Most common failures | No# failures |
---|
Parking brake: efficiency below requirements |3.7.B.7| | 45 |
Registration plate lamp issues | 38 |
Brake pipe excessively corroded | 36 |
Headlamp aim out of alignment | 24 |
Service brake: efficiency below requirements |3.7.B.7| | 23 |
Rear parking brake recording little or no effort | 17 |
Windscreen wiper does not clear the windscreen effectively | 16 |
Brakes imbalanced across an axle | 16 |
Brake hose excessively deteriorated | 8 |
Nearside Stop lamp not working |1.2.1b| | 7 |
Rear brake binding | 6 |
Horn not working |1.6.2a| | 6 |
Fuel system component leaking |7.2.3| | 6 |
Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 5 |
Offside Front position lamp|s| not working |1.1.A.3b| | 5 |
Offside Rear fog lamp not working |1.3.2b| | 5 |
Offside Front brake disc excessively pitted |3.5.1h| | 5 |
Nearside Side repeater not working |1.4.A.2c| | 5 |
Fuel system component insecure |7.2.1| | 4 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 4 |
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 4 |
Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 4 |
Parking brake: efficiency below requirements |3.7.D.4| | 4 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 4 |
Rear Exhaust system not adequately supported |7.1.1| | 4 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 4 |
Nearside Outer Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 3 |
Front brake disc in such a condition that it is seriously weakened | 3 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
Front Fuel system component insecure |7.2.1| | 3 |
Registration plate issues | 3 |
Rear brake application uneven | 3 |
Nearside Front brake disc excessively pitted |3.5.1h| | 3 |
Emissions not tested |7.0| | 3 |
Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
Nearside Front Direction indicator not working |1.4.A.2c| | 3 |
Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Nearside Front Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 2 |
Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
Offside Outer Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 2 |
Front Exhaust system not adequately supported |7.1.1| | 2 |
Nearside Rear position lamp|s| not in a clean condition and function impaired |1.1.4a| | 2 |
Nearside Rear Direction indicator not working |1.4.A.2c| | 2 |
Power steering component|s| leaking |2.3.3b| | 2 |
Exhaust system not adequately supported |7.1.1| | 2 |
Offside Stop lamp not working |1.2.1b| | 2 |
Nearside Rear Stop lamp not working |1.2.1b| | 2 |
Fuel cap/sealing device sealing washer missing |7.2.4c| | 2 |
All position lamps not working |1.1.A.3b| | 2 |
Offside Headlamp not working on main beam |1.7.5a| | 2 |
Windscreen has damage | 2 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
Windscreen wiper blade insecure | 2 |
Offside Front Body has a sharp edge caused by damage |6.1.C.1| | 2 |
Offside Windscreen wiper blade deteriorated |8.2.2| | 2 |
Nearside Rear Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement |2.4.B.2| | 2 |
Offside Front Side repeater not working |1.4.A.2c| | 2 |
Nearside Front Body has a sharp edge caused by damage |6.1.C.1| | 2 |
Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
Centre Statutory seat belt missing |5.1.1| | 2 |
Brake performance not tested |3.7.A.1| | 2 |
Nearside Front brake disc excessively scored |3.5.1h| | 2 |
Offside Side repeater not working |1.4.A.2c| | 2 |
Offside Front Brake hose twisted |3.6.B.4c| | 2 |
Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
Nearside Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
Offside Rear Leaf spring fractured |2.4.B.1a| | 2 |
Offside Rear Leaf spring cracked |2.4.B.1a| | 2 |
Brake pedal has insufficient reserve movement |3.3.A.5| | 2 |
Steering rack insecure |2.2.B.1a| | 2 |
Nearside Front Upper Shock absorber insecure |2.7.2b| | 2 |
Nearside Steering arm has relative movement at its fixings |2.2.B.1h| | 2 |
Offside Steering arm has relative movement at its fixings |2.2.B.1h| | 2 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
brake disc in such a condition that it is seriously weakened |3.5.1i| | 1 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Offside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Nearside Front position lamp|s| not in good working order |not working| |1.1.4a| | 1 |
Driving control|s| obstructed or impeded in its travel |6.8.1c| | 1 |
Stop lamp remains on when the brakes are released | 1 |
Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Outer Rear position lamp|s| incomplete |1.1.4a| | 1 |
Offside Rear position lamp|s| insecure |1.1.A.3a| | 1 |
Offside Rear Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
Rear passenger door does not latch securely closed |6.2.B.1a| | 1 |
Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
Offside Rear Upper Shock absorber has an excessively worn bush |2.7.4| | 1 |
Nearside Front Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
Steering system excessively rough |2.2.D.1| | 1 |
Steering system fouling |2.2.D.2a| | 1 |
Windscreen wiper blade deteriorated |8.2.2| | 1 |
Offside Front Side repeater missing |1.4.A.2b| | 1 |
Offside Rear rear brake grabbing severely |3.7.A.5b| | 1 |
Nearside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Offside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
Nearside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear rear brake grabbing severely |3.7.A.5b| | 1 |
Nearside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
Offside Front Braking system leaking |3.6.A.1| | 1 |
Offside Fuel system component insecure |7.2.1| | 1 |
Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
Rear Stop lamp emits other than a steady red light |1.2.1e| | 1 |
Front Track rod end ball pin shank loose |2.2.B.1c| | 1 |
Offside Rear Rear position lamp|s| incomplete |1.1.4a| | 1 |
Offside Rear Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Nearside Rear Leaf spring eye defective |shackle| |2.4.B.1b| | 1 |
Nearside Front Loading door cannot be secured in the closed position |6.4.1| | 1 |
Nearside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
Nearside Front Side repeater insecure |1.4.A.2b| | 1 |
Centre Exhaust has a part missing |7.1.1a| | 1 |
Offside Front Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Stop lamp not working |1.2.1b| | 1 |
Offside Rear Upper Direction indicator incorrect colour |1.4.A.2f| | 1 |
Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |
Nearside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
Steering column universal joint has excessive play |2.1.5| | 1 |
Parking brake lever has no reserve travel |3.1.6b| | 1 |
Offside Rear Anti-roll bar linkage fractured |2.4.G.1| | 1 |
Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
Nearside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Mechanical brake component has restricted free movement | 1 |
Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside Headlamp flickers when tapped lightly by hand |1.2.4c| | 1 |
Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
Nearside External window not made of safety glass, or from safety glazing |on or after 1st June 1978| |6.11.6b| | 1 |
Offside External window not made of safety glass, or from safety glazing |on or after 1st June 1978| |6.11.6b| | 1 |
Upper Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Rear Leaf spring longitudinally displaced |2.4.B.1d| | 1 |
Offside Rear Leaf spring longitudinally displaced |2.4.B.1d| | 1 |
Nearside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
Offside Front Brake pipe excessively chafed |3.6.B.2c| | 1 |
rear brakes release unevenly |3.7.B.4| | 1 |
Nearside Front Side repeater not working |1.4.A.2c| | 1 |
Offside Inner Rear Valve stem seriously damaged |4.1.D.1e| | 1 |
Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
Offside Front Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
Brake pedal pad not secure to the pedal |3.3.A.1c| | 1 |
Centre Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
Offside Front Brake pipe inadequately supported |3.6.B.1| | 1 |
Nearside Rear An item not tested |Manual| | 1 |
Offside Front Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Headlamp aim not tested |1.8.A.1c| | 1 |
An item not tested |Manual| | 1 |
Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Offside Rear Rear fog lamp not visible from a reasonable distance |1.1.6b| | 1 |
Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Front Torsion bar fractured |2.4.E.1a| | 1 |
Parking brake lever defective so that it cannot be satisfactorily operated |3.1.3c| | 1 |
Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
Brake master cylinder leaking hydraulic fluid |3.6.G.1f| | 1 |
Nearside Front Suspension arm attachment bracket/mounting insecure |2.4.G.1| | 1 |
Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Offside Rear Leaf spring to axle securing bolt insecure |2.4.B.7b| | 1 |
Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Offside Front Fuel system component insecure |7.2.1| | 1 |
Front Lower Steering component is not secure to the vehicle structure |2.2.B.1a| | 1 |
Centre Brake cable has restricted free movement |3.5.1k| | 1 |
Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Fuel cap/sealing device mounting flange/sealing method defective |7.2.4c| | 1 |
Offside Rear Direction indicator incomplete |1.5.A1b| | 1 |
Nearside Stop lamp excessively deteriorated so that it is not visible from a reasonable distance |1.2.1d| | 1 |
Nearside Front Torsion bar attachment bracket loose |2.4.E.4a| | 1 |
Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Rear Leaf spring has excessive side play at eye |anchor| |2.4.B.4| | 1 |
Offside Rear Leaf spring has excessive side play at eye |anchor| |2.4.B.4| | 1 |
Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Offside Rear fog lamp excessively damaged so that it is not visible from a reasonable distance |1.3.2d| | 1 |
Direction indicator excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
Nearside Rear Torsion bar attachment bracket loose |2.4.E.4a| | 1 |
Nearside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Nearside Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Nearside Statutory seat belt missing |5.1.1| | 1 |
Rear Rear fog lamp not working |1.3.2b| | 1 |
Rear Rear fog lamp tell tale not working |1.3.1b| | 1 |
Offside Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
Nearside Outer Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Outer Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Upper Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Upper Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front Suspension has inadequate clearance with the chassis |2.4.A.1a| | 1 |
Nearside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Offside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Offside Front Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Rear Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
Nearside Rear Leaf spring cracked |2.4.B.1a| | 1 |
Rear Leaf spring cracked |2.4.B.1a| | 1 |
Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Rear Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
Offside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Offside Rear Anti-roll bar attachment bracket/mounting fractured |2.4.G.1| | 1 |
Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Wheel nut|s| loose |4.2.A.1e| | 1 |
Brake valve leaking |3.6.A.1| | 1 |
Nearside Front Torque/reaction arm has a deteriorated rubber bush resulting in excessive movement |2.4.G.2| | 1 |
Brake hose has insufficient room to move | 1 |
Offside Exhaust mounting missing |7.1.1b| | 1 |
Nearside Front Lower Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Brake load sensing valve linkage seized |3.6.E.3| | 1 |
Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Offside Headlamp aim not tested |1.8.A.1c| | 1 |
Nearside Front Shock absorber insecure |2.7.2b| | 1 |
Brake vacuum build up too slow |3.3.E.6| | 1 |
Nearside Front suspension locking device missing |2.5.A.4| | 1 |
Offside Front suspension locking device missing |2.5.A.4| | 1 |
Offside Ball joint has excessive play |2.2.B.1f| | 1 |
Offside Outer Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
Offside Rear fog lamp emits a light other than red |1.3.2e| | 1 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Front Braking system leaking |3.6.A.1| | 1 |
Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Rear Leaf spring fractured |2.4.B.1a| | 1 |
Offside Rear Leaf spring shackle bracket loose |2.4.B.6a| | 1 |
Offside Front Brake pipe leaking |3.6.A.1| | 1 |
Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
Nearside Front Lower Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Nearside Rear Lower Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Offside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Nearside Front suspension has a suspension lower ball joint securing nut not locked |2.5.B.1a| | 1 |
Steering system excessively tight |2.2.D.1| | 1 |
Nearside Upper Ball joint excessively corroded and unserviceable |2.2.C.1d| | 1 |
Nearside Side repeater incomplete |1.5.A1b| | 1 |
Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
Nearside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
Offside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Nearside Front Body has a projection caused by damage |6.1.C.1| | 1 |
Nearside Track rod end loose |2.2.B.1d| | 1 |
Offside Track rod end loose |2.2.B.1d| | 1 |
Rear Brake load sensing valve linkage seized |3.6.E.3| | 1 |
Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Service brake: efficiency below requirements |3.7.D.4| | 1 |
Nearside Front Brake hose twisted |3.6.B.4c| | 1 |
Offside Front Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Brake pedal spongy |3.3.B.1b| | 1 |
Brake pedal reservoir fluid level decreases after several brake applications |3.3.C.1| | 1 |
Nearside Front Brake pipe leaking |3.6.A.1| | 1 |
Offside Front brake disc excessively scored |3.5.1h| | 1 |
Nearside Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
Nearside rear brakes release unevenly |3.7.B.4| | 1 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Nearside Headlamp not working on main beam |1.7.5a| | 1 |