| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 30 |
| Windscreen wiper does not clear the windscreen effectively | 27 |
| Registration plate lamp issues | 13 |
| Brake pipe excessively corroded | 12 |
| Anti-lock braking system warning lamp indicates an ABS fault | 10 |
| Rear parking brake recording little or no effort | 6 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 5 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 5 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 5 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 4 |
| Registration plate issues | 4 |
| Parking brake: efficiency below requirements |3.7.B.7| | 4 |
| Parking brake lever has no reserve travel |3.1.6b| | 3 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 3 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 3 |
| Front brake disc in such a condition that it is seriously weakened | 3 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 2 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 2 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 2 |
| Nearside Front Direction indicator incorrect colour (4.4.3 (a)) | 2 |
| Offside Front Direction indicator incorrect colour (4.4.3 (a)) | 2 |
| Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 2 |
| Electronic stability system warning lamp indicates a fault |3.4.1c| | 2 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 2 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
| Nearside Rear Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Nearside Front Drag link end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Front Drag link end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Nearside Rear Brake disc contaminated Diff oil leak (1.1.14 (b)) | 1 |
| Nearside Rear Suspension arm corroded and seriously weakened Trailing arm (5.3.3 (b) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength By trailing arm front mount (5.3.6 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength By trailing arm front mount (5.3.6 (a) (i)) | 1 |
| Offside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i)) | 1 |
| Exhaust has a major leak of exhaust gases centre box (6.1.2 (a)) | 1 |
| Nearside Rear Brake disc contaminated (1.1.14 (b)) | 1 |
| Nearside Rear Suspension component corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Nearside Rear Brake disc contaminated oil from failed hub seal |1.1.14 |b|| | 1 |
| Brake lever has insufficient reserve travel |1.1.2 |a|| | 1 |
| Steering lock fails to engage key stuck in lock |2.1.4b| | 1 |
| Offside Rear Seat belt retracting mechanism defective will not extend |5.2.5b| | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.2.2 (g)) | 1 |
| Power steering component leaking Heavy power steering leak covering most components (2.1.5 (a)) | 1 |
| Nearside Front Shock absorbers has a serious fluid leak | 1 |
| Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Front Brake pedal anti-slip provision worn smooth (1.1.2 (c)) | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Central Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Anti-roll bar linkage has excessive play in a ball joint Both rear |2.4.G.2| | 1 |
| Drivers view of the road through the swept area of the windscreen significantly affected by an obstruction (3.1 (a) (ii)) | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Exhaust system insecure both brakets snapped of (6.1.2 (a)) | 1 |
| Offside Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Nearside Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Front Upper Front drive shaft support bearing excessively worn axle support mounting |2.5.C.2c| | 1 |
| Offside Front Driver`s seat with a defective structure frame broken. |6.2.5 |a| |i|| | 1 |
| Driver`s seat insecure |6.2.5 |a| |ii|| | 1 |
| Nearside Rear Seat belt buckle damaged |7.1.2 |d|| | 1 |
| Nearside Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Offside Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Steering box has excessive free play detected at the steering wheel (steering box fitted) controll arm bush (2.3 (a) (i)) | 1 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Brake disc contaminated hub oil seal leaking |1.1.14 |b|| | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 1 |
| Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Braking system leaking |3.6.A.1| | 1 |
| Rear brake binding | 1 |
| Prop shaft joint constant velocity boot no longer prevents the ingress of dirt front prop rear joint (6.1.7 (g) (ii)) | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Offside Front Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced inner wheel arch (7.1.1 (a) (i)) | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced inner wheel arch (7.1.1 (a) (i)) | 1 |
| Nearside Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced sill (6.1.1 (c) (i)) | 1 |
| Offside Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced sill (6.1.1 (c) (i)) | 1 |
| Central Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Front Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Central Exhaust system insecure MOUNTING BROKEN (6.1.2 (a)) | 1 |
| Nearside Front Service brake excessively binding |1.2.1 |f|| | 1 |
| Nearside Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| Offside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Battery insecure and likely to fall from carrier |4.13 |a| |ii|| | 1 |
| Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Nearside Rear Towbar component excessively corroded |6.6.1| | 1 |
| Offside Rear Towbar component excessively corroded |6.6.1| | 1 |
| Central Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Emissions not tested |7.0| | 1 |
| Offside Front Prop shaft joint constant velocity boot no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Nearside Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Upper Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Upper Trailing arm rubber bush deteriorated resulting in excessive movement top axle bar |2.4.G.2| | 1 |
| Centre Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Front Shock absorbers has a serious fluid leak | 1 |
| Front brake excessively fluctuating | 1 |
| Nearside Front Macpherson strut worn and seriously weakened |2.4.G.1| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Main beam `tell-tale` not working |1.7.4c| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Horn not working |1.6.2a| | 1 |
| Nearside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength cill within 30cm of mount (5.3.6 (a) (i)) | 1 |
| Rear Brake pipe at imminent risk of failure or fracture (1.1.11 (a)) | 1 |
| Drivers seat moving inadvertently (6.2.5 (b) (ii)) | 1 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
| Offside Rear Exhaust emissions likely to be affected by an exhaust leak Rear silencer holed (8.2.2.1 (b)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn trailing arm front bush (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn trailing arm front bush (5.3.4 (a) (i)) | 1 |
| Nearside Rear Suspension arm pin or bush excessively worn trailing arm rear bush (5.3.4 (a) (i)) | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Rear Upper Tie bar/rod rubber mounting deteriorated resulting in excessive movement x 2 a frame bushes |2.4.G.2| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturer`s specified limits |8.2.1.2 |a|| | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Centre Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Track rod end ball joint worn to the extent there is a serious risk of detachment (2.1.3 (b) (ii)) | 1 |
| Nearside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Track rod end ball joint has excessive play rubber cover also split (2.1.3 (b) (i)) | 1 |
| Trailer electrical socket (13 pin) not functioning at all (4.10 (c) (ii)) | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front Inner Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |