| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 47 |
| Parking brake: efficiency below requirements |3.7.B.7| | 32 |
| Windscreen wiper does not clear the windscreen effectively | 26 |
| Rear parking brake recording little or no effort | 18 |
| Rear brake binding | 17 |
| Horn not working |1.6.2a| | 16 |
| Nearside Stop lamp not working |1.2.1b| | 13 |
| Registration plate lamp issues | 11 |
| Offside Stop lamp not working |1.2.1b| | 10 |
| Service brake: efficiency below requirements |3.7.B.7| | 8 |
| Brakes imbalanced across an axle | 7 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 7 |
| Brake hose excessively deteriorated | 7 |
| Windscreen washer not working | 7 |
| Offside Headlamp not working on main beam |1.7.5a| | 7 |
| Steering column top bearing excessively worn |2.1.2c| | 6 |
| Fuel system component leaking |7.2.3| | 6 |
| Brake pipe excessively corroded | 6 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Stop lamp not working |1.2.1b| | 5 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
| Rear Exhaust system not adequately supported |7.1.1| | 4 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
| Brake hose has insufficient room to move | 4 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 4 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 4 |
| Rear brake disc in such a condition that it is seriously weakened | 4 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 3 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Registration plate issues | 3 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 3 |
| Offside Rear Stop lamp not working |1.2.1b| | 3 |
| Rear Stop lamp not working |1.2.1b| | 3 |
| Nearside Rear brake disc contaminated by oil |3.5.1h| | 3 |
| Battery insecure |1.9.1| | 3 |
| Indicator switch faulty |1.4.A.1| | 3 |
| Offside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 3 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 3 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 3 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 3 |
| Parking brake: efficiency below requirements (3.7.B.7) | 3 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Parking brake lever has no reserve travel |3.1.6b| | 3 |
| Service brake: efficiency below requirements |3.7.C.1a| | 3 |
| Offside Indicator tell tale inoperative |1.4.A.2a| | 3 |
| Offside Front Lower Suspension arm ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.4.G.2| | 3 |
| Dipswitch operation does not deflect all main beam headlamps to make them dipped beams |1.7.4b| | 3 |
| Front brake application uneven | 3 |
| Direction indicators not working |1.4.A.2c| | 3 |
| Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 3 |
| Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Power steering pipe|s| or hose|s| leaking |2.3.3b| | 2 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 2 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Front Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Offside Front Wheel insecure |4.2.A.1c| | 2 |
| Driver`s door does not latch securely closed |6.2.B.1a| | 2 |
| Driver`s seat insecure |6.2.A.1| | 2 |
| Fuel tank leaking |7.2.3| | 2 |
| Nearside Front Brake pipe inadequately clipped |3.6.B.1| | 2 |
| Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 2 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Rear Stop lamp not working |1.2.1b| | 2 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Offside Rear brake disc contaminated by oil |3.5.1h| | 2 |
| Offside front brake binding |3.7.B.1| | 2 |
| Nearside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 2 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Headlamp not working on main beam |1.7.5a| | 2 |
| Offside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 2 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Steering column movement between the shaft and steering wheel |2.1.2b| | 2 |
| Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 2 |
| Nearside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Steering pivot point has excessive play |2.2.B.1g| | 2 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 2 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Brake servo vacuum pipe deteriorated |3.6.C.1b| | 2 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 2 |
| Steering box has a significant oil leak |2.2.D.2e| | 2 |
| Horn not working (1.6.2a) | 2 |
| Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 2 |
| Front Brake pipe inadequately supported |3.6.B.1| | 2 |
| Offside Front Lower Ball joint has excessive play |2.2.B.1f| | 2 |
| Exhaust emits dense blue smoke at idle |7.3.A.2b| | 2 |
| Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Offside Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 2 |
| Front Sub-frame attachment rubber mounting bonding deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 2 |
| Nearside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Drag link end ball pin shank loose |2.2.B.1c| | 1 |
| Offside Rear Suspension rod pin or bush excessively worn panhard rod (5.3.4 (a) (i)) | 1 |
| Windscreen has damage | 1 |
| Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Front Lower Suspension arm attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Offside Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Nearside Front Driver`s seat insecure |6.2.A.1| | 1 |
| Nearside Front Brake hose excessively damaged |3.6.B.4d| | 1 |
| Offside Inner Front Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
| Nearside Rear Radius arm locating pin locking device not properly locked |2.4.G.3b| | 1 |
| Nearside Front brake caliper locking device missing |3.5.1l| | 1 |
| Offside Front brake caliper locking device missing |3.5.1l| | 1 |
| Power steering ram leaking (2.1.5 (a)) | 1 |
| Tailgate cannot be secured in the closed position |6.4.1| | 1 |
| Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 1 |
| Fuel tank insecure |7.2.1| | 1 |
| Front Brake pipe leaking |3.6.A.1| | 1 |
| Centre Front Exhaust mounting missing |7.1.1b| | 1 |
| Rear Exhaust mounting missing |7.1.1b| | 1 |
| Brake has no servo assistance |3.3.B.2| | 1 |
| Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Offside Rear Fuel system component insecure |7.2.1| | 1 |
| Centre Exhaust mounting missing |7.1.1b| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
| Fuel system component leaking carburettor |7.2.3| | 1 |
| Nearside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Braking system leaking master cylinder pipe nut |3.6.A.1| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint (2.5.B.1a) | 1 |
| Offside front brake binding (3.7.B.1) | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement (2.4.G.2) | 1 |
| Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Exhaust mounting missing |7.1.1b| | 1 |
| Offside Front Steering column top bearing excessively worn |2.1.2c| | 1 |
| Nearside Front Outer Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Inner Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
| Parking brake: efficiency below requirements |3.7.D.4| | 1 |
| Nearside Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Exhaust emits excessive dense blue smoke during acceleration |7.3.A.2c| | 1 |
| Offside Rear Seat belt locking mechanism does not secure or release (5.2.5a) | 1 |
| Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear Stop lamp not working (1.2.1b) | 1 |
| Offside Front Anti-roll bar linkage insecure (2.4.G.1) | 1 |
| Offside Front Steering rack gaiter split (2.2.D.2d) | 1 |
| Nearside Rear Brake pipe likely to become detached or damaged Fouling fuel tank (1.1.11 (d) (ii)) | 1 |
| Front Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Speedometer clearly inoperative |6.7.2| | 1 |
| Nearside Front Steering rack gaiter split (2.2.D.2d) | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Stop lamp not working (1.2.1b) | 1 |
| Central Front Subframe mounting prescribed area is excessively corroded (2.4.A.3) | 1 |
| Nearside Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Offside Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Nearside Front Upper Seat belt anchorage loose (7.1.1 (b)) | 1 |
| Offside Front Lower Seat belt likely to become detached in the event of a collision (7.1.1 (a) (ii)) | 1 |
| Offside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Brake insecure brake servo reservior (1.1.21 (c)) | 1 |
| Power steering pump leaking (2.1.5 (a)) | 1 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced jacking point (6.1.1 (c) (i)) | 1 |
| Offside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced jacking point (6.1.1 (c) (i)) | 1 |
| Nearside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced jacking point (6.1.1 (c) (i)) | 1 |
| Nearside Front Sub-frame attachment bracket/mounting insecure un bonded (5.3.3 (a) (i)) | 1 |
| Offside Front Sub-frame attachment bracket/mounting insecure un bonded (5.3.3 (a) (i)) | 1 |
| Rear Stop lamp not working (1.2.1b) | 1 |
| Nearside Headlamp not working on dipped beam (1.7.5a) | 1 |
| Nearside Headlamp not working on main beam (1.7.5a) | 1 |
| Offside Rear wheel bearing has excessive play (2.6.2) | 1 |
| Nearside Steering rack gaiter split (2.2.D.2d) | 1 |
| Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings chassis leg |6.1.B.2| | 1 |
| Offside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Outer Drag link end ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Rear Upper Suspension component mounting prescribed area is excessively corroded sill |2.4.A.3| | 1 |
| Offside Front Outer Suspension component mounting prescribed area is excessively corroded sill |2.4.A.3| | 1 |
| Front Lower Steering column flexible coupling is excessively deteriorated |2.1.5| | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Outer Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength jacking point (5.3.6 (a) (i)) | 1 |
| Offside Front Road wheel spoke bent |4.2.A.1b| | 1 |
| Offside Front Road wheel spoke missing |4.2.A.1b| | 1 |
| Offside Outer Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Nearside Inner Steering rack gaiter split |2.2.D.2d| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Brake pedal spongy (3.3.B.1b) | 1 |
| Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Front Wheel insecure |4.2.A.1c| | 1 |
| Nearside Rear Wheel insecure |4.2.A.1c| | 1 |
| Offside Rear Wheel insecure |4.2.A.1c| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Lower Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Lower Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
| Nearside Front brake caliper has restricted free movement |3.5.1k| | 1 |
| Nearside Front front brake recording little or no effort |3.7.B.5a| | 1 |
| Brake pedal fouling on other parts of the vehicle |3.3.A.4| | 1 |
| Steering column will not lock in a fixed position |adjustable type| |2.1.2a| | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Inner Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Inner Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front engine mounting bracket insecure and likely to fail |6.1.D.1b| | 1 |
| Offside Front engine mounting bracket insecure and likely to fail |6.1.D.1b| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Centre Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Rear Tie bar/rod attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Nearside Front Lower Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Nearside Front Shock absorber insecure |2.7.2b| | 1 |
| Offside Front Shock absorber insecure |2.7.2b| | 1 |
| Offside Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Service brake: efficiency below requirements |3.7.D.4| | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Upper Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Front Upper Ball joint dust cover insecure so that it no longer prevents the ingress of dirt Both |2.2.C.1c| | 1 |
| Nearside Rear Radius arm locating pin locking device missing |2.4.G.3b| | 1 |
| Front Headlamp missing |1.7.3| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Anti-roll bar insecurely attached bolt loose (5.3.3 (a) (i)) | 1 |
| Offside Rear Road wheel spoke excessively loose |4.2.A.1b| | 1 |
| Exhaust engine idle speed too high |7.3.A.2a| | 1 |
| Offside Front Track rod end loose |2.2.B.1d| | 1 |
| Offside Front Brake pipe inadequately supported |3.6.B.1| | 1 |
| Offside Front Drivers door cannot be opened from inside the vehicle (6.2.3 (a)) | 1 |
| Offside Front Drivers door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Front position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
| Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Steering column universal joint insecure |2.1.5| | 1 |
| Offside Rear brake caliper leaking |3.6.A.1| | 1 |
| Nearside Rear Shock absorber detached |2.7.2b| | 1 |
| Brake pipe fouled by moving parts rear o/s brake pipe fouling road wheel. (3.6.B.2a) | 1 |
| Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Front Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Offside Rear Position lamp not working side light inoperative (4.2.1 (a) (ii)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect left hand drive light kick up wrong way (4.1.2 (c)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect left hand drive lamp kick up wrong way (4.1.2 (c)) | 1 |
| Nearside Front Direction indicators not working (1.4.A.2c) | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Rear Panhard rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Lower Radius arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Upper Radius arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Lower Radius arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Brake hose inappropriately repaired |3.6.A.3| | 1 |
| Horn not working (7.7 (a)) | 1 |
| Centre Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear Brake back plate|s| securing device loose |3.5.1j| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Offside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Offside Front Outer Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| An item not tested |Manual| | 1 |
| Nearside Front Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Offside Front Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Offside Rear Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Fuel cap/sealing device sealing washer torn |7.2.4c| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Body has a projection caused by corrosion |6.1.C.1| | 1 |
| Offside Rear Body has a projection caused by corrosion |6.1.C.1| | 1 |
| Nearside Rear Body has a projection caused by corrosion |6.1.C.1| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Outer Body or chassis is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Fuel system component leaking (6.1.3 (b) (i)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Rear brake disc contaminated by grease |3.5.1h| | 1 |
| Fuel pipe leaking pipe running under inlet manifold. |7.2.3| | 1 |
| Power steering pump leaking from a failed seal |2.3.3b| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
| Nearside Rear brake caliper leaking |3.6.A.1| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Lower Front suspension ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Intermediate drop arm insecure track rod bush that attaches to intermediate drop arm has excessive play... |2.2.B.1a| | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover missing |2.4.G.2| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wheel arch (5.3.6 (a) (i)) | 1 |
| Nearside Front Headlamp not working on dipped beam (1.7.5a) | 1 |
| Offside Front Headlamp not working on dipped beam (1.7.5a) | 1 |
| Nearside Front Headlamp not working on main beam (1.7.5a) | 1 |
| Offside Front Headlamp not working on main beam (1.7.5a) | 1 |
| Power steering inoperative (2.3.3a) | 1 |
| Offside Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Power steering malfunctioning |2.3.3a| | 1 |
| Offside Front Lower Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Lower Shock absorber insecure |2.7.2b| | 1 |
| Offside Rear Shock absorber insecure |2.7.2b| | 1 |
| Centre Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
| Nearside Rear Leaf spring deteriorated and seriously weakened |2.4.B.1a| | 1 |
| Offside Rear Leaf spring deteriorated and seriously weakened |2.4.B.1a| | 1 |
| Nearside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
| Front Fuel system component leaking |7.2.3| | 1 |
| Windscreen wiper not working (3.4 (a)) | 1 |
| Steering column top bearing excessively worn (2.2.2 (b)) | 1 |
| Nearside Front Lower Shock absorbers insecurely attached bolt loose (5.3.2 (a) (i)) | 1 |
| Nearside Front Seat belt anchorage prescribed area is inadequately repaired |7.1.1 |a| |i|| | 1 |
| Offside Front Seat belt anchorage prescribed area is inadequately repaired |7.1.1 |a| |i|| | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced |6.1.1 |c| |i|| | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced near engine mount |6.1.1 |c| |i|| | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced In wheel arch |6.1.1 |c| |i|| | 1 |
| Nearside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Inner sill |6.1.1 |c| |i|| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Spring mount |5.3.6 |a| |i|| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Spring mount |5.3.6 |a| |i|| | 1 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Intermediate drop arm insecure |2.2.B.1a| | 1 |
| brake disc excessively pitted |3.5.1h| | 1 |
| Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Power steering inoperative |2.3.3a| | 1 |
| Nearside Front position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Front position lamp|s| not working side light |1.1.A.3b| | 1 |
| Vehicle Identification Number not permanently displayed |6.3.5.a| | 1 |
| Nearside engine mounting bracket insecure and likely to fail bolt loose/nut missing |6.1.D.1b| | 1 |
| Offside engine mounting bracket insecure and likely to fail bolt loose |6.1.D.1b| | 1 |
| Offside Rear Wheel insecure wheel loose |4.2.A.1c| | 1 |
| Offside Outer Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Rear passenger seat cannot be secured in the upright position. |6.2.3| | 1 |
| rear brake recording little or no effort |3.7.B.5a| | 1 |
| All position lamps adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Front Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Headlamp not working on dipped beam |1.7.5a| | 1 |
| front parking brake recording little or no effort |3.7.B.6a| | 1 |
| Front front brake binding |3.7.B.1| | 1 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
| Fuel pipe insecure |7.2.1| | 1 |
| Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Rear Shock absorber has an excessively worn bush bottom bush |2.7.4| | 1 |
| Inner Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Inner Front Lower Vehicle structure has an inadequate repair which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Inner Lower Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting cross member under radiator corroded |6.2.2 |d| |i|| | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting and centre outer and inner sill corroded |6.2.2 |d| |i|| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings outrigger |6.1.B.2| | 1 |
| Offside Front Brake hose leaking |3.6.A.1| | 1 |
| Nearside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Service brake is causing the vehicle to swerve to the offside |3.7.C.2| | 1 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Rear Upper Suspension arm attachment bracket/mounting cracked |2.4.G.1| | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced sill (around jacking point) (6.1.1 (c) (i)) | 1 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Nearside Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Nearside front brake juddering severely |3.7.A.2b| | 1 |
| Nearside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Steering retaining device insecure |2.2.C.1g| | 1 |
| Offside Front Steering retaining device insecure |2.2.C.1g| | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 1 |
| Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt all front joint dust covers nearside and offside front |2.4.G.2| | 1 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Direction indicator not working not working when switched on |1.4.A.2c| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Offside Lower Seat belt anchorage prescribed area is excessively corroded `B` Pillar inner sill holed and corroded |5.2.6| | 1 |
| Nearside Rear Leaf spring anchor bracket corroded and seriously weakened |2.4.B.6d| | 1 |
| Steering system excessively rough |2.2.D.1| | 1 |
| Brake performance not tested no brakes |3.7.A.1| | 1 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
| Lower Steering column universal joint has excessive play |2.1.5| | 1 |
| Lower Steering column flexible coupling has excessive play |2.1.5| | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Front Direction indicators not working nearside and offside |1.4.A.2c| | 1 |
| Rear Direction indicators not working nearside and offside |1.4.A.2c| | 1 |
| Front Inner Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt nearside and offside |2.2.C.1c| | 1 |
| Front Outer Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt nearside and offside |2.2.C.1c| | 1 |
| Front Sub-frame attachment rubber mounting deteriorated resulting in excessive movement nearside and offside |2.4.G.2| | 1 |
| Central Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear Panhard rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Upper Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Leaf spring has excessive wear in an anchor pin and/or bush nearside and offside |2.4.B.2| | 1 |
| Offside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Front Braking system leaking caliper |3.6.A.1| | 1 |
| Offside Front Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Wheel nut|s| loose |4.2.A.1e| | 1 |
| Nearside Rear Wheel nut|s| loose |4.2.A.1e| | 1 |
| Offside Rear Wheel nut|s| loose |4.2.A.1e| | 1 |
| Nearside Inner Track rod end ball joint dust cover missing |2.2.C.1c| | 1 |
| Offside Inner Track rod end ball joint dust cover missing |2.2.C.1c| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Lower Front suspension ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Driver`s door catch insecure |6.2.B.2| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded crossmember |2.4.A.3| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Parking brake: efficiency below requirements (3.7.C.1b) | 1 |
| Offside Front Upper Suspension arm ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.4.G.2) | 1 |
| Central Rear Prop shaft securing bolt loose prop to rear diff bolts (6.1.7 (a) (i)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Rear Lower Suspension arm has excessive play in a pin/bearing |2.4.G.2| | 1 |
| Fuel system component insecure |7.2.1| | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Front Sub-frame rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Statutory seat belt missing |5.1.1| | 1 |
| Offside Front Statutory seat belt missing |5.1.1| | 1 |
| Nearside Rear Brake disc contaminated |1.1.14 |b|| | 1 |
| Offside Rear Brake disc contaminated |1.1.14 |b|| | 1 |
| Fuel system component leaking carb leaking |7.2.3| | 1 |
| Offside Rear Lower Panhard rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Lower Steering column shaft locking device missing |2.1.6| | 1 |
| Nearside Front Inner Drag link end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Rear Brake disc contaminated (1.1.14 (b)) | 1 |
| Offside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Lower Steering column universal joint insecure (2.1.3 (a) (i)) | 1 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Rear Service brake excessively binding both (1.2.1 (f)) | 1 |
| Indicator switch inoperative do not operate o/s indicators (4.4.2 (a) (ii)) | 1 |