Most common failures | No# failures |
---|
Registration plate lamp issues | 23 |
Brake pipe excessively corroded | 21 |
Headlamp aim out of alignment | 17 |
Windscreen wiper does not clear the windscreen effectively | 12 |
Parking brake: efficiency below requirements |3.7.B.7| | 8 |
Brakes imbalanced across an axle | 7 |
Service brake: efficiency below requirements |3.7.B.7| | 5 |
Battery insecure |1.9.1| | 4 |
Front brake application uneven | 3 |
Brake hose excessively deteriorated | 3 |
Rear brake binding | 3 |
Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Nearside Upper Rear position lamp|s| not working |1.1.A.3b| | 2 |
Rear parking brake recording little or no effort | 2 |
Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 2 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 2 |
Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
Offside Rear brake caliper has restricted free movement |3.5.1k| | 2 |
Front brake disc in such a condition that it is seriously weakened | 1 |
Nearside Brake pipe leaking |3.6.A.1| | 1 |
Offside Rear Leaf spring cracked |2.4.B.1a| | 1 |
Headlamp does not operate immediately when selected on main beam |1.7.4a| | 1 |
Steering system excessively rough |2.2.D.1| | 1 |
Offside Upper Rear position lamp|s| not working |1.1.A.3b| | 1 |
Offside front brake binding |3.7.B.1| | 1 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Anti-lock braking system warning lamp does not illuminate |3.4.1b| | 1 |
Nearside Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
Offside Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
Bonnet retaining device excessively deteriorated catch |8.4.2| | 1 |
Rear brake application uneven | 1 |
Exhaust has a major leak of exhaust gases tail section |7.1.2| | 1 |
Front Upper Outline marker lamp does not illuminate simultaneously with the position lamps both (4.2.2 (a)) | 1 |
Offside Rear Anti-roll bar linkage fractured |2.4.G.1| | 1 |
Offside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
Indicator switch faulty |1.4.A.1| | 1 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Headlamp not working on main beam |1.7.5a| | 1 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
Horn not working |7.7 |a| |ii|| | 1 |
Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 1 |
Nearside Front Side repeater not working |4.4.1 |a| |ii|| | 1 |
Offside Front Side repeater not working |4.4.1 |a| |ii|| | 1 |
Nearside Front Brake hose excessively twisted |1.1.12 |b| |ii|| | 1 |
Nearside Front Braking system leaking |3.6.A.1| | 1 |
Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
Offside Front Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
Nearside Rear Upper Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
Nearside Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
Offside Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
Offside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Side repeater not working |1.4.A.2c| | 1 |
Nearside Seat belt retracting mechanism defective |5.2.5b| | 1 |
Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |
Nearside Front Side repeater not working (4.4.1 (a) (ii)) | 1 |
Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 1 |
Horn not working |1.6.2a| | 1 |
Nearside Headlamp insecure |1.7.3| | 1 |
Offside Headlamp insecure |1.7.3| | 1 |
Nearside Rear Leaf spring shackle pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength step frame/chassis corroded and holed within 30cm of body/suspension mounting (5.3.6 (a) (i)) | 1 |
Offside Rear Rear fog lamp emits a light other than red |1.3.2e| | 1 |
Nearside Front Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Front Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Windscreen has damage | 1 |
Service brake: efficiency below requirements |3.7.C.1a| | 1 |
Nearside Front Wheel bolt|s| missing |4.2.A.1e| | 1 |
Offside Front front brake binding |3.7.B.1| | 1 |
Mechanical brake component has restricted free movement | 1 |
Offside Rear Brake back plate|s| securing device loose |3.5.1j| | 1 |
Nearside Rear brake disc contaminated by oil |3.5.1h| | 1 |
Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
Nearside Front Fuel pipe leaking |7.2.3| | 1 |
Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front Shock absorbers has a serious fluid leak | 1 |
Front Power steering pipe/hose leaking (2.1.5 (a)) | 1 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
Nearside Front Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting (6.2.2 (d) (i)) | 1 |
Offside Front Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting (6.2.2 (d) (i)) | 1 |
Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Rear brake caliper has restricted free movement |3.5.1k| | 1 |
Offside Rear Statutory seat belt missing |5.1.1| | 1 |
Speedometer cannot be illuminated. |6.7.3| | 1 |
Offside Side repeater not working |1.4.A.2c| | 1 |
Nearside Rear Air suspension unit totally deflated |2.4.D.1a| | 1 |
Offside Rear Air suspension unit totally deflated |2.4.D.1a| | 1 |
Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
Anti-lock braking system warning lamp indicates an ABS fault | 1 |
Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Upper Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Semaphore indicator switch faulty |1.4.C.1c| | 1 |
Offside Front Body has a sharp edge caused by damage wheel trim damaged, slightly adrift and has sharp edge |6.1.C.1| | 1 |
Brake hose has insufficient room to move | 1 |
Offside Rear Leaf spring main leaf fractured (5.3.1 (b) (ii)) | 1 |
Braking system leaking brake chamber leaking (1.1.3 (d)) | 1 |
Central Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Drag link end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt both ends |2.1.3 |g| |ii|| | 1 |
Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt both ends |2.1.3 |g| |ii|| | 1 |
Exhaust emits excessive smoke or vapour likely to obscure the vision of other road users |8.2.2.2 |c|| | 1 |
Exhaust emissions exceed level of metered smoke for a turbo charged engine |8.2.2.2 |b|| | 1 |
Braking system leaking brake chamber for rear |1.1.3 |d|| | 1 |
Nearside Front Service brake excessively binding |1.2.1 |f|| | 1 |
Offside front brake juddering severely |3.7.A.2b| | 1 |
Braking system leaking |3.6.A.1| | 1 |
Nearside Front Brake pipe twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
Nearside Rear Leaf spring main leaf fractured |5.3.1 |b| |ii|| | 1 |
Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
Nearside Front Direction indicator incorrect colour lens broken |1.4.A.2f| | 1 |
Front Fuel system component leaking near filter area |7.2.3| | 1 |
Offside Rear coil spring broken |2.4.C.1a| | 1 |
Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
Brake load sensing valve seized |3.6.E.3| | 1 |
Nearside Rear Axle has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
Offside Rear Axle has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
Rear brake disc in such a condition that it is seriously weakened | 1 |
Nearside Rear rear brake excessively fluctuating |3.7.B.3| | 1 |
Fuel system component leaking Fuel pump (6.1.3 (b) (i)) | 1 |
Offside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Nearside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wheel arch area (5.3.6 (a) (i)) | 1 |
Offside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wheel arch area (5.3.6 (a) (i)) | 1 |
Nearside Front Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced sill (6.1.1 (c) (i)) | 1 |
Nearside Rear Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced sill (6.1.1 (c) (i)) | 1 |
Nearside Rear Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced sill after wheel arch (6.1.1 (c) (i)) | 1 |
Offside Rear Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced sill after wheel arch (6.1.1 (c) (i)) | 1 |
Offside Rear Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced sill (6.1.1 (c) (i)) | 1 |
Offside Front Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced sill (6.1.1 (c) (i)) | 1 |
Brake load sensing valve seized and ABS not fitted or inoperative (1.1.17 (c) (ii)) | 1 |
Nearside Rear Brake lever has restricted free movement caliper lever (1.1.15 (e)) | 1 |
Offside Rear Brake lever has restricted free movement caliper lever (1.1.15 (e)) | 1 |
Offside Rear fog lamp not working |1.3.2b| | 1 |
Front Drive shaft uj which forms part of the suspension has excessive play in a universal joint |2.4.G.4b| | 1 |
Offside Front Headlamp aim so that beam "kick up" is not visible on the screen misted lense |1.8.B.1| | 1 |
Nearside Front Seat belt obviously repaired too short |5.2.2c| | 1 |
Nearside Front Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` stickers fan etc |8.3.1e| | 1 |
Central Front Brake pipe inadequately clipped 2x pipes resting on gearbox |3.6.B.1| | 1 |
Nearside Front Brake pipe inadequately clipped along chassis leg |3.6.B.1| | 1 |
Front passenger door does not latch securely closed bonnet safety catch |6.2.B.1a| | 1 |