| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 24 |
| Registration plate lamp issues | 23 |
| Registration plate issues | 13 |
| Windscreen wiper does not clear the windscreen effectively | 8 |
| Rear parking brake recording little or no effort | 7 |
| Anti-lock braking system warning lamp indicates an ABS fault | 5 |
| Nearside Stop lamp not working |1.2.1b| | 4 |
| Battery insecure |1.9.1| | 4 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 4 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Rear Suspension arm corroded and seriously weakened (5.3.3 (b) (i)) | 3 |
| Brake hose excessively deteriorated | 3 |
| Nearside Front Battery insecure |1.9.1| | 2 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Rear brake binding | 2 |
| Windscreen wiper blade insecure | 2 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 2 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 2 |
| Centre Stop lamp not working |1.2.1b| | 2 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 2 |
| Brakes imbalanced across an axle | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Drivers seat insecure (6.2.5 (a) (ii)) | 2 |
| Offside Rear Suspension arm corroded and seriously weakened (5.3.3 (b) (i)) | 2 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Central Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Rear Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Brake pump leaking |3.6.A.1| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Offside Upper Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Rear Prop shaft bearing likely to break up (6.1.7 (b) (ii)) | 1 |
| Nearside Front Anti-lock braking system component excessively damaged (1.6 (e)) | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Electrical wiring insecure |1.9.2a| | 1 |
| Front Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced Outer sill (7.1.1 (a) (i)) | 1 |
| Rear Panhard rod rubber bush deteriorated resulting in excessive movement axle support member N/S Bush |2.4.G.2| | 1 |
| Offside Rear Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Offside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Front Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Exhaust system insecure both rear brackets not attached (6.1.2 (a)) | 1 |
| Offside Rear Lower Suspension arm pin or bush excessively worn rear bush of radius arm (5.3.4 (a) (i)) | 1 |
| Windscreen washer not working | 1 |
| Nearside Rear Sub-frame pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Service brake lagging in operation (1.2.1 (d)) | 1 |
| Nearside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Rear Upper Sub-frame pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Front Anti-roll bar pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Wheel nut|s| missing 1 each wheel |4.2.A.1e| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a pin/bush wishbone bush |2.4.G.2| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded outer sill |5.2.6| | 1 |
| Nearside Position lamp not working |4.2.1 |a|| | 1 |
| Offside Position lamp not working |4.2.1 |a|| | 1 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Inner Seat belt anchorage prescribed area strength or continuity significantly reduced And outer sill corroded (7.1.1 (a) (i)) | 1 |
| Offside Inner Seat belt anchorage prescribed area strength or continuity significantly reduced And outer sill corroded (7.1.1 (a) (i)) | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
| Offside Front Main beam `tell-tale` not working |1.7.4c| | 1 |
| Offside Front Power steering component|s| leaking |2.3.3b| | 1 |
| Offside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Front Side repeater not working |1.4.A.2c| | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Fuel tank insecure strap broken |7.2.1| | 1 |
| Nearside Rear Torque/reaction arm has a deteriorated rubber mounting resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Torque/reaction arm has a deteriorated rubber mounting resulting in excessive movement |2.4.G.2| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced Outer Sill |7.1.1 |a| |i|| | 1 |
| Offside Seat belt anchorage prescribed area strength or continuity significantly reduced Outer Sill |7.1.1 |a| |i|| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Inner Sill |5.3.6 |a| |i|| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Inner Sill |5.3.6 |a| |i|| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Central Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Upper Front suspension has excessive movement at a suspension ball joint |2.5.A.1c| | 1 |
| Electronic parking brake warning indicates a malfunction Red Dash board warning light On |3.1.7| | 1 |
| Nearside Front Headlamp adversely affected by the operation of another lamp 50% of light output |1.7.5c| | 1 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 1 |
| Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 1 |
| Hydraulic fluid leaking excessively |8.4.1 |a| |i|| | 1 |
| Battery insecure and likely to fall from carrier |4.13 |a| |ii|| | 1 |
| Nearside Side repeater light intensity significantly reduced |4.4.3 |a|| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Front Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |