Most common failures | No# failures |
---|
Parking brake: efficiency below requirements |3.7.B.7| | 10 |
Headlamp aim out of alignment | 6 |
Windscreen wiper does not clear the windscreen effectively | 6 |
Nearside Headlamp not working on main beam |1.7.5a| | 5 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 5 |
Offside Headlamp not working on main beam |1.7.5a| | 5 |
Offside Stop lamp not working |1.2.1b| | 4 |
Front brake application uneven | 4 |
Rear brake binding | 4 |
Brakes imbalanced across an axle | 4 |
Registration plate lamp issues | 4 |
Offside Headlamp not working on dipped beam |1.7.5a| | 4 |
Service brake: efficiency below requirements |3.7.B.7| | 3 |
Parking brake: efficiency below requirements |3.7.C.1b| | 3 |
Rear Exhaust system not adequately supported |7.1.1| | 3 |
Nearside Stop lamp not working |1.2.1b| | 3 |
Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
Steering column top bearing excessively worn |2.1.2c| | 3 |
Horn not working |1.6.2a| | 3 |
Rear parking brake recording little or no effort | 2 |
Nearside Front Direction indicator not working |1.4.A.2c| | 2 |
Brake pipe excessively corroded | 2 |
Nearside Front Headlamp not working on main beam |1.7.5a| | 2 |
Nearside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
Offside Steering rack gaiter split |2.2.D.2d| | 2 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
Nearside Rear brake disc contaminated by oil |3.5.1h| | 2 |
Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
Power steering component|s| leaking |2.3.3b| | 2 |
Fuel system component leaking |7.2.3| | 2 |
Nearside Indicator tell tale inoperative |1.4.A.2a| | 2 |
Rear Mechanical brake component has restricted free movement | 2 |
Offside Front Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 2 |
Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 2 |
Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Brake hose excessively deteriorated | 1 |
Parking brake efficiency below requirements |3.7.C.1b| | 1 |
Nearside Front brake caliper leaking |3.6.A.1| | 1 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Brake pipe inadequately clipped |3.6.B.1| | 1 |
Fuel system component insecure |7.2.1| | 1 |
Steering box insecure |2.2.B.1a| | 1 |
Nearside Steering component is not secure to the vehicle structure |2.2.B.1a| | 1 |
Front Sub-frame attachment bracket/mounting insecure |2.4.G.1| | 1 |
Offside Rear Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Centre Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Fuel system component leaking (6.1.3 (b) (i)) | 1 |
Nearside Front Drag link end seriously misaligned (2.1.3 (e)) | 1 |
Offside Front Drag link end seriously misaligned (2.1.3 (e)) | 1 |
Nearside Rear Stop lamp not working |1.2.1b| | 1 |
Offside Rear Stop lamp not working |1.2.1b| | 1 |
Offside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Inner Front Upper Front suspension locking device missing |2.5.A.4| | 1 |
Offside Inner Front Upper Front suspension locking device missing |2.5.A.4| | 1 |
Nearside Headlamp has a product on the light source so that the light output is severely reduced |1.7.5a| | 1 |
Headlamp not working on dipped beam both |1.7.5a| | 1 |
Headlamp not working on main beam both |1.7.5a| | 1 |
Front position lamp|s| not working both |1.1.A.3b| | 1 |
Rear position lamp|s| not working both |1.1.A.3b| | 1 |
Headlamp not working on main beam |1.7.5a| | 1 |
Fuel cap/sealing device sealing washer torn |7.2.4c| | 1 |
Nearside Front Headlamp aim not tested |1.8.A.1c| | 1 |
Offside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
Offside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Front Mechanical brake component locking device missing |3.5.1l| | 1 |
Offside Front Mechanical brake component locking device missing |3.5.1l| | 1 |
Centre Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Braking system leaking |3.6.A.1| | 1 |
Mechanical brake component has restricted free movement | 1 |
Front Fuel system component leaking |7.2.3| | 1 |
Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Front Lower Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Steering pivot point has excessive play |2.2.B.1g| | 1 |
Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
Nearside Front Lower Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Lower Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Front Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
brake disc contaminated by oil |3.5.1h| | 1 |
Nearside front brake binding |3.7.B.1| | 1 |
Offside front brake binding |3.7.B.1| | 1 |
Exhaust system not adequately supported |7.1.1| | 1 |
Nearside Rear Fuel pipe insecure |7.2.1| | 1 |
Nearside Front Vehicle structure is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Power steering component|s| leaking from a failed seal |2.3.3b| | 1 |
Steering system excessively rough |2.2.D.1| | 1 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Nearside Front position lamp|s| not working When switched on to side position. |1.1.A.3b| | 1 |
Parking brake lever has no reserve travel |3.1.6b| | 1 |
Power steering pump leaking from a failed component |2.3.3b| | 1 |
Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
Steering rack gaiter split |2.2.D.2d| | 1 |
Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Bonnet cannot be secured in the closed position |8.4.1| | 1 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Front Lower Front suspension retaining device missing |2.5.A.4| | 1 |
Offside Front Lower Front suspension locking device missing |2.5.A.4| | 1 |
Nearside Rear Lower Front suspension retaining device ineffective |2.5.A.4| | 1 |
Nearside Rear Lower Front suspension locking device ineffective |2.5.A.4| | 1 |
Offside Rear Lower Front suspension retaining device ineffective |2.5.A.4| | 1 |
Offside Rear Lower Front suspension locking device ineffective |2.5.A.4| | 1 |
Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Nearside Rear brake caliper leaking |3.6.A.1| | 1 |
Offside Rear brake caliper leaking |3.6.A.1| | 1 |
Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 1 |
Service brake: efficiency below requirements |3.7.C.1a| | 1 |
Indicator switch faulty |1.4.A.1| | 1 |
Nearside Front Power steering pipe|s| or hose|s| leaking from a seal |2.3.3b| | 1 |
Offside Front Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
Brake pedal has insufficient reserve movement |3.3.A.5| | 1 |
Exhaust emits dense blue smoke at idle |7.3.A.2b| | 1 |
Battery insecure |1.9.1| | 1 |
Power steering component|s| leaking rack area |2.3.3b| | 1 |
brake disc in such a condition that it is seriously weakened all |3.5.1i| | 1 |
Nearside Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Lower Steering pivot point has excessive play |2.2.B.1g| | 1 |
Centre Front Brake pipe inadequately supported |3.6.B.1| | 1 |
Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
Offside Rear Lower Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front Ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Rear Stub axle has excessive vertical movement between stub axle and axle beam |2.5.A.1a| | 1 |
Bonnet retaining device ineffective |8.4.2| | 1 |
Horn control insecure |1.6.1| | 1 |
Nearside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Vehicle Identification Number not permanently displayed |6.3.5.a| | 1 |
Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
Steering box has a significant oil leak |2.2.D.2e| | 1 |
Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
Offside Front Sub-frame attachment rubber mounting bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Front Sub-frame attachment rubber mounting bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Nearside Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Offside Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Anti-roll bar linkage severely distorted |2.4.G.1| | 1 |
Nearside Rear Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
Nearside Headlamp light source and lamp not compatible |4.1.4 |c|| | 1 |
Offside Headlamp light source and lamp not compatible |4.1.4 |c|| | 1 |
Offside Front Sub-frame rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Stop lamp not working |1.2.1b| | 1 |
Speedometer cannot be illuminated. |6.7.3| | 1 |
Fuel cap/sealing device mounting flange/sealing method defective |7.2.4c| | 1 |
Offside Front Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Electrical wiring inadequately supported |1.9.2a| | 1 |
Nearside Front Anti-roll bar linkage missing |2.4.G.1| | 1 |
Offside Front Anti-roll bar linkage missing |2.4.G.1| | 1 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Rear Stop lamp not working |1.2.1b| | 1 |