MOT History from tests of diesel IVECO DAILYs year 2009

Review the list of common IVECO DAILY failures below or to perform a specific mot history check on your IVECO then use our popular KnowYourCar service

mot history

Pass percent:54.58%

(The average a diesel IVECO DAILY year 2009 passes without issue)

Based on:25,335 MOT Tests

Most common failures	No# failures
Registration plate lamp issues	2861
Headlamp aim out of alignment	2197
Parking brake: efficiency below requirements \|3.7.B.7\|	1602
Windscreen wiper does not clear the windscreen effectively	1508
Rear parking brake recording little or no effort	702
Horn not working \|1.6.2a\|	676
Brakes imbalanced across an axle	632
Parking brake efficiency below requirements (1.4.2 (a) (i))	494
Registration plate issues	372
Brake fluid warning lamp illuminated \|3.6.G.2\|	368
Anti-lock braking system warning lamp indicates an ABS fault	310
Offside Rear fog lamp not working \|1.3.2b\|	296
Nearside Front position lamp\|s\| not working \|1.1.A.3b\|	288
Parking brake lever has no reserve travel \|3.1.6b\|	287
Windscreen has damage	269
Rear brake binding	265
Offside Side repeater incorrect colour \|1.4.A.2f\|	249
Nearside Side repeater incorrect colour \|1.4.A.2f\|	247
Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii))	245
Nearside Stop lamp not working \|1.2.1b\|	243
Battery insecure \|1.9.1\|	237
Offside Front position lamp\|s\| not working \|1.1.A.3b\|	230
Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush \|2.4.B.2\|	222
Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush \|2.4.B.2\|	216
Offside Stop lamp not working \|1.2.1b\|	214
Nearside Rear Direction indicator incorrect colour \|1.4.A.2f\|	213
Nearside Rear position lamp\|s\| not working \|1.1.A.3b\|	203
Parking brake efficiency below requirements \|1.4.2 \|a\| \|i\|\|	203
Offside Rear Direction indicator incorrect colour \|1.4.A.2f\|	197
Hazard warning switch faulty \|1.4.B.1d\|	189
Exhaust system not adequately supported \|7.1.1\|	180
Offside Rear position lamp\|s\| not working \|1.1.A.3b\|	175
Horn not working (7.7 (a) (ii))	173
Nearside Front Lower Suspension arm has excessive play in a ball joint \|2.4.G.2\|	166
Nearside Rear Anti-roll bar has excessive play in a pin/bush \|2.4.G.2\|	161
Nearside Side repeater not working \|1.4.A.2c\|	159
Nearside Headlamp aim beam image obviously incorrect \|1.8.A.1b\|	158
Offside Front Lower Suspension arm has excessive play in a ball joint \|2.4.G.2\|	158
Exhaust has a major leak of exhaust gases \|7.1.2\|	145
Offside Rear Anti-roll bar has excessive play in a pin/bush \|2.4.G.2\|	145
Offside Headlamp aim beam image obviously incorrect \|1.8.A.1b\|	144
Engine MIL inoperative or indicates a malfunction (8.2.2.2 (g))	142
Front brake application uneven	139
Offside Front Position lamp not working (4.2.1 (a) (ii))	138
Nearside Front Upper Suspension arm has excessive play in a pin/bush \|2.4.G.2\|	130
Offside Headlamp not working on dipped beam \|1.7.5a\|	128
Nearside Headlamp not working on dipped beam \|1.7.5a\|	125
Supplementary Restraint System warning lamp indicates a fault \|5.4.2\|	125
Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement \|2.4.G.2\|	123
Windscreen washer not working	122
Nearside Front Upper Suspension arm has excessive play in a ball joint \|2.4.G.2\|	120
Nearside Front Position lamp not working (4.2.1 (a) (ii))	120
Front brake disc in such a condition that it is seriously weakened	119
Horn not working \|7.7 \|a\| \|ii\|\|	118
Horn not working (7.7 (a))	117
Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement \|2.4.G.2\|	115
Nearside Rear Position lamp not working (4.2.1 (a) (ii))	115
Nearside Front Front position lamp\|s\| not working \|1.1.A.3b\|	111
Service brake: efficiency below requirements \|3.7.B.7\|	110
Nearside Front suspension has excessive play in a lower suspension ball joint \|2.5.B.1a\|	108
Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush \|2.4.G.2\|	107
Offside Side repeater not working \|1.4.A.2c\|	107
Nearside Rear Stop lamp not working \|1.2.1b\|	104
Offside Front suspension has excessive play in a lower suspension ball joint \|2.5.B.1a\|	104
Offside Rear fog lamp not working (4.5.1 (a) (ii))	104
Rear fog lamp not working \|1.3.2b\|	102
Parking brake efficiency less than 50% of the required value \|1.4.2 \|a\| \|ii\|\|	102
Offside Rear Anti-roll bar linkage has excessive play in a pin/bush \|2.4.G.2\|	98
Brake pedal anti-slip provision incomplete \|3.3.A.1b\|	97
Offside Rear Rear fog lamp not working \|1.3.2b\|	95
Offside Rear Stop lamp not working \|1.2.1b\|	95
Rear Exhaust has a major leak of exhaust gases \|7.1.2\|	91
Offside Rear Position lamp not working (4.2.1 (a) (ii))	91
Exhaust emits an excessive level of metered smoke \|7.4.B.3a\|	91
Nearside Headlamp insecure \|1.7.3\|	90
Nearside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement \|2.4.B.2\|	90
Offside Front Upper Suspension arm has excessive play in a pin/bush \|2.4.G.2\|	87
Offside Front Front position lamp\|s\| not working \|1.1.A.3b\|	85
Supplementary restraint system warning lamp indicates a fault (7.1.6 (a))	85
Offside Front Upper Suspension arm has excessive play in a ball joint \|2.4.G.2\|	85
Offside Front Service brake excessively binding (1.2.1 (f))	82
Offside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement \|2.4.B.2\|	81
Nearside Parking brake inoperative on one side (1.4.1 (a))	75
Offside Stop lamp(s) not working (4.3.1 (a) (ii))	73
Offside Rear Rear fog lamp not working (4.5.1 (a) (ii))	72
Nearside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement \|2.4.G.2\|	72
Nearside Rear Leaf spring to axle securing bolt insecure \|2.4.B.7b\|	71
Nearside Obligatory mirror seriously damaged, affecting the rear view \|8.1.2a\|	70
Offside Front Side repeater incorrect colour \|1.4.A.2f\|	70
Windscreen wiper blade insecure	70
Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h))	70
Brake pedal spongy \|3.3.B.1b\|	68
Nearside Rear Service brake excessively binding (1.2.1 (f))	68
Nearside Rear Rear position lamp\|s\| not working \|1.1.A.3b\|	68
Bonnet retaining device ineffective \|8.4.2\|	68
Offside front brake binding \|3.7.B.1\|	66
Rear Anti-roll bar has excessive play in a pin/bush \|2.4.G.2\|	66
Offside Rear Service brake excessively binding (1.2.1 (f))	64
Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii))	63
Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i))	63
Rear brake application uneven	62
Nearside Side repeater not working (4.4.1 (a) (ii))	62
Offside Rear Rear position lamp\|s\| not working \|1.1.A.3b\|	61
Exhaust emissions exceed manufacturers specified limit (8.2.2.2 (a))	61
Service brake efficiency below requirements (1.2.2 (a) (i))	61
Rear fog lamp not working (4.5.1 (a) (ii))	61
Offside Headlamp insecure \|1.7.3\|	61
Nearside Stop lamp(s) not working (4.3.1 (a) (ii))	60
Offside Parking brake inoperative on one side (1.4.1 (a))	60
Nearside Front Side repeater incorrect colour \|1.4.A.2f\|	59
Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i))	59
Offside Rear Leaf spring to axle securing bolt insecure \|2.4.B.7b\|	58
Rear brake disc in such a condition that it is seriously weakened	58
Nearside Rear Leaf spring saddle is moving relative to the spring \|2.4.B.7a\|	58
Nearside Front suspension has excessive play in a upper suspension ball joint \|2.5.B.1a\|	57
Nearside Front Position lamp not working \|4.2.1 \|a\|\|	56
Nearside Front Service brake excessively binding (1.2.1 (f))	56
Nearside Rear Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement \|2.4.G.2\|	55
Hazard warning lamps inoperative \|1.4.B.1b\|	54
Offside Front Position lamp not working \|4.2.1 \|a\|\|	54
Nearside front brake binding \|3.7.B.1\|	54
Nearside Rear Shock absorber has a serious fluid leak \|2.7.3\|	53
Offside Rear Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement \|2.4.G.2\|	53
Rear Brake cable insecure	52
Engine MIL inoperative or indicates a malfunction \|8.2.2.2 \|g\|\|	52
Nearside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i))	52
Nearside Front Direction indicator incorrect colour \|1.4.A.2f\|	51
Rear Exhaust system not adequately supported \|7.1.1\|	51
Nearside Front Headlamp not working on dipped beam \|1.7.5a\|	51
Nearside Rear Direction indicator incorrect colour (4.4.3 (a))	51
Nearside Front Outline marker lamp not working (4.2.1 (a) (ii))	50
Offside Rear Parking brake inoperative on one side (1.4.1 (a))	50
Nearside Rear Parking brake inoperative on one side (1.4.1 (a))	49
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement \|7.2.4b\|	49
Nearside Rear Direction indicator not working \|1.4.A.2c\|	49
Front Exhaust has a major leak of exhaust gases \|7.1.2\|	48
Nearside Front Track rod end ball joint has excessive play \|2.2.B.1f\|	48
Offside Side repeater incorrect colour (4.4.3 (a))	48
Offside Front Shock absorber has a serious fluid leak \|2.7.3\|	48
Offside Front Direction indicator incorrect colour \|1.4.A.2f\|	48
Offside Side repeater not working (4.4.1 (a) (ii))	47
Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii))	47
Nearside Stop lamp\|s\| not working \|4.3.1 \|a\| \|ii\|\|	47
Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii))	47
Offside Rear fog lamp not working \|4.5.1 \|a\| \|ii\|\|	47
Nearside Rear Position lamp not working \|4.2.1 \|a\|\|	46
Nearside Rear Shock absorbers has a serious fluid leak	46
Nearside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement \|2.4.G.2\|	46
Nearside Rear Leaf spring to axle securing nut insecure \|2.4.B.7b\|	46
Offside Rear Position lamp not working \|4.2.1 \|a\|\|	46
Nearside Front Shock absorber has a serious fluid leak \|2.7.3\|	45
Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c))	45
Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c))	44
Nearside Rear Lower Leaf spring has excessive wear in a shackle pin and/or bush \|2.4.B.2\|	44
Offside Rear Lower Leaf spring has excessive wear in a shackle pin and/or bush \|2.4.B.2\|	44
Nearside Track rod end ball joint has excessive play \|2.2.B.1f\|	44
Nearside Front Headlamp aim beam image obviously incorrect \|1.8.A.1b\|	43
Offside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement \|2.4.G.2\|	43
Nearside Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement \|2.4.G.2\|	43
Rear Mechanical brake component has restricted free movement	43
Nearside Rear Leaf spring shackle bracket loose \|2.4.B.6a\|	43
Offside Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement \|2.4.G.2\|	42
Offside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement \|2.4.G.2\|	42
Offside Headlamp not working on dipped beam (4.1.1 (a) (ii))	42
Offside Rear Leaf spring saddle is moving relative to the spring \|2.4.B.7a\|	41
Offside Front Headlamp not working on dipped beam \|1.7.5a\|	40
rear parking \|secondary\| brakes imbalanced	40
Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i))	40
Offside Obligatory mirror seriously damaged, affecting the rear view \|8.1.2a\|	39
Offside Rear Leaf spring has excessive wear in an anchor pin and/or bush \|2.4.B.2\|	39
Offside Rear Leaf spring shackle bracket loose \|2.4.B.6a\|	39
Offside Front Brake hose twisted \|found during steering lock to lock check\| \|2.2.D.2b\|	39
Offside Front Lower Suspension arm ball joint excessively worn \|5.3.4 \|a\| \|i\|\|	38
Nearside Front Shock absorbers has a serious fluid leak	38
Nearside Rear Leaf spring shackle pin or bush excessively worn (5.3.4 (a) (i))	38
Nearside Front Suspension arm has excessive play in a ball joint \|2.4.G.2\|	38
Nearside Front Front suspension has excessive play in a lower suspension ball joint \|2.5.B.1a\|	37
Offside Front Front suspension has excessive play in a lower suspension ball joint \|2.5.B.1a\|	37
Offside Front Headlamp aim beam image obviously incorrect \|1.8.A.1b\|	37
Supplementary restraint system warning lamp indicates a fault \|7.1.6 \|a\|\|	37
Offside Rear Shock absorber has a serious fluid leak \|2.7.3\|	37
Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c))	36
Offside Front suspension has excessive play in a upper suspension ball joint \|2.5.B.1a\|	36
Nearside Side repeater incorrect colour (4.4.3 (a))	36
Nearside Body has a sharp edge caused by damage \|6.1.C.1\|	36
Offside Rear Leaf spring shackle pin or bush excessively worn (5.3.4 (a) (i))	36
Nearside Side repeater excessively damaged so that it is not visible from a reasonable distance \|1.4.A.2e\|	36
Nearside Side repeater not working \|4.4.1 \|a\| \|ii\|\|	36
Nearside Rear Leaf spring has excessive wear in an anchor pin and/or bush \|2.4.B.2\|	36
Nearside Front Side repeater not working \|1.4.A.2c\|	36
Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii))	35
Offside Rear Direction indicator incorrect colour (4.4.3 (a))	35
Offside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i))	35
Nearside All position lamps not working \|1.1.A.3b\|	35
Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement \|2.4.G.2\|	35

We get to these numbers by trawling through over 1 billion MOT test results since 2004 and crunched the numbers. We remove anything to do with Tyres, as they are model independent and group together common non-model specific issues. We are trying to get to a picture of what models have what issues.

Please note: We take the data from the DVSA. This data is raw and can contain typos and spelling mistakes that garages may have entered while recording a MOT result. Specifically miss-match on names of models and makes. We are constantly cleaning the data so bear with the odd issue.

Got suggestions? We’re improving this section all the time. If you have any suggestions, please let us know.

MOT History from tests of diesel IVECO DAILYs year 2009

Find us on Facebook