MOT History from tests of diesel IVECO DAILYs year 2002

Review the list of common IVECO DAILY failures below or to perform a specific mot history check on your IVECO then use our popular KnowYourCar service

mot history

Pass percent:44.28%

(The average a diesel IVECO DAILY year 2002 passes without issue)

Based on:34,351 MOT Tests

Most common failures	No# failures
Registration plate lamp issues	8137
Parking brake: efficiency below requirements \|3.7.B.7\|	6210
Brake pipe excessively corroded	5751
Headlamp aim out of alignment	3747
Service brake: efficiency below requirements \|3.7.B.7\|	3321
Windscreen wiper does not clear the windscreen effectively	2873
Rear parking brake recording little or no effort	2765
Brakes imbalanced across an axle	1910
Offside Rear fog lamp not working \|1.3.2b\|	988
Parking brake lever has no reserve travel \|3.1.6b\|	859
Rear brake binding	702
Registration plate issues	693
Nearside Front position lamp\|s\| not working \|1.1.A.3b\|	657
Horn not working \|1.6.2a\|	616
Brake load sensing valve linkage defective and function impaired \|3.6.E.3\|	589
Nearside Headlamp not working on dipped beam \|1.7.5a\|	568
Exhaust has a major leak of exhaust gases \|7.1.2\|	566
Windscreen has damage	563
Brake load sensing valve linkage seized \|3.6.E.3\|	563
Nearside Stop lamp not working \|1.2.1b\|	560
Offside Front position lamp\|s\| not working \|1.1.A.3b\|	520
Offside Stop lamp not working \|1.2.1b\|	517
Offside rear brake recording little or no effort \|3.7.B.5a\|	489
Nearside rear brake recording little or no effort \|3.7.B.5a\|	473
Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush \|2.4.B.2\|	471
Offside Headlamp not working on dipped beam \|1.7.5a\|	453
Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush \|2.4.B.2\|	451
Brake fluid warning lamp illuminated \|3.6.G.2\|	439
Battery insecure \|1.9.1\|	428
Rear brake application uneven	343
Brake load sensing valve seized \|3.6.E.3\|	315
Offside Rear position lamp\|s\| not working \|1.1.A.3b\|	312
Front brake application uneven	308
Rear Exhaust has a major leak of exhaust gases \|7.1.2\|	304
Nearside Rear position lamp\|s\| not working \|1.1.A.3b\|	287
Brake hose excessively deteriorated	287
Nearside Front Lower Suspension arm has excessive play in a ball joint \|2.4.G.2\|	278
Nearside Rear Anti-roll bar has excessive play in a pin/bush \|2.4.G.2\|	271
Nearside Front suspension has excessive play in a lower suspension ball joint \|2.5.B.1a\|	271
Offside Rear Anti-roll bar has excessive play in a pin/bush \|2.4.G.2\|	267
Rear fog lamp not working \|1.3.2b\|	259
Nearside Rear Direction indicator incorrect colour \|1.4.A.2f\|	257
Offside Rear position lamp\|s\| excessively deteriorated so that it is not visible from a reasonable distance \|1.1.A.3d\|	255
Offside Rear Direction indicator incorrect colour \|1.4.A.2f\|	251
Nearside Rear position lamp\|s\| excessively deteriorated so that it is not visible from a reasonable distance \|1.1.A.3d\|	249
Offside Rear Rear fog lamp not working \|1.3.2b\|	247
Nearside Rear Leaf spring has excessive wear in an anchor pin and/or bush \|2.4.B.2\|	245
Nearside Headlamp not working on main beam \|1.7.5a\|	244
Anti-lock braking system warning lamp indicates an ABS fault	240
Bonnet retaining device ineffective \|8.4.2\|	235
Offside Rear Leaf spring has excessive wear in an anchor pin and/or bush \|2.4.B.2\|	234
Offside Front suspension has excessive play in a lower suspension ball joint \|2.5.B.1a\|	230
Offside Front Lower Suspension arm has excessive play in a ball joint \|2.4.G.2\|	229
Offside Rear Anti-roll bar linkage has excessive play in a pin/bush \|2.4.G.2\|	229
Front Exhaust has a major leak of exhaust gases \|7.1.2\|	228
Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush \|2.4.G.2\|	222
Nearside Front Front position lamp\|s\| not working \|1.1.A.3b\|	214
Nearside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement \|2.4.B.2\|	210
Nearside Front Headlamp not working on dipped beam \|1.7.5a\|	207
Parking brake efficiency below requirements (1.4.2 (a) (i))	199
Nearside Headlamp aim beam image obviously incorrect \|1.8.A.1b\|	199
Offside Rear rear brake recording little or no effort \|3.7.B.5a\|	199
Offside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement \|2.4.B.2\|	194
Nearside Rear Stop lamp not working \|1.2.1b\|	189
Offside Headlamp not working on main beam \|1.7.5a\|	188
Nearside Headlamp not in good working order adversely affecting beam image \|1.2.4a\|	183
Brake pedal spongy \|3.3.B.1b\|	183
Offside Rear Stop lamp not working \|1.2.1b\|	179
Brake pedal anti-slip provision incomplete \|3.3.A.1b\|	177
Emissions not tested \|7.0\|	172
Nearside Rear rear brake recording little or no effort \|3.7.B.5a\|	169
Rear Brake load sensing valve linkage seized \|3.6.E.3\|	165
Offside Front Upper Suspension arm has excessive play in a ball joint \|2.4.G.2\|	164
Rear Brake load sensing valve linkage defective and function impaired \|3.6.E.3\|	160
Headlamp switch faulty \|1.7.1\|	158
Windscreen wiper blade insecure	157
Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement \|2.4.G.2\|	156
Nearside Front Upper Suspension arm has excessive play in a ball joint \|2.4.G.2\|	154
Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement \|2.4.G.2\|	154
Offside Headlamp aim beam image obviously incorrect \|1.8.A.1b\|	150
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement \|7.2.4b\|	145
Indicator switch faulty \|1.4.A.1\|	144
Parking brake efficiency below requirements \|1.4.2 \|a\| \|i\|\|	142
Rear Anti-roll bar has excessive play in a pin/bush \|2.4.G.2\|	141
Offside Headlamp not in good working order adversely affecting beam image \|1.2.4a\|	138
Fuel system component leaking \|7.2.3\|	136
Offside Front Front position lamp\|s\| not working \|1.1.A.3b\|	136
Offside front brake binding \|3.7.B.1\|	136
Offside Front Headlamp not working on dipped beam \|1.7.5a\|	135
Brake load sensing valve inoperative \|3.6.E.3\|	135
Fuel tank leaking \|7.2.3\|	128
Nearside front brake binding \|3.7.B.1\|	128
Offside Front suspension has excessive play in a upper suspension ball joint \|2.5.B.1a\|	128
Rear fog lamp tell tale not working \|1.3.1b\|	127
Exhaust has part of the system excessively deteriorated \|7.1.1a\|	124
Brake hose has insufficient room to move	122
Service brake efficiency below requirements (1.2.2 (a) (i))	121
Rear brake disc in such a condition that it is seriously weakened	120
Nearside Front Direction indicator incorrect colour \|1.4.A.2f\|	119
Offside Track rod end ball joint has excessive play \|2.2.B.1f\|	117
Nearside Windscreen wiper blade deteriorated \|8.2.2\|	114
Offside Windscreen wiper blade deteriorated \|8.2.2\|	114
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings \|6.1.B.2\|	111
Brake performance not tested \|3.7.A.1\|	110
Offside Front Track rod end ball joint has excessive play \|2.2.B.1f\|	110
Nearside Rear Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement \|2.4.B.2\|	109
Nearside Front Shock absorber has an excessively worn bush \|2.7.4\|	107
Nearside Front suspension has excessive play in a upper suspension ball joint \|2.5.B.1a\|	107
Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii))	106
Fuel tank insecure \|7.2.1\|	106
Nearside Rear Leaf spring to axle securing bolt insecure \|2.4.B.7b\|	106
Nearside Rear brake disc contaminated by oil \|3.5.1h\|	105
Offside Rear Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement \|2.4.B.2\|	105
Nearside Front Lower Shock absorber has an excessively worn bush \|2.7.4\|	102
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings \|6.1.B.2\|	101
Nearside Track rod end ball joint has excessive play \|2.2.B.1f\|	100
Offside Front Lower Shock absorber has an excessively worn bush \|2.7.4\|	99
Nearside Rear Shock absorber has a serious fluid leak \|2.7.3\|	98
Offside Front Shock absorber has an excessively worn bush \|2.7.4\|	98
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings \|6.1.B.2\|	98
Nearside Front Track rod end ball joint has excessive play \|2.2.B.1f\|	97
Nearside Front Brake hose twisted \|found during steering lock to lock check\| \|2.2.D.2b\|	95
Offside Front Brake hose twisted \|found during steering lock to lock check\| \|2.2.D.2b\|	95
Nearside Front Brake pipe leaking \|3.6.A.1\|	94
Offside Front Suspension component mounting prescribed area is excessively corroded \|2.4.A.3\|	94
Nearside Rear Leaf spring saddle is moving relative to the spring \|2.4.B.7a\|	94
Offside Rear Leaf spring to axle securing bolt insecure \|2.4.B.7b\|	91
Offside Rear Leaf spring fractured \|2.4.B.1a\|	91
Fuel system component insecure \|7.2.1\|	90
Nearside Rear Lower Leaf spring has excessive wear in a shackle pin and/or bush \|2.4.B.2\|	90
Offside Rear Leaf spring saddle is moving relative to the spring \|2.4.B.7a\|	90
Nearside Rear Suspension spring mounting prescribed area is excessively corroded \|2.4.A.3\|	90
Nearside Front Shock absorber has a serious fluid leak \|2.7.3\|	89
Service brake efficiency below requirements \|1.2.2 \|a\| \|i\|\|	88
Nearside Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement \|2.4.G.2\|	86
Centre Exhaust has a major leak of exhaust gases \|7.1.2\|	85
Offside Front front brake binding \|3.7.B.1\|	84
Offside Rear Rear position lamp\|s\| not working \|1.1.A.3b\|	84
Mechanical brake component has restricted free movement	83
Brake load sensing valve has been disconnected and was fitted as standard \|3.6.E.2\|	83
Nearside Front Suspension arm has excessive play in a ball joint \|2.4.G.2\|	83
Nearside Obligatory mirror seriously damaged, affecting the rear view \|8.1.2a\|	82
Rear Exhaust has part of the system excessively deteriorated \|7.1.1a\|	81
Nearside Headlamp insecure \|1.7.3\|	81
Offside Rear Lower Leaf spring has excessive wear in a shackle pin and/or bush \|2.4.B.2\|	80
Steering system excessively tight \|2.2.D.1\|	80
Nearside Rear Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement \|2.4.G.2\|	80
Nearside Obligatory mirror insecure \|8.1.1\|	80
Nearside All position lamps not working \|1.1.A.3b\|	79
Offside Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement \|2.4.G.2\|	79
Offside Rear Shock absorber has a serious fluid leak \|2.7.3\|	78
Brake hose damaged	78
Offside Obligatory mirror seriously damaged, affecting the rear view \|8.1.2a\|	77
Nearside Front Headlamp not working on main beam \|1.7.5a\|	77
Rear Mechanical brake component has restricted free movement	76
Brake pedal creeps down when held under pressure \|3.3.B.1a\|	75
All position lamps not working \|1.1.A.3b\|	75
Offside Rear position lamp\|s\| incorrect colour \|1.1.A.3e\|	75
Nearside Rear Rear position lamp\|s\| excessively deteriorated so that it is not visible from a reasonable distance \|1.1.A.3d\|	74
Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt \|2.2.C.1c\|	74
Power steering component\|s\| leaking \|2.3.3b\|	74
Brake pedal creeps down while the pedal is held under pressure \|3.3.B.1a\|	74
Offside Rear brake disc contaminated by oil \|3.5.1h\|	73
Nearside Front Upper Suspension arm has excessive play in a pin/bush \|2.4.G.2\|	73
Offside Rear Suspension spring mounting prescribed area is excessively corroded \|2.4.A.3\|	71
Brake pedal anti-slip provision missing \|3.3.A.1b\|	70
Offside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement \|2.4.G.2\|	70
Offside Rear Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement \|2.4.G.2\|	70
Parking brake: efficiency below requirements \|3.7.D.4\|	69
Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt \|2.2.C.1c\|	69
Nearside Rear Direction indicator not working \|1.4.A.2c\|	69
Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` \|8.3.1e\|	69
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings \|6.1.B.2\|	69
Offside Rear Suspension has inadequate clearance with the bump stop \|2.4.A.1a\|	68
Steering rack insecure \|2.2.B.1a\|	68
Nearside Rear Rear position lamp\|s\| not working \|1.1.A.3b\|	67
Brake pedal anti-slip provision worn smooth \|3.3.A.1b\|	67
Front brake disc in such a condition that it is seriously weakened	67
Nearside Front Front suspension has excessive play in a lower suspension ball joint \|2.5.B.1a\|	67
Nearside Rear Suspension has inadequate clearance with the bump stop \|2.4.A.1a\|	66
Nearside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement \|2.4.G.2\|	66
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings \|6.1.B.2\|	66
Offside Rear Rear position lamp\|s\| excessively deteriorated so that it is not visible from a reasonable distance \|1.1.A.3d\|	65
Nearside Rear Direction indicators incorrect colour \|1.4.A.2f\|	65
Nearside Front front brake binding \|3.7.B.1\|	65
Offside Front Seat belt anchorage prescribed area is excessively corroded \|5.2.6\|	64
Nearside Rear Body has a sharp edge caused by damage \|6.1.C.1\|	64
Nearside Front Headlamp aim beam image obviously incorrect \|1.8.A.1b\|	64
Nearside Headlamp aim aimed so that it dazzles other road users \|1.8.A.1a\|	64
Nearside Rear position lamp\|s\| adversely affected by the operation of another lamp \|1.1.A.3f\|	64
Nearside Rear Leaf spring fractured \|2.4.B.1a\|	64
Brake hydraulic reservoir fluid level below minimum level \|3.6.G.1b\|	63
Nearside Rear position lamp\|s\| incorrect colour \|1.1.A.3e\|	63
Offside Rear brake caliper has restricted free movement \|3.5.1k\|	63
Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt \|2.2.C.1c\|	63
Rear Brake load sensing valve seized \|3.6.E.3\|	63
Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings \|6.1.B.2\|	63
Offside Front Suspension arm has excessive play in a ball joint \|2.4.G.2\|	63
Nearside Front Headlamp not in good working order adversely affecting beam image \|1.2.4a\|	62
Nearside Rear Leaf spring to axle securing nut insecure \|2.4.B.7b\|	62
Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement \|2.4.G.2\|	62
Nearside Front Windscreen wiper blade deteriorated \|8.2.2\|	61
Offside Front Windscreen wiper blade deteriorated \|8.2.2\|	61
Nearside Rear Brake pipe leaking \|3.6.A.1\|	60
Power steering pipe\|s\| or hose\|s\| leaking \|2.3.3b\|	60
Offside Rear Direction indicators incorrect colour \|1.4.A.2f\|	59
Offside Front Headlamp not working on main beam \|1.7.5a\|	59
Nearside Steering rack gaiter split \|2.2.D.2d\|	59
Brake master cylinder/servo mounting prescribed area is excessively corroded \|3.6.C.3\|	59
Nearside Front Body has a sharp edge caused by damage \|6.1.C.1\|	58
Nearside Rear Suspension component mounting prescribed area is excessively corroded \|2.4.A.3\|	58

We get to these numbers by trawling through over 1 billion MOT test results since 2004 and crunched the numbers. We remove anything to do with Tyres, as they are model independent and group together common non-model specific issues. We are trying to get to a picture of what models have what issues.

Please note: We take the data from the DVSA. This data is raw and can contain typos and spelling mistakes that garages may have entered while recording a MOT result. Specifically miss-match on names of models and makes. We are constantly cleaning the data so bear with the odd issue.

Got suggestions? We’re improving this section all the time. If you have any suggestions, please let us know.

MOT History from tests of diesel IVECO DAILYs year 2002

Find us on Facebook