Most common failures | No# failures |
---|
Registration plate lamp issues | 48 |
Parking brake: efficiency below requirements |3.7.B.7| | 37 |
Brake pipe excessively corroded | 37 |
Rear parking brake recording little or no effort | 25 |
Headlamp aim out of alignment | 19 |
Service brake: efficiency below requirements |3.7.B.7| | 18 |
Brakes imbalanced across an axle | 11 |
Windscreen wiper does not clear the windscreen effectively | 8 |
Offside Rear fog lamp not working |1.3.2b| | 7 |
Parking brake lever has no reserve travel |3.1.6b| | 7 |
Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 6 |
Rear brake binding | 6 |
Horn not working |1.6.2a| | 6 |
Exhaust has a major leak of exhaust gases |7.1.2| | 6 |
Offside Front position lamp|s| not working |1.1.A.3b| | 5 |
Nearside Headlamp not working on main beam |1.7.5a| | 4 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 4 |
Rear fog lamp not working |1.3.2b| | 4 |
Battery insecure |1.9.1| | 4 |
Brake load sensing valve inoperative |3.6.E.3| | 4 |
Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 4 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 4 |
Service brake efficiency below requirements (1.2.2 (a) (i)) | 4 |
Offside Headlamp not working on main beam |1.7.5a| | 3 |
Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 3 |
Brake load sensing valve seized |3.6.E.3| | 3 |
Brake load sensing valve linkage seized |3.6.E.3| | 3 |
Parking brake efficiency below requirements |1.4.2 |a| |i|| | 3 |
Offside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 3 |
Offside front brake binding |3.7.B.1| | 3 |
Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 3 |
Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 3 |
Nearside Stop lamp not working |1.2.1b| | 3 |
Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
Rear Brake load sensing valve linkage seized |3.6.E.3| | 3 |
Windscreen wiper blade insecure | 3 |
Nearside Windscreen wiper blade deteriorated |8.2.2| | 2 |
Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 2 |
Nearside Rear Stop lamp not working |1.2.1b| | 2 |
Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
Nearside Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Offside Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 2 |
Nearside Front front brake binding |3.7.B.1| | 2 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
Registration plate issues | 2 |
Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
Offside Stop lamp not working |1.2.1b| | 2 |
Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 2 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 2 |
Brake hose damaged | 2 |
Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
Nearside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 2 |
Brake pedal anti-slip provision incomplete |3.3.A.1b| | 1 |
Nearside Headlamp insecure |1.7.3| | 1 |
Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
Nearside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Rear Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Rear Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
Offside Front Braking system leaking |3.6.A.1| | 1 |
Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Rear Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
Electrical wiring damaged, likely to cause a short |1.9.2b| | 1 |
Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Centre Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Offside Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
Nearside Rear Brake pipe leaking in chassis |3.6.A.1| | 1 |
Nearside Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Brake hose has insufficient room to move | 1 |
Nearside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
Offside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
Fuel system component leaking |7.2.3| | 1 |
Battery insecure and likely to cause a short circuit |4.13 |a| |ii|| | 1 |
Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
Offside Headlamp aim not tested |4.1.2 |b|| | 1 |
Nearside Rear fog lamp does not emit a steady red light showing white light |4.5.4 |a|| | 1 |
Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting |6.2.2 |d| |i|| | 1 |
Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
Windscreen has damage | 1 |
Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Rear brake disc excessively pitted |3.5.1h| | 1 |
Brake servo leaking |3.6.C.1c| | 1 |
Front Exhaust emissions likely to be affected by an exhaust leak |8.2.2.1 |b|| | 1 |
Exhaust emissions exceed level of metered smoke for a turbo charged engine |8.2.2.2 |b|| | 1 |
Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
Nearside Inner Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Speedometer cannot be illuminated. |6.7.3| | 1 |
Rear Electrical wiring insecure |1.9.2a| | 1 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside Rear Leaf spring to axle securing bolt insecure |2.4.B.7b| | 1 |
Offside Rear Leaf spring to axle securing bolt insecure |2.4.B.7b| | 1 |
Offside Front front brake binding |3.7.B.1| | 1 |
Nearside Electrical wiring insecure |1.9.2a| | 1 |
Electrical wiring insecure underside earth lead |1.9.2a| | 1 |
rear parking |secondary| brakes imbalanced | 1 |
Front brake excessively fluctuating | 1 |
Front brake application uneven | 1 |
front brakes release unevenly |3.7.B.4| | 1 |
Offside Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Electrical wiring insecure offside under bonet |1.9.2a| | 1 |
Electrical wiring insecure nearside under bonet |1.9.2a| | 1 |
Electrical wiring insecure in cab |1.9.2a| | 1 |
Electrical wiring deteriorated, likely to become detached under bonet on nearside of engine |1.9.2b| | 1 |
Offside Brake master cylinder/servo mounting prescribed area is excessively corroded under bonet |3.6.C.3| | 1 |
Brake pedal anti-slip provision loose |3.3.A.1b| | 1 |
Mechanical brake component has restricted free movement | 1 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Front brake caliper leaking |3.6.A.1| | 1 |
Offside Rear Brake pipe leaking |3.6.A.1| | 1 |
Nearside Rear Leaf spring to axle securing nut insecure |2.4.B.7b| | 1 |
Offside Leaf spring to axle securing nut insecure |2.4.B.7b| | 1 |
Nearside Front Brake hose excessively twisted (1.1.12 (b) (ii)) | 1 |
Offside Front Side repeater not working |1.4.A.2c| | 1 |
Anti-lock braking system warning lamp indicates an ABS fault | 1 |
Offside Front Upper Suspension component ball joint excessively worn |5.3.4 |a| |i|| | 1 |
Offside Front Lower Suspension component ball joint excessively worn |5.3.4 |a| |i|| | 1 |
Power steering pipe/hose leaking |2.1.5 |a|| | 1 |
Steering rack has excessive free play detected at the steering wheel to the extent that safe steering is affected |steering rack fitted| |2.3 |a| |ii|| | 1 |
Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 1 |
Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Vehicle structure is damaged, seriously affecting its strength within 30cm of the body mountings NS of front cross member at lower suspension arm |6.1.B.2| | 1 |
Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Brake load sensing valve has been disconnected and was fitted as standard |3.6.E.2| | 1 |
Fuel tank leaking |7.2.3| | 1 |
Nearside Ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Rear Leaf spring cracked |2.4.B.1a| | 1 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Rear Rear fog lamp adversely affected by the operation of another lamp |1.3.2f| | 1 |
Nearside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Front Statutory seat belt missing |5.1.1| | 1 |
Nearside All position lamps not working |1.1.A.3b| | 1 |
Rear Body has a projection caused by damage |6.1.C.1| | 1 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Offside Rear Direction indicator excessively deteriorated so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
Nearside Rear Direction indicator excessively deteriorated so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
Offside Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
Nearside Side repeater incorrect colour |1.4.A.2f| | 1 |
Nearside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Offside Rear brake caliper has restricted free movement |3.5.1k| | 1 |
Rear Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Rear Fuel pipe leaking |7.2.3| | 1 |
Offside Front Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced inner sill (6.1.1 (c) (i)) | 1 |
Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
Offside Front Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced |6.1.1 |c| |i|| | 1 |
Nearside Front Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced |6.1.1 |c| |i|| | 1 |
Offside Front Lower Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced |6.1.1 |c| |i|| | 1 |
Nearside Front Lower Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced |6.1.1 |c| |i|| | 1 |
Windscreen washer not working | 1 |
Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
Front Exhaust has a major leak of exhaust gases hole in exhaust box |7.1.2| | 1 |
Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Rear Brake rod insecure load valve |3.5.1d| | 1 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner chasis tube |6.1.B.2| | 1 |
Offside Obligatory mirror missing |8.1.1| | 1 |
Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Nearside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Seat belt retracting mechanism defective |5.2.5b| | 1 |
Fuel cap/sealing device sealing washer deteriorated |7.2.4c| | 1 |
Indicator switch faulty |1.4.A.1| | 1 |
Offside Ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Upper Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
Fuel system component insecure |7.2.1| | 1 |
Offside Obligatory mirror insecure |8.1.1| | 1 |
Headlamp switch faulty |1.7.1| | 1 |
Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Anti-roll bar linkage fractured |2.4.G.1| | 1 |
Body component corroded and likely to cause injury tipper frame a number of holes (6.2.1 (a) (i)) | 1 |
Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
Nearside Front Direction indicator incomplete |1.5.A1b| | 1 |
Nearside Obligatory mirror insecure |8.1.1| | 1 |
Nearside Seat belt retracting mechanism defective |5.2.5b| | 1 |
Horn not working |7.7 |a| |ii|| | 1 |
Offside Rear Leaf spring missing and directional control affected moved |5.3.1 |c| |ii|| | 1 |
Front Position lamp not working n/s and o/s |4.2.1 |a|| | 1 |
Headlamp aim not tested |4.1.2 |b|| | 1 |
Headlamp not working on dipped beam n/s and o/s |4.1.1 |a| |ii|| | 1 |
Offside Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
Nearside Front Electrical wiring likely to touch hot or rotating parts by wheel |4.11 |a| |iii|| | 1 |
Exhaust has a major leak of exhaust gases silencer |7.1.2| | 1 |
Nearside Front Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Offside Front Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Offside Rear reflector missing |1.5.1a| | 1 |
Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Offside Rear fog lamp does not emit a steady red light |1.3.2e| | 1 |
Rear brake application uneven | 1 |
rear brakes release unevenly |3.7.B.4| | 1 |
Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
Front Exhaust has a major leak of exhaust gases before flexi pipe (6.1.2 (a)) | 1 |
Nearside Front Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
Bonnet retaining device ineffective |8.4.2| | 1 |
Nearside front parking brake recording little or no effort |3.7.B.6a| | 1 |
Offside front parking brake recording little or no effort |3.7.B.6a| | 1 |
Nearside Inner Rear Braking system leaking |3.6.A.1| | 1 |
Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Nearside Rear Leaf spring shackle bracket loose |2.4.B.6a| | 1 |
Offside Rear Leaf spring shackle bracket loose |2.4.B.6a| | 1 |
Nearside Rear brake disc excessively scored |3.5.1h| | 1 |
Brake relay lever has restricted free movement |3.5.1k| | 1 |
Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
Brake hose excessively deteriorated | 1 |
Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Rear Anti-roll bar synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Rear Anti-roll bar synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Lower Shock absorber has an excessively worn shock absorber pivot |2.7.4| | 1 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Rear brake disc in such a condition that it is seriously weakened | 1 |
Rear fog lamp tell tale not working |1.3.1b| | 1 |
Offside Front Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
Nearside Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Rear Rear position lamp|s| incomplete |1.1.4a| | 1 |
Offside Rear Rear position lamp|s| incomplete |1.1.4a| | 1 |
Nearside Rear Leaf spring saddle is moving relative to the spring |2.4.B.7a| | 1 |
Offside Rear Leaf spring eye defective |anchor| |2.4.B.1b| | 1 |
Offside Steering column shaft excessively corroded and unserviceable |2.2.C.1d| | 1 |
Offside Rear fog lamp emits a light other than red |1.3.2e| | 1 |
Nearside Direction indicators incorrect colour |1.4.A.2f| | 1 |
Nearside Front Brake hose twisted |3.6.B.4c| | 1 |
Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Front Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
Offside Front Direction indicator incomplete |1.5.A1b| | 1 |
Offside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Rear Brake valve insecurely mounted |3.6.A.2a| | 1 |