| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 29 |
| Registration plate issues | 24 |
| Windscreen wiper does not clear the windscreen effectively | 20 |
| Registration plate lamp issues | 13 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 10 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 10 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 8 |
| Brake hose excessively deteriorated | 8 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 7 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 6 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 6 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 5 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 5 |
| Battery insecure |1.9.1| | 4 |
| Anti-lock braking system warning lamp indicates an ABS fault | 4 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 4 |
| Rear fog lamp switch missing |1.3.1a| | 3 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Rear brake disc in such a condition that it is seriously weakened | 3 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 3 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 3 |
| Windscreen washer not working | 3 |
| Centre Stop lamp not working |1.2.1b| | 3 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 3 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Rear fog lamp missing |1.3.2a| | 2 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 2 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 2 |
| Nearside Front front brake binding |3.7.B.1| | 2 |
| Offside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 2 |
| Nearside Rear Wheel nut|s| missing |4.2.A.1e| | 2 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 2 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt clip (6.1.7 (g) (ii)) | 2 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Offside front brake binding |3.7.B.1| | 2 |
| Rear brake binding | 2 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Rear Wheel nut|s| missing |4.2.A.1e| | 2 |
| Central Stop lamp not working |1.2.1b| | 2 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Front brake disc in such a condition that it is seriously weakened | 2 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Electronic stability system warning lamp indicates a fault |3.4.1c| | 2 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 2 |
| Offside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Parking brake: efficiency below requirements |3.7.B.7| | 2 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Nearside Front position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
| Rear fog lamp tell tale missing |1.3.1b| | 1 |
| Nearside Side repeater missing |1.4.A.2b| | 1 |
| Offside Side repeater missing |1.4.A.2b| | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Inner Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Rear Wheel nut|s| missing one |4.2.A.1e| | 1 |
| Windscreen has damage | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |
| Nearside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Headlamp not working on dipped beam both (4.1.1 (a) (ii)) | 1 |
| Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Nearside Rear Seat belt buckle not functioning as intended (7.1.2 (d)) | 1 |
| Nearside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Brake performance not tested |1.2.1 |g|| | 1 |
| rear parking |secondary| brakes imbalanced | 1 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Rear Service brake is causing the vehicle to swerve to the nearside binding (1.2.1 (b) (i)) | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt clip/suggest re pack joint (6.1.7 (g) (ii)) | 1 |
| Nearside Front Front passenger door cannot be opened from inside the vehicle (6.2.3 (a)) | 1 |
| Central Rear Seat belt buckle missing (7.1.2 (d)) | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt clip/suggest check joint (6.1.7 (g) (ii)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Offside Rear Seat belt buckle not functioning as intended (7.1.2 (d)) | 1 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
| Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Rear Inner Anti-roll bar rubber bush deteriorated resulting in excessive movement both |2.4.G.2| | 1 |
| Offside Rear Brake lining(s) less than 1.5 mm thick (1.1.13 (a) (ii)) | 1 |
| Nearside Rear Brake lining(s) less than 1.5 mm thick (1.1.13 (a) (ii)) | 1 |
| Offside Rear Anti-roll bar ball joint likely to become detached lnk bar (5.3.4 (a) (ii)) | 1 |
| Offside Front Position lamp not working sidelight (4.2.1 (a) (ii)) | 1 |
| Offside Rear Lower Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Emissions unable to be completed (8.2.1.2 (d)) | 1 |
| Nearside Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Central Stop lamp|s| with a multiple light source more than 1/2 not functioning |4.3.1 |a| |ii|| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Rear Vehicle structure has damage which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Front Shock absorbers has a serious fluid leak | 1 |
| Central Rear Stop lamp(s) light intensity significantly reduced Middle rear brake lamp (4.3.3 (a) (ii)) | 1 |
| Offside Steering linkage ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Rear Oil leaking excessively from transmission rear differential |8.4.1 |a| |i|| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Rear Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Front Outer Steering system has excessive free play detected at the steering wheel |steering rack fitted| joint |2.2.A.1b| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Exhaust has a major leak of exhaust gases center silencer (6.1.2 (a)) | 1 |
| Emissions not tested exhaust leak (8.2.1.2 (d)) | 1 |
| Nearside Front Suspension component ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Rear Suspension rod pin or bush excessively worn Lower arm (5.3.4 (a) (i)) | 1 |
| Offside Rear Suspension rod pin or bush excessively worn Lower arm (5.3.4 (a) (i)) | 1 |
| Offside Rear Outer Passenger`s seat cannot be secured in the upright position. rear|rear| |6.2.A.2| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Exhaust fumes causing a danger to health of persons on board (6.1.2 (b) (ii)) | 1 |
| Nearside Obligatory mirror insecure |8.1.1| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front Lower Suspension arm insecurely attached (5.3.3 (a) (i)) | 1 |
| Nearside Front Road wheel fixings not compatible brake touching road wheel (5.2.2 (d)) | 1 |
| Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front Steering linkage ball joint has excessive play tie rod (2.1.3 (b) (i)) | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Centre Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Centre Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Rear Stop lamp|s| all not working |4.3.1 |a| |iii|| | 1 |
| Nearside Rear Service brake indicates brake bind |3.7.D.2a| | 1 |
| Offside Front Service brake indicates brake bind |3.7.D.2a| | 1 |
| Offside Front Brake hose excessively twisted (1.1.12 (b) (ii)) | 1 |
| Nearside Front Upper Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Headlamps matched pair are incorrectly positioned |1.7.3| | 1 |
| Offside Rear Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Offside Rear Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Battery insecure Clamping block missing |1.9.1| | 1 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Front Service brake grabbing severely |3.7.C.2| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Emissions not tested due to condition of centre silencer (8.2.1.2 (d)) | 1 |
| Offside Front Shock absorbers has a serious fluid leak | 1 |
| Rear parking brake recording little or no effort | 1 |