Most common failures | No# failures |
---|
Headlamp aim out of alignment | 15 |
Front Roller brake test indicates a binding brake |3.3.A1a| | 8 |
Front Roller brake test indicates excessive fluctuation of brake effort |3.3.A1d| | 4 |
Rear Roller brake test indicates a binding brake |3.3.A1a| | 4 |
Headlamp at least one does not illuminate on main beam |1.2.2a|ii|| | 3 |
Registration plate lamp issues | 3 |
Offside Front Brake lever has inadequate reserve travel |3.1.3b| | 2 |
Front Brake lever has inadequate reserve travel |3.1.3b| | 2 |
Parking brake: efficiency below requirements |3.7.B.7| | 2 |
Headlamp at least one does not illuminate on dipped beam |1.2.2a|i|| | 2 |
Front wheel bearings have excessive free play |2.3.5b| | 2 |
Registration plate issues | 2 |
Front Stop lamp does not illuminate immediately a brake applies |1.3.1a| | 2 |
Nearside Front shock absorber seal failed and leaking oil |2.3.3| | 2 |
Rear Roller brake test indicates a sticking brake |3.3.A1a| | 2 |
Front suspension has inadequate damping effect. |2.3.6c| | 2 |
Rear Floor brake test indicates a binding brake |3.3.C2c| | 2 |
Throttle operating incorrectly |6.2.1f| | 2 |
Offside Front Direction indicator not working |1.5.1c| | 1 |
Offside Rear Direction indicator flashing less than 60 times a minute |1.5.1c| | 1 |
Rear Locking devices not correctly fitted which may make the motor bicycle dangerous to ride No split pin in rear axle castellated nut |6.2.1h| | 1 |
Roller brake test The less effective brake control does not achieve an efficiency of 25%. |3.3.A2b| | 1 |
Rear Brake disc|s| excessively scored |3.2.A1l| | 1 |
Service brake: efficiency below requirements |3.7.B.7| | 1 |
Nearside Front Direction indicator flashing more than 120 times per minute wrong bulb fitted changed to higher watt to reduce flash rate |1.5.1c| | 1 |
Front Roller brake test indicates brake effort rise disproportional to brake lever or pedal effort bled front brake to rid system of trapped air |3.3.A1c| | 1 |
Rear Roller brake test indicates excessive fluctuation of brake effort |3.3.A1d| | 1 |
Rear Rear wheel has a loose wheel nut|s| |4.2.3a| | 1 |
Rear Rear wheel spindle securing nut locking device missing |2.4.A.2b| | 1 |
Rear suspension has a fracture of a load bearing member or its supporting structure. |2.4.A.2d| | 1 |
Front position lamp incorrect colour |1.1.2a| | 1 |
Offside Rear Braking system leaking |3.6.A.1| | 1 |
Exhaust noise is clearly in excess of that emitted by a similar motor bicycle fitted with a standard silencer in average condition |7.1.2| | 1 |
Front Brake lever has inadequate reserve travel |9.3.1f| | 1 |
Offside Footrest insecure |9.6.1| | 1 |
Rear Trailing arm attachment bracket/mounting insecure |2.4.G.1| | 1 |
Front shock absorber seal failed and leaking oil |2.3.3| | 1 |
Stop lamp does not illuminate immediately a brake applies |1.3.1a| | 1 |
Rear suspension has corrosion which reduces the strength of a load bearing member or its supporting structure. |2.4.A.2d| | 1 |
Steering head bearings has excessive wear or free play seized and notchy |2.2.2 |g|| | 1 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Stop lamp does not face the rear |1.2.1a| | 1 |
Offside Stop lamp does not face the rear |1.2.1a| | 1 |
Rear fog lamp tell tale not working |1.3.1b| | 1 |
Rear Brake pedal has insufficient reserve movement |3.3.A.5| | 1 |
Offside Front Lower Brake hose excessively damaged |3.6.B.4d| | 1 |
Body has excessive displacement which may lead to loss of vehicle control |6.1.B.1a| | 1 |
Rear Rear reflector missing |1.5.1a| | 1 |
Centre Front Steering movement excessively `notchy` with the wheel raised |2.2.1b| | 1 |
Nearside Front Brake disc|s| is excessively distorted |3.2.A1m| | 1 |
Offside Front Brake disc|s| is excessively distorted |3.2.A1m| | 1 |
Throttle operating incorrectly |6.2.7 |a| |i|| | 1 |
Rear wheel bearings have excessive free play |2.4.A.2c| | 1 |
Direction indicator not working righthand rear |1.5.1c| | 1 |
Fuel system component leaking |7.2.1a| | 1 |
Footrest insecure lefthand front |6.2.1a| | 1 |
Headlamp insecure |1.2.3b| | 1 |
Rear wheel spindle securing nut locking device missing |2.4.A.2b| | 1 |
Handlebar handgrip not secure to handlebars. |2.1.1c| | 1 |
Fairings insecure and likely to impede the steering |2.1.2e| | 1 |
Front Floor brake test indicates a binding brake |3.3.C2c| | 1 |
Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
Rear fog lamp missing |1.3.2a| | 1 |
Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
Nearside Exhaust system not adequately supported |7.1.1| | 1 |
Front Stop lamp not working |1.2.1b| | 1 |
Nearside Front position lamp|s| missing |1.1.A.3a| | 1 |
Offside Front position lamp|s| missing |1.1.A.3a| | 1 |
Offside Rear Hydraulic brake cylinder retaining device insecure |3.6.A.2d| | 1 |
Offside Rear Parking brake lever has no reserve travel |3.1.6b| | 1 |
Offside Hydraulic brake cylinder locking device insecure |3.6.A.2d| | 1 |
Centre front brake binding |3.7.B.1| | 1 |
Nearside Rear Mechanical brake component securing device missing |3.5.1i| | 1 |
Offside Rear Mechanical brake component securing device missing |3.5.1i| | 1 |
Offside Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
Centre Rear Sub-frame attachment bracket/mounting insecure |2.4.G.1| | 1 |
Hazard warning switch inoperative |4.4.2 |a| |ii|| | 1 |
Nearside Front Steering component mounting prescribed area is inadequately repaired steering dampner |2.2.C.1h| | 1 |
Front Brake hose excessively damaged |3.6.B.4d| | 1 |
Offside Rear Stop lamp not working |1.2.1b| | 1 |
Centre Front Front position lamp|s| obviously incorrectly positioned |1.1.A.3a| | 1 |
Centre Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Outer Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside Front suspension has inadequate damping effect. |2.3.6c| | 1 |
Offside Front Front suspension has inadequate damping effect. |2.3.6c| | 1 |
Front Front wheel bearings have excessive free play |2.3.5b| | 1 |
Direction indicators flashing more than 120 times per minute |1.5.1c| | 1 |
Rear position lamp does not illuminate immediately when it is switched on |1.1.3a| | 1 |
Steering movement excessively `notchy` with the weight on the lower bearing |2.2.1a| | 1 |
Rear Roller brake test indicates a severely juddering brake |3.3.A1b| | 1 |
Front wheel bearings are excessively rough |2.3.5b| | 1 |
Offside Front Front shock absorber seal failed and leaking oil |2.3.3| | 1 |
Centre Fuel system component leaking |7.2.1a| | 1 |
Indicator tell tale missing |1.4.A.2a| | 1 |
Nearside Rear reflector missing |1.5.1a| | 1 |
Offside Rear reflector missing |1.5.1a| | 1 |
Front suspension assembly component loose |2.3.1| | 1 |
Front suspension assembly component missing |2.3.1| | 1 |
Front Headlamp insecure |1.2.3b| | 1 |
Rear Rear wheel bearings have excessive free play |2.4.A.2c| | 1 |
Rear spring worn and seriously weakened |2.4A1b|ii|| | 1 |
Front Motorcycle structure excessively distorted |6.1.1a| | 1 |
Rear position lamp|s| not working |1.1.A.3b| | 1 |
Rear brake binding | 1 |
Front Brake pedal spongy |3.3.B.1b| | 1 |
Rear Brake disc|s| cracked |3.2.A1g| | 1 |
Nearside Exhaust is leaking and excessively noisey |7.1.1b| | 1 |
Offside Exhaust is leaking and excessively noisey |7.1.1b| | 1 |
Front Brake lever cracked |3.1.2c| | 1 |
Offside Front Footrest insecure |6.2.1a| | 1 |
Rear suspension bush has excessive free play |2.4.A2a|i|| | 1 |
Horn not working |1.7.3a| | 1 |
Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
Brake lever has insufficient reserve travel Adjustment made. (1.1.2 (a)) | 1 |
Rear reflector missing x2. Fitted during test. (4.8.2 (a) (ii)) | 1 |
Nearside Rear reflector missing (4.8.2 (a) (ii)) | 1 |
Offside Rear reflector missing (4.8.2 (a) (ii)) | 1 |
Hazard warning lamps not fitted (4.4.1 (d)) | 1 |
Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
Nearside Front Shock absorber has a serious fluid leak (5.3.2 (b)) | 1 |
Offside Front Shock absorber has a serious fluid leak (5.3.2 (b)) | 1 |
Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
Brake valve leaking (1.1.7 (d) (i)) | 1 |
All position lamps not working (4.2.1 (a)) | 1 |
Front Stop lamp not working (4.3.1 (a) (ii)) | 1 |
Nearside Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
Offside Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |