| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 47 |
| Registration plate lamp issues | 39 |
| Headlamp aim out of alignment | 26 |
| Brake hose excessively deteriorated | 11 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 10 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 10 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 9 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 7 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 7 |
| Offside Stop lamp not working |1.2.1b| | 7 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 6 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 6 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 6 |
| Anti-lock braking system warning lamp indicates an ABS fault | 6 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 6 |
| Engine MIL inoperative or indicates a malfunction (8.2.2.2 (g)) | 5 |
| Front brake disc in such a condition that it is seriously weakened | 5 |
| Rear fog lamp not working |1.3.2b| | 5 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 5 |
| Offside Front Shock absorbers has a serious fluid leak | 5 |
| Exhaust emissions exceed default limit of 1.5m-1 (8.2.2.2 (b)) | 5 |
| Rear parking brake recording little or no effort | 4 |
| Nearside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 4 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 4 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 4 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 4 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 4 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Offside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 3 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 3 |
| Rear fog lamp tell tale not working |1.3.1b| | 3 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 3 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 3 |
| Registration plate issues | 3 |
| Exhaust emits an excessive level of metered smoke |7.4.B.3a| | 3 |
| Windscreen washer not working | 3 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 3 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 3 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 3 |
| Nearside Front Shock absorbers has a serious fluid leak | 3 |
| Offside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 3 |
| Offside Front Road wheel fixing missing (5.2.1 (a) (i)) | 2 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
| Nearside Rear Shock absorbers has a serious fluid leak | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Rear Shock absorbers has a serious fluid leak | 2 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Fuel system component leaking |7.2.3| | 2 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Nearside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 2 |
| Brake pipe excessively corroded | 2 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Rear brake binding | 2 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Electronic stability system warning lamp indicates a fault |3.4.1c| | 2 |
| Exhaust on a vehicle fitted with a diesel particulate filter emits visible smoke of any colour (8.2.2.2 (d)) | 2 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 2 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 2 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Offside Front Position lamp not working |4.2.1 |a|| | 2 |
| Exhaust fumes causing a danger to health of persons on board (6.1.2 (b) (ii)) | 2 |
| Nearside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 2 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Fuel system component leaking dripping at bottom of engine (6.1.3 (b) (i)) | 1 |
| Front Headlamp aim projected beam image is obviously incorrect BOTH (4.1.2 (c)) | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Obligatory mirror insecure |8.1.1| | 1 |
| Offside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Fuel system component leaking (6.1.3 (b) (i)) | 1 |
| Towbar attachment insecure (6.1.6 (c) (i)) | 1 |
| Power steering pipe/hose leaking (2.1.5 (a)) | 1 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view (3.3 (b) (ii)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 1 |
| Spare wheel insecure in carrier (6.1.5 (b) (i)) | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Offside Front Lower Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Battery insecure |1.9.1| | 1 |
| Offside Rear fog lamp obviously incorrectly positioned |1.3.2a| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength axle cross beam n/s outer mounting rotted and weak (5.3.6 (a) (i)) | 1 |
| Offside Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Anti-roll bar linkage fractured (5.3.3 (b) (ii)) | 1 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Headlamp cleaning device inoperative |1.7.2| | 1 |
| Offside Headlamp cleaning device inoperative |1.7.2| | 1 |
| Headlamp cleaning device inoperative |1.7.2| | 1 |
| Exhaust emits excessive smoke or vapour likely to obscure the vision of other road users |8.2.2.2 |c|| | 1 |
| Front Anti-roll bar pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Lower Shock absorbers insecurely attached bolt was loose (5.3.2 (a) (i)) | 1 |
| Battery insecure and likely to fall from carrier |4.13 |a| |ii|| | 1 |
| Brake fluid contaminated (1.8 (a)) | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Headlamp aim beam image obviously incorrect incorrectly fitted bulb |1.8.A.1b| | 1 |
| Nearside Stop lamp has a product on the light source so it is not visible from a reasonable distance |1.2.1d| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Front Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Brake fluid contaminated - Brake reservoir/non-transparent fluid (1.8 (a)) | 1 |
| Nearside Rear Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Offside Rear Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Offside Rear Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Road wheel more than one fixing missing (5.2.1 (a) (ii)) | 1 |
| Offside Front Valve stem seriously damaged |4.1.D.1e| | 1 |
| Offside Rear Valve stem seriously damaged |4.1.D.1e| | 1 |
| Nearside Rear Valve stem seriously damaged |4.1.D.1e| | 1 |
| Offside Rear Anti-lock braking system wheel speed sensor excessively damaged (1.6 (c)) | 1 |
| Nearside Front Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Valve stem seriously damaged |4.1.D.1e| | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Front Prop shaft joint excessively worn (6.1.7 (c) (i)) | 1 |
| Offside Front Position lamp light intensity significantly reduced |4.2.3 |a| |ii|| | 1 |
| Fuel system component leaking excessively or a risk of fire In engine bay. |6.1.3 |b| |ii|| | 1 |
| Nearside Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Front Inner Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
| Offside Front Inner Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
| Offside Rear Inner Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill (6.2.2 (d) (i)) | 1 |
| Electronic stability control warning lamp indicates a fault |7.12 |e|| | 1 |
| Nearside Front Suspension arm pin or bush excessively worn bottom ball joint |5.3.4 |a| |i|| | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect led bulbs were fitted (4.1.2 (c)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect led bulbs were fitted (4.1.2 (c)) | 1 |
| Nearside Rear Brake disc contaminated (1.1.14 (b)) | 1 |
| Nearside Rear Brake lining(s) contaminated (1.1.13 (b)) | 1 |
| Nearside Rear Oil leaking excessively from transmission (8.4.1 (a) (i)) | 1 |
| Nearside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Obligatory mirror seriously deteriorated, affecting the rear view |8.1.2a| | 1 |
| Nearside Front Lower Front suspension has excessive movement at a suspension ball joint |2.5.A.1c| | 1 |
| Offside Front Lower Front suspension has excessive movement at a suspension ball joint |2.5.A.1c| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Offside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Offside Rear position lamp(s) not working (1.1.A.3b) | 1 |
| Offside Stop lamp not working (1.2.1b) | 1 |
| Nearside Rear fog lamp not working (1.3.2b) | 1 |
| Exhaust emits an excessive level of metered smoke (7.4.B.3a) | 1 |
| An item not tested |Manual| | 1 |
| Nearside Front Seat belt webbing significantly weakened cut from edge greater than 2mm (7.1.2 (b)) | 1 |
| Nearside Front Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Brakes imbalanced across an axle | 1 |
| Rear Anti-roll bar linkage ball joint excessively worn both sides (5.3.4 (a) (i)) | 1 |
| Nearside Front Front position lamp|s| not working sidelight |1.1.A.3b| | 1 |
| Offside Front Front position lamp|s| not working sidelight |1.1.A.3b| | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Nearside Rear Rear fog lamp does not emit a steady red light (4.5.4 (a)) | 1 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Front Road wheel fixing missing wheel stud broken (5.2.1 (a) (i)) | 1 |
| Nearside Rear Inner Anti-roll bar linkage pin or bush excessively worn d bush (5.3.4 (a) (i)) | 1 |
| Offside Rear Inner Anti-roll bar linkage pin or bush excessively worn d bush (5.3.4 (a) (i)) | 1 |
| Offside Rear Suspension arm pin or bush excessively worn CHALKED (5.3.4 (a) (i)) | 1 |
| Nearside Rear Anti-roll bar pin or bush excessively worn D BUSH (5.3.4 (a) (i)) | 1 |
| Offside Rear Anti-roll bar pin or bush excessively worn D BUSH (5.3.4 (a) (i)) | 1 |
| Nearside Front Inner Seat belt anchorage prescribed area strength or continuity significantly reduced SILL (7.1.1 (a) (i)) | 1 |
| Offside Front Inner Seat belt anchorage prescribed area strength or continuity significantly reduced SILL (7.1.1 (a) (i)) | 1 |
| Fuel tank leaking (6.1.3 (b) (i)) | 1 |
| Bonnet cannot be secured in the closed position (3.1 (b) (i)) | 1 |
| Nearside Front Inner Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Headlamp aim not tested |4.1.2 |b|| | 1 |
| Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Bonnet cannot be secured in the closed position |3.1 |b| |i|| | 1 |
| Nearside Rear Stop lamp not working (1.2.1b) | 1 |
| Nearside Front Valve stem seriously damaged (4.1.D.1e) | 1 |
| Offside Front Valve stem seriously damaged (4.1.D.1e) | 1 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
| Offside Rear Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Front position lamp(s) not working (1.1.A.3b) | 1 |
| Offside Rear Rear fog lamp not working (1.3.2b) | 1 |
| Offside Front Shock absorber has a serious fluid leak (2.7.3) | 1 |
| Fuel system component leaking at engine (6.1.3 (b) (i)) | 1 |
| Fuel system component leaking excessively or a risk of fire engine area (6.1.3 (b) (ii)) | 1 |
| Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Nearside Rear Brake hose connection leaking on a hydraulic braking system (1.1.12 (c) (ii)) | 1 |
| Offside Rear Brake hose connection leaking on a hydraulic braking system (1.1.12 (c) (ii)) | 1 |
| Brake performance unable to be tested due to leaking connections at rear (1.2.1 (g)) | 1 |
| Rear fog lamp not working (1.3.2b) | 1 |
| Nearside Inner Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
| Offside Inner Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
| Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Offside Front Service brake grabbing severely (1.2.1 (c)) | 1 |
| Offside Front Service brake is causing the vehicle to swerve to the offside (1.2.1 (b) (i)) | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside Front Outer Prop shaft joint constant velocity boot no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside front brake binding wheel bearing not cheched |3.7.B.1| | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view (3.3 (b) (ii)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Exhaust emissions exceed manufacturers specified limit (8.2.2.2 (a)) | 1 |
| Exhaust emissions exceed default limit of 1.5m-1 |8.2.2.2 |b|| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Headlamp not working on dipped beam NO BULB HOLDER |1.7.5a| | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt outer (6.1.7 (g) (ii)) | 1 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt outer (6.1.7 (g) (ii)) | 1 |
| Steering column universal joint has excessive wear or play (2.2.2 (c)) | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Rear Stop lamp(s) showing white light to the rear (4.3.3 (a) (ii)) | 1 |
| Central Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Obligatory mirror insecure |8.1.1| | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Nearside Rear Parking (secondary brake) on a single line braking system has no recorded effort at a wheel (1.3.1 (a) (ii)) | 1 |
| Offside Rear Parking (secondary brake) on a single line braking system has no recorded effort at a wheel (1.3.1 (a) (ii)) | 1 |
| Offside Front Position lamp not working |4.2.1 |a| |ii|| | 1 |
| Nearside Rear fog lamp light intensity significantly reduced (4.5.4 (a)) | 1 |
| Headlamp aim projected beam image is obviously incorrect both (4.1.2 (c)) | 1 |
| Front Body component damaged and likely to cause injury |6.2.1 |a| |i|| | 1 |
| Offside Rear Brake disc contaminated |1.1.14 |b|| | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced Inner sill (7.1.1 (a) (i)) | 1 |
| Offside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced inner sill (7.1.1 (a) (i)) | 1 |
| Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Brake hose has insufficient room to move | 1 |
| Nearside Front Brake hose twisted |3.6.B.4c| | 1 |
| Front Bumper damaged and likely to cause injury when grazed or contacted taped over (6.1.4 (a) (i)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn press in ball joint (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn press in ball joint (5.3.4 (a) (i)) | 1 |
| Nearside Front Brake hose leaking on a hydraulic braking system caliper area |1.1.12 |c| |ii|| | 1 |
| Offside Front Brake hose leaking on a hydraulic braking system caliper area |1.1.12 |c| |ii|| | 1 |
| Offside Rear Rear fog lamp lens defective such that emitted light is adversely affected showing white light to rear lens broken (4.5.1 (b) (ii)) | 1 |
| Offside Rear Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Offside Front Valve stem seriously damaged tpms valve end snapped off so core exposed (5.2.3 (j)) | 1 |
| Offside Rear Valve stem seriously damaged tpms valve snapped off and inner core exposed (5.2.3 (j)) | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Engine MIL inoperative or indicates a malfunction LIGHT ON DASH (8.2.2.2 (g)) | 1 |