| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 18 |
| Headlamp aim out of alignment | 12 |
| Windscreen wiper does not clear the windscreen effectively | 8 |
| Service brake: efficiency below requirements |3.7.B.7| | 7 |
| Parking brake: efficiency below requirements |3.7.B.7| | 7 |
| Registration plate issues | 6 |
| Brake pipe excessively corroded | 5 |
| Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 4 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 4 |
| Horn not working |1.6.2a| | 4 |
| Brakes imbalanced across an axle | 3 |
| Rear fog lamp not working |1.3.2b| | 3 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Rear parking brake recording little or no effort | 3 |
| Offside Rear Stop lamp emits other than a steady red light |1.2.1e| | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Offside Front Upper Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 2 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 2 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Brake pedal has insufficient reserve movement |3.3.A.5| | 1 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Front Wheel stud|s| missing |4.2.A.1e| | 1 |
| Fuel cap/sealing device missing |7.2.4a| | 1 |
| Nearside Inner Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Brake hose twisted |3.6.B.4c| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Centre Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Front Seat belt insecurely fixed to the seat |5.2.1a| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Rear Outline marker lamp missing (4.2.1 (a) (ii)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Outline marker lamp likely to become detached (4.2.1 (c) (ii)) | 1 |
| Offside Rear Hydraulic brake calliper leaking (1.1.16 (b) (i)) | 1 |
| Brake performance unable to be tested Due to failed brake pipe at NSR (1.2.1 (g)) | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Rear brake binding | 1 |
| Brake load sensing valve inoperative and ABS not fitted or inoperative |1.1.17 |c| |ii|| | 1 |
| Fuel system component leaking excessively or a risk of fire fuel filter |6.1.3 |b| |ii|| | 1 |
| Nearside Rear Leaf spring main leaf fractured anchor eye broken off |5.3.1 |b| |ii|| | 1 |
| Spare wheel carrier insecure |6.1.5 |a|| | 1 |
| Nearside Front Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting inner panel |6.2.2 |d| |i|| | 1 |
| Offside Front Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting inner panel |6.2.2 |d| |i|| | 1 |
| Brake load sensing valve linkage defective and function impaired siezed |1.1.17 |a|| | 1 |
| Offside Front Upper Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Brake pipe leaking at chasi above rear spring hanger front |3.6.A.1| | 1 |
| Nearside Front Body has a projection caused by corrosion at suspension arm |6.1.C.1| | 1 |
| Offside Front Body has a projection caused by corrosion at suspension arm |6.1.C.1| | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Inner Body has a projection caused by corrosion |6.1.C.1| | 1 |
| Offside Inner Body has a projection caused by corrosion |6.1.C.1| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Rear Brake load sensing valve inoperative |3.6.E.3| | 1 |
| Rear Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
| Offside Upper Front position lamp|s| not working |1.1.A.3b| | 1 |
| Bonnet retaining device ineffective |8.4.2| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Nearside Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Nearside Upper Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar linkage fractured |2.4.G.1| | 1 |
| Offside Rear Anti-roll bar linkage fractured |2.4.G.1| | 1 |
| Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Nearside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
| Offside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
| Nearside Rear Direction indicator incomplete |1.5.A1b| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Brake pedal anti-slip provision incomplete |3.3.A.1b| | 1 |
| Brake load sensing valve has been disconnected and was fitted as standard |3.6.E.2| | 1 |
| Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Offside Inner Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Rear position lamp|s| incomplete |1.1.4a| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Front Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Offside Rear Leaf spring fractured |2.4.B.1a| | 1 |
| Nearside Rear Leaf spring to axle securing nut insecure |2.4.B.7b| | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Brake pipe leaking |3.6.A.1| | 1 |
| Braking system leaking |3.6.A.1| | 1 |
| Nearside Rear Leaf spring fractured |2.4.B.1a| | 1 |
| Nearside Rear Wheel nut|s| loose |4.2.A.1e| | 1 |
| Front Steering column movement between the shaft and steering wheel |2.1.2b| | 1 |
| Nearside Front Lower Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Rear Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Steering column top bearing excessively worn |2.1.2c| | 1 |
| Rear Fuel tank insecure |7.2.1| | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Battery insecure |1.9.1| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
| Nearside Rear Leaf spring has excessive side play at eye |shackle| |2.4.B.4| | 1 |
| Offside Rear Leaf spring has excessive side play at eye |anchor| |2.4.B.4| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Brake load sensing valve inoperative |3.6.E.3| | 1 |
| Nearside Rear Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Rear Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Direction indicators not working |1.4.A.2c| | 1 |
| Offside Front Body mounting fixings insecure corroded (6.2.2 (c) (i)) | 1 |
| Brake pedal anti-slip provision worn smooth (1.1.2 (c)) | 1 |
| Nearside Stop lamp(s) lens defective such that the emitted light is adversely affected (4.3.1 (b) (ii)) | 1 |
| Nearside Rear Shock absorbers has a serious fluid leak | 1 |
| Nearside Rear Anti-roll bar linkage attachment bracket/mounting likely to fail (5.3.3 (b) (ii)) | 1 |
| Offside Rear Anti-roll bar linkage attachment bracket/mounting likely to fail (5.3.3 (b) (ii)) | 1 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view (3.3 (b) (ii)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively damaged significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Front Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting (6.2.2 (d) (i)) | 1 |
| Nearside Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Outer Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Nearside Front Lower Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner sill |6.1.B.2| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Offside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Centre Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Headlamp does not operate immediately when selected on main beam |1.7.4a| | 1 |
| Front Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 1 |
| Nearside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |