Most common failures | No# failures |
---|
Parking brake: efficiency below requirements |3.7.B.7| | 20 |
Headlamp aim out of alignment | 13 |
Rear parking brake recording little or no effort | 10 |
Windscreen wiper does not clear the windscreen effectively | 10 |
Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 7 |
Horn not working |1.6.2a| | 6 |
Rear brake binding | 5 |
Offside Headlamp not working on main beam |1.7.5a| | 5 |
Offside Rear fog lamp not working |1.3.2b| | 4 |
Hazard warning tell tale not working correctly |1.4.B.1e| | 4 |
Nearside Headlamp not working on main beam |1.7.5a| | 4 |
Registration plate issues | 4 |
Parking brake lever has no reserve travel |3.1.6b| | 3 |
Service brake: efficiency below requirements |3.7.B.7| | 3 |
Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
Registration plate lamp issues | 3 |
Nearside Side repeater not working |1.4.A.2c| | 2 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
Brake pipe excessively corroded | 2 |
Nearside Stop lamp not working |1.2.1b| | 2 |
Offside Stop lamp not working |1.2.1b| | 2 |
Rear Stop lamp not working |1.2.1b| | 2 |
Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 2 |
Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Brakes imbalanced across an axle | 2 |
Nearside Rear wheel bearing has excessive play |2.6.2| | 2 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Nearside Front Direction indicator not working |1.4.A.2c| | 2 |
Nearside Rear Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Rear Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Direction indicator not working |1.4.A.2c| | 1 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Front Brake pipe excessively damaged |3.6.B.2c| | 1 |
Steering component is not secure to the vehicle structure |2.2.B.1a| | 1 |
Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
Front Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen |3.5 |a|| | 1 |
Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
Offside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
Offside Rear Rear fog lamp excessively deteriorated so that it is not visible from a reasonable distance |1.3.2d| | 1 |
Offside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
Front Exhaust has a major leak of exhaust gases manifold joint |7.1.2| | 1 |
Sub-frame attachment bracket/mounting bolt missing Rear subframe, NSR mounting not correctly located |2.4.G.1| | 1 |
Offside front brake binding |3.7.B.1| | 1 |
Nearside Upper Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Upper Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Steering column universal joint insecure |2.1.5| | 1 |
Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Nearside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front coil spring fractured |2.4.C.1a| | 1 |
Front brake application uneven | 1 |
Offside Steering rack gaiter split |2.2.D.2d| | 1 |
Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
Offside Front Subframe mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Headlamp not working on main beam |1.7.5a| | 1 |
Mechanical brake component locking device missing |3.5.1l| | 1 |
Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Front suspension locking device missing |2.5.A.4| | 1 |
Offside Front Direction indicator not working |1.4.A.2c| | 1 |
Offside Front Power steering pump leaking from a failed component |2.3.3b| | 1 |
Offside Front Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
Rear brake application uneven | 1 |
Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Offside Front Lower Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Power steering component|s| leaking |2.3.3b| | 1 |
Fuel pipe leaking |7.2.3| | 1 |
Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Front Windscreen wiper blade missing |8.2.2| | 1 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Horn emits two or more alternating tones |1.6.2d| | 1 |
Horn not a continuous or uniform sound |1.6.2e| | 1 |
Nearside Front Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Rear Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Rear Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside Rear Lower Axle swivel joint has excessive play in a swivel pin |2.5.A.3b| | 1 |
Offside Front Lower coil spring incomplete |2.4.C.1a| | 1 |
Position lamp switch insecure |1.1.A.1| | 1 |
Offside Front Side repeater not working |1.4.A.2c| | 1 |
Nearside Rear Stop lamp not working |1.2.1b| | 1 |
Offside Rear Stop lamp not working |1.2.1b| | 1 |
Front Headlamp not working on main beam |1.7.5a| | 1 |
Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Nearside Rear Sub-frame attachment rubber mounting bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Stop lamp not working |1.2.1b| | 1 |
Nearside Indicator tell tale inoperative |1.4.A.2a| | 1 |
Steering rack insecure |2.2.B.1a| | 1 |
Nearside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Rear Direction indicators not working |1.4.A.2c| | 1 |
Nearside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Rear brake disc contaminated by oil |3.5.1h| | 1 |
Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 1 |
Dipswitch operation does not deflect all main beam headlamps to make them dipped beams |1.7.4b| | 1 |
Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Front Position lamp missing |4.2.1 |a|| | 1 |
Offside Front Position lamp missing |4.2.1 |a|| | 1 |
Nearside Front Service brake excessively binding |1.2.1 |f|| | 1 |
Nearside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
Offside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
Nearside Front Floor excessively deteriorated |6.2.4 |a| |i|| | 1 |
Nearside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
Offside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
Horn not working |7.7 |a| |ii|| | 1 |
Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
Nearside Rear Brake disc contaminated Half shaft seal leaking onto disc (1.1.14 (b)) | 1 |
Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Service brake excessively fluctuating o/s/r and n/sf (1.2.1 (e)) | 1 |
Nearside Power steering component leaking steering rack (2.1.5 (a)) | 1 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 1 |
Passengers seat insecure (6.2.6 (a) (ii)) | 1 |
Rear fog lamp adversely affected by the operation of another lamp (4.5.4 (b)) | 1 |
Steering rack has excessive free play detected at the steering wheel to the extent that safe steering is affected (steering rack fitted) Excessive movement at fixings. (2.3 (a) (ii)) | 1 |