| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 68 |
| Windscreen wiper does not clear the windscreen effectively | 67 |
| Headlamp aim out of alignment | 43 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 43 |
| Brake pipe excessively corroded | 39 |
| Registration plate issues | 22 |
| Windscreen washer not working | 16 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 15 |
| Nearside Rear Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 14 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 13 |
| Anti-lock braking system warning lamp indicates an ABS fault | 13 |
| Brake hose excessively deteriorated | 12 |
| Offside Rear Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 11 |
| Nearside Rear Direction indicator incorrect colour (4.4.3 (a)) | 11 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 10 |
| Offside Rear Direction indicator incorrect colour (4.4.3 (a)) | 9 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 8 |
| Nearside Rear Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 7 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 7 |
| Offside Rear Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 6 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 6 |
| Bonnet cannot be secured in the closed position (3.1 (b) (i)) | 6 |
| Electronic parking brake control defective so that it cannot be satisfactorily operated (1.1.6 (d)) | 6 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 6 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 6 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 5 |
| Nearside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 5 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 5 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 4 |
| Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 4 |
| Brakes imbalanced across an axle | 4 |
| Nearside Rear Outer Suspension rod ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 4 |
| Offside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 4 |
| Offside Rear Suspension rod ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 4 |
| Nearside Rear Suspension rod ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 4 |
| Nearside Rear Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 4 |
| Electronic parking brake control inoperative (1.1.6 (d)) | 4 |
| Suspension system inoperative (5.3.5 (a)) | 4 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 4 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 4 |
| Offside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 4 |
| Nearside Rear Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 4 |
| Horn not working (7.7 (a)) | 4 |
| Nearside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 4 |
| Rear brake binding | 3 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 3 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 3 |
| Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 3 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Rear Outer Suspension rod ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 3 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 3 |
| Offside Rear Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 3 |
| Offside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Offside Rear Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 3 |
| Electronic parking brake warning indicates a malfunction (1.1.6 (e)) | 3 |
| Nearside Rear Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 3 |
| Nearside Rear Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 3 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 3 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 3 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 3 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 3 |
| Brake performance not tested (1.2.1 (g)) | 3 |
| Nearside Rear Shock absorbers has an excessively worn bush (5.3.2 (c)) | 3 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 3 |
| Offside Rear Lower Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 3 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 3 |
| Offside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 3 |
| Nearside Front Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 3 |
| Offside Rear Road wheel cracked |4.2.A.1a| | 2 |
| Offside Rear Upper Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 2 |
| Nearside Rear Lower Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 2 |
| Offside Rear Lower Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 2 |
| Nearside Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
| Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 2 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 2 |
| Offside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 2 |
| Nearside Rear Lower Suspension arm has excessive play in a pin/bearing |2.4.G.2| | 2 |
| Offside Rear Lower Suspension arm has excessive play in a pin/bearing |2.4.G.2| | 2 |
| Offside Rear Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Horn not working |1.6.2a| | 2 |
| Rear parking brake recording little or no effort | 2 |
| Nearside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
| Rear brake disc in such a condition that it is seriously weakened | 2 |
| Horn not working (7.7 (a) (ii)) | 2 |
| Offside Rear Lower Suspension arm pin or bush excessively worn inner and outer (5.3.4 (a) (i)) | 2 |
| Offside Rear Lower Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Offside Rear Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Offside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 2 |
| Offside Front Road wheel fixing missing (5.2.1 (a) (i)) | 2 |
| Offside Rear Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Rear Lower Suspension arm pin or bush excessively worn rear (5.3.4 (a) (i)) | 2 |
| Offside Rear Lower Suspension arm pin or bush excessively worn rear (5.3.4 (a) (i)) | 2 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 2 |
| Offside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Offside Rear Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Nearside Rear Outer Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Offside Rear Outer Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Nearside Front Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 2 |
| Offside Rear Road wheel fixing missing (5.2.1 (a) (i)) | 2 |
| Nearside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Offside Rear Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Rear Lower Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Nearside Rear Seat belt buckle not functioning as intended (7.1.2 (d)) | 2 |
| Nearside Rear Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Offside Rear Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 2 |
| Nearside Rear Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Nearside Rear Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Front Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Offside Front Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Offside Rear Upper Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |