| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 9 |
| Windscreen wiper does not clear the windscreen effectively | 6 |
| Brakes imbalanced across an axle | 6 |
| Registration plate issues | 6 |
| Headlamp aim out of alignment | 5 |
| Nearside Rear Stop lamp not working |1.2.1b| | 4 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Nearside Stop lamp not working |1.2.1b| | 4 |
| Registration plate lamp issues | 4 |
| Offside Front Front drive shaft coupling is excessively worn |2.5.C.1c| | 3 |
| Exhaust system not adequately supported |7.1.1| | 3 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 3 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 2 |
| Headlamp aim not tested |1.8.A.1c| | 2 |
| Mechanical brake component has restricted free movement | 2 |
| Parking brake: efficiency below requirements |3.7.B.7| | 2 |
| Rear parking brake recording little or no effort | 2 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Nearside Front coil spring incomplete |2.4.C.1a| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Nearside Front An item not tested |Manual| | 1 |
| Offside Front An item not tested |Manual| | 1 |
| Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Rear Parking brake lever is impeded in its travel |3.1.6c| | 1 |
| Nearside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Front coil spring fractured |2.4.C.1a| | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Rear brake application uneven | 1 |
| Offside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Rear Seat belt stitching badly frayed |5.2.2b| | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect LED bulb fitted |4.1.2 |c|| | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect LED bulb fitted |4.1.2 |c|| | 1 |
| Oil leaking excessively from engine Suspect oil filter loose |8.4.1 |a| |i|| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Spring mount |5.3.6 |a| |i|| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Spring mount |5.3.6 |a| |i|| | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Offside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Rear Position lamp not working both (4.2.1 (a) (ii)) | 1 |
| Offside Front brake caliper leaking |3.6.A.1| | 1 |
| Front Drag link end loose |2.2.B.1d| | 1 |
| Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Nearside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced front leaf spring mount area (6.1.1 (c) (i)) | 1 |
| Offside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Front leaf spring mount area (6.1.1 (c) (i)) | 1 |
| Nearside Front Outer Drive shaft joint excessively worn (6.1.7 (c) (i)) | 1 |
| Offside Front Outer Drive shaft joint excessively worn (6.1.7 (c) (i)) | 1 |
| Offside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Drivers door hinge insecure (6.2.3 (c) (ii)) | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Nearside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Upper Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement bush worn on link arm |2.4.G.2| | 1 |
| Offside Front Upper Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement bush worn on link arm |2.4.G.2| | 1 |
| Front Body insecure and dangerous to other road users bull bars brackets corroded/broken |6.1.B.1b| | 1 |
| Offside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Headlamp switch faulty |1.7.1| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Battery insecure |1.9.1| | 1 |
| Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Headlamp not in good working order |not working| |1.2.4a| | 1 |
| Centre Rear Statutory seat belt missing |5.1.1| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Service brake is causing the vehicle to swerve to the offside |3.7.C.2| | 1 |
| Offside Rear Service brake grabbing severely |3.7.C.2| | 1 |
| Nearside Inner Front Panhard rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Body or chassis is cracked, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
| Nearside Front drive shaft coupling is excessively worn |2.5.C.1c| | 1 |
| Nearside Mechanical brake component securing device excessively deteriorated |3.5.1i| | 1 |
| Offside Mechanical brake component securing device excessively deteriorated |3.5.1i| | 1 |
| Horn not working |1.6.2a| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside Front Side repeater incorrect colour |1.4.A.2f| | 1 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
| Centre Statutory seat belt missing |5.1.1| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Nearside Front Anti-roll bar synthetic mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Anti-roll bar synthetic mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |