside Front position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Offside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect suspected bulb seated incorrectly (4.1.2 (c)) | 1 |
| Centre Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Offside Front All position lamps not working |1.1.A.3b| | 1 |
| Nearside Front Lower Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Emissions not tested major exhaust leak (8.2.1.2 (d)) | 1 |
| Parking brake lever inoperative (1.1.6 (d)) | 1 |
| Front Exhaust has a major leak of exhaust gases flex |7.1.2| | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Inner Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Front position lamp|s| not in good working order |function impaired| |1.1.4a| | 1 |
| Rear Brake disc significantly and obviously worn |1.1.14 |a| |i|| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Nearside Front Upper Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Rear Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| Nearside Front Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Offside Front Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Nearside Front Anti-roll bar linkage pin or bush excessively worn D bush |5.3.4 |a| |i|| | 1 |
| Offside Front Anti-roll bar linkage pin or bush excessively worn D bush |5.3.4 |a| |i|| | 1 |
| Nearside Rear Anti-roll bar linkage pin or bush excessively worn D bush |5.3.4 |a| |i|| | 1 |
| Offside Rear Anti-roll bar linkage pin or bush excessively worn D bush |5.3.4 |a| |i|| | 1 |
| Rear Stop lamp has less than 50% of the light sources illuminating high level brake lamp |1.2.1b| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt slight play in ball joint |2.2.C.1c| | 1 |
| Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings nearside and offside front |6.1.B.2| | 1 |
| Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 1 |
| Rear brake application uneven | 1 |
| Nearside Rear rear brake grabbing severely |3.7.A.5b| | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Offside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Central Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting both sides (6.2.2 (d) (i)) | 1 |
| Nearside Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting sill member. |6.2.2 |d| |i|| | 1 |
| Offside Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting sill member. |6.2.2 |d| |i|| | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment no reserve travel. |1.1.6 |c|| | 1 |
| Nearside Outer Seat belt anchorage prescribed area strength or continuity significantly reduced Sill area. (7.1.1 (a) (i)) | 1 |
| Offside Outer Seat belt anchorage prescribed area strength or continuity significantly reduced Sill area. (7.1.1 (a) (i)) | 1 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear Suspension arm attachment bracket/mounting insecure and impairing directional stability |5.3.3 |a| |ii|| | 1 |
| Nearside Rear Suspension arm attachment bracket/mounting corroded and seriously weakened |5.3.3 |b| |i|| | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced |7.1.1 |a| |i|| | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced |7.1.1 |a| |i|| | 1 |
| Front Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect lens needs cleaned (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect lens needs cleaned (4.1.2 (c)) | 1 |
| Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement both sides |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Nearside Rear Other passenger door cannot be opened from outside the vehicle |6.2.3 |a|| | 1 |
| Nearside Front Upper Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Upper Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Nearside Brake lever has restricted free movement |1.1.15 |e|| | 1 |
| Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Rear Rear fog lamp insecure |1.3.2a| | 1 |
| Nearside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Offside Rear Rear fog lamp missing |1.3.2a| | 1 |
| Nearside Front Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Side repeater incorrect colour |4.4.3 |a|| | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Offside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Front Side repeater incorrect colour |1.4.A.2f| | 1 |
| Exhaust system not adequately supported 2 brackets corroded off centre of exhaust |7.1.1| | 1 |
| Nearside Front Position lamp not working sidelight |4.2.1 |a|| | 1 |
| Nearside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill |5.3.6 |a| |i|| | 1 |
| Offside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill |5.3.6 |a| |i|| | 1 |
| Offside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill |5.3.6 |a| |i|| | 1 |
| Rear Prop shaft securing bolt loose |6.1.7 |a| |i|| | 1 |
| Nearside Inner Integral body structure or chassis has excessive corrosion to the extent that overall security or stability of the body is impaired sill |6.2.2 |d| |ii|| | 1 |
| Offside Inner Integral body structure or chassis has excessive corrosion to the extent that overall security or stability of the body is impaired sill |6.2.2 |d| |ii|| | 1 |
| Brake pivot has restricted free movement |3.5.1k| | 1 |
| Nearside Rear brake disc contaminated by oil |3.5.1h| | 1 |
| Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front coil spring incomplete |2.4.C.1a| | 1 |
| Central Stop lamp|s| with a multiple light source more than 1/2 not functioning |4.3.1 |a| |ii|| | 1 |
| Central Exhaust system not adequately supported |7.1.1| | 1 |
| Brake hose excessively deteriorated | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Position lamp light intensity significantly reduced |4.2.3 |a| |ii|| | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Sill. |5.3.6 |a| |i|| | 1 |
| Offside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Sill. |5.3.6 |a| |i|| | 1 |
| Nearside Front Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Sill. |6.2.2 |d| |i|| | 1 |
| Trailer electrical socket |13 pin| not operating the trailer lamps as intended |1.9.4| | 1 |
| Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Front Service brake grabbing severely |3.7.C.2| | 1 |
| Offside Rear Service brake grabbing severely |3.7.C.2| | 1 |
| Offside Brake pivot has restricted free movement |3.5.1k| | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Nearside Rear Shock absorbers has a serious fluid leak | 1 |
| Power steering component leaking Steering rack |2.1.5 |a|| | 1 |
| Nearside Drag link end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 1 |
| Offside Front Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill (6.2.2 (d) (i)) | 1 |
| Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen Jets Aiming Above Screen |3.5 |a|| | 1 |
| Central Rear Seat belt buckle missing Centre Rear Seat Belt Buckle Missing |7.1.2 |d|| | 1 |
| Offside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Nearside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| rear parking |secondary| brakes imbalanced | 1 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Front Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Exhaust fumes entering cabin (6.1.2 (b) (i)) | 1 |
| Battery leaking electrolyte |1.9.1| | 1 |
| Offside Front Power steering ram|s| leaking from a failed seal |2.3.3b| | 1 |
| Front Exhaust has a major leak of exhaust gases center flexi pipe |7.1.2| | 1 |
| Front Anti-roll bar has excessive play in a pin/bush on both sides D bushes |2.4.G.2| | 1 |
| Rear Anti-roll bar has excessive play in a pin/bush on both sides D bushes |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar linkage fractured |2.4.G.1| | 1 |
| Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Exhaust has a major leak of exhaust gases front flexi pipe (6.1.2 (a)) | 1 |
| Brake pedal anti-slip provision missing (1.1.2 (c)) | 1 |
| Emissions not tested due to major blow (8.2.1.2 (d)) | 1 |
| Nearside Front Lower Seat belt anchorage prescribed area strength or continuity significantly reduced inner sill corroded (7.1.1 (a) (i)) | 1 |
| Nearside Lower Seat belt anchorage prescribed area strength or continuity significantly reduced whole outer sill (7.1.1 (a) (i)) | 1 |
| Offside Lower Seat belt anchorage prescribed area strength or continuity significantly reduced whole outer sill (7.1.1 (a) (i)) | 1 |
| Front Exhaust system insecure hangar broke off (6.1.2 (a)) | 1 |
| Nearside Rear Parking (secondary brake) on a single line braking system grabbing severely (1.3.1 (c)) | 1 |
| Offside Rear Parking (secondary brake) on a single line braking system grabbing severely (1.3.1 (c)) | 1 |
| Offside Front Front passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Offside Rear Direction indicator incorrect colour showing white (4.4.3 (a)) | 1 |
| Nearside Front Position lamp not working aftermarket led strip fitted original sidelights not fitted (4.2.1 (a) (ii)) | 1 |
| Front Position lamp not working Both fronts (4.2.1 (a) (ii)) | 1 |
| Rear Rear fog lamp does not emit a steady red light Showing white light (4.5.4 (a)) | 1 |
| Nearside Rear Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill holed |5.3.6 |a| |i|| | 1 |
| Brake lever has insufficient reserve travel Parking brake |1.1.2 |a|| | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust system insecure (6.1.2 (a)) | 1 |
| Fluid leak harmful to the environment or a risk to other road users Coolant (8.4.1 (a) (i)) | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Nearside Rear Inner Seat belt anchorage prescribed area strength or continuity significantly reduced Sill (7.1.1 (a) (i)) | 1 |
| Offside Rear Inner Seat belt anchorage prescribed area strength or continuity significantly reduced Sill (7.1.1 (a) (i)) | 1 |
| Offside Rear Lower Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Shock mount (Axle) (5.3.6 (a) (i)) | 1 |
| Nearside Rear Upper Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Arm mount (Axle) (5.3.6 (a) (i)) | 1 |
| Offside Rear Upper Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Arm mount (Axle) (5.3.6 (a) (i)) | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Battery insecure |1.9.1| | 1 |