| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 38 |
| Headlamp aim out of alignment | 20 |
| Registration plate lamp issues | 19 |
| Registration plate issues | 14 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 6 |
| Windscreen has damage | 4 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 4 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 4 |
| Headlamp cleaning device for LED or HID headlamp inoperative (4.1.6 (a) (ii)) | 3 |
| Windscreen washer not working | 3 |
| Offside Rear Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 3 |
| Offside Headlamp cleaning device obviously defective |1.7.2| | 2 |
| Electronic parking brake warning indicates a malfunction |3.1.7| | 2 |
| Parking brake: efficiency below requirements |3.7.B.7| | 2 |
| Headlamp cleaning device inoperative |1.7.2| | 2 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect kick up to the right (4.1.2 (c)) | 2 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 2 |
| Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 2 |
| Nearside Rear Road wheel fractured (5.2.2 (a)) | 2 |
| Nearside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Rear Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Nearside Front Side repeater has less than 50% of the light sources illuminating |1.4.A.2c| | 1 |
| Offside Front Inner Road wheel cracked |4.2.A.1a| | 1 |
| Nearside Headlamp cleaning device for LED or HID headlamp inoperative |4.1.6 |a| |ii|| | 1 |
| Offside Headlamp cleaning device for LED or HID headlamp inoperative |4.1.6 |a| |ii|| | 1 |
| Brakes imbalanced across an axle | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Nearside Front Anti-roll bar pin or bush excessively worn `D` bush |5.3.4 |a| |i|| | 1 |
| Offside Front Anti-roll bar pin or bush excessively worn `D` bush |5.3.4 |a| |i|| | 1 |
| Power steering pipe|s| or hose|s| leaking HP pump to top of rack |2.3.3b| | 1 |
| Offside Front brake caliper has restricted free movement |3.5.1k| | 1 |
| Front Headlamp cleaning device inoperative |1.7.2| | 1 |
| Power steering fluid level below minimum |2.3.1| | 1 |
| Nearside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Stop lamp remains on when the brakes are released | 1 |
| Offside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Offside Front Road wheel cracked |4.2.A.1a| | 1 |
| Offside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front Road wheel distorted |4.2.A.1a| | 1 |
| Offside Front Body component damaged and likely to cause injury DRIVERS DOOR HANDLE |6.2.1 |a| |i|| | 1 |
| Nearside Front Road wheel fractured |5.2.2 |a|| | 1 |
| Offside Front Road wheel has a welding defect OLD WELD FRACTURED |5.2.2 |a|| | 1 |
| Nearside Front Road wheel fixing missing |5.2.1 |a| |i|| | 1 |
| Nearside Front Headlamp cleaning device for LED or HID headlamp inoperative |4.1.6 |a| |ii|| | 1 |
| Offside Front Headlamp cleaning device for LED or HID headlamp inoperative |4.1.6 |a| |ii|| | 1 |
| Nearside Rear Road wheel cracked |4.2.A.1a| | 1 |
| Nearside Rear Tie bar/rod which is adjustable, locking device insecure |2.4.G.1| | 1 |
| Offside Rear Tie bar/rod which is adjustable, locking device insecure |2.4.G.1| | 1 |
| Nearside Position lamp not working |4.2.1 |a|| | 1 |
| Headlamp switch faulty |1.7.1| | 1 |
| Offside Obligatory mirror insecure |3.3 |b| |ii|| | 1 |
| Undertray insecure |8.1.1 |b| |i|| | 1 |
| Nearside Headlamp cleaning device inoperative |1.7.2| | 1 |
| Offside Headlamp cleaning device inoperative |1.7.2| | 1 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Nearside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside Front Windscreen damaged and affecting the driver`s view of the road |3.2 |a| |ii|| | 1 |
| Nearside Rear Rear position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
| Nearside Stop lamp has less than 50% of the light sources illuminating |1.2.1b| | 1 |
| Nearside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Central Rear Lower Statutory seat belt missing buckle |5.1.1| | 1 |
| Central Rear Seat belt buckle missing (7.1.2 (d)) | 1 |
| Headlamp cleaning device for LED or HID headlamp inoperative P.R.S offside & nearside, filled reservoir with fluid, no further fault found (4.1.6 (a) (ii)) | 1 |
| Front Headlamp aim projected beam image is obviously incorrect kick up to the right (4.1.2 (c)) | 1 |
| Offside Front Road wheel fractured (5.2.2 (a)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn front (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn front (5.3.4 (a) (i)) | 1 |
| Nearside Rear Upper Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Upper Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Rear Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt Both sides (2.1.3 (g) (ii)) | 1 |
| Central Rear Seat belt buckle not functioning as intended seat belt will not connect (7.1.2 (d)) | 1 |
| Front Anti-roll bar pin or bush excessively worn D-Bushes (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn Front (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn Front (5.3.4 (a) (i)) | 1 |
| Nearside Rear Suspension component pin or bush excessively worn Tension rod (5.3.4 (a) (i)) | 1 |
| Offside Rear Suspension component pin or bush excessively worn Tension rod (5.3.4 (a) (i)) | 1 |
| Nearside Rear Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Front Headlamp cleaning device for LED or HID headlamp inoperative (4.1.6 (a) (ii)) | 1 |
| Dipswitch does not operate immediately when selected on main beam (4.1.3 (b)) | 1 |
| Nearside Rear Exhaust system insecure mounting broken (6.1.2 (a)) | 1 |
| Engine MIL inoperative or indicates a malfunction engine light on (8.2.1.2 (h)) | 1 |
| Drivers seat fore and aft adjustment mechanism not functioning as intended. (6.2.5 (b) (i)) | 1 |
| Offside Rear Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Rear Road wheel fractured inner rim (5.2.2 (a)) | 1 |
| Offside Rear Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Brake disc fractured wrong size (1.1.14 (a) (ii)) | 1 |
| Offside Rear Brake disc fractured wrong size (1.1.14 (a) (ii)) | 1 |
| Offside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |
| Central Rear Seat belt buckle not functioning as intended middle seat belt buckle (7.1.2 (d)) | 1 |
| Offside Rear Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Headlamp cleaning device for LED or HID headlamp inoperative (4.1.6 (a) (ii)) | 1 |
| Offside Rear Road wheel fractured (5.2.2 (a)) | 1 |
| Nearside Front Road wheel has a welding defect (5.2.2 (a)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Electronic parking brake warning indicates a malfunction (1.1.6 (e)) | 1 |
| Parking brake inoperative on one side n/s and o/s (1.4.1 (a)) | 1 |
| Nearside Rear Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Rear Lower Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Rear Suspension unit damaged or deteriorated and function affected (5.3.5 (b) (i)) | 1 |
| Offside Rear Suspension unit damaged or deteriorated and function affected (5.3.5 (b) (i)) | 1 |
| Offside Rear Suspension component pin or bush likely to become detached (5.3.4 (a) (ii)) | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect kick up to the right (4.1.2 (c)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Position lamp with a multiple light source more than 1/2 not functioning (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Rear Stop lamp(s) lens defective such that the emitted light is adversely affected (4.3.1 (b) (ii)) | 1 |
| Offside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Rear Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Rear Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |