| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 12 |
| Brake pipe excessively corroded | 12 |
| Brakes imbalanced across an axle | 7 |
| Windscreen wiper does not clear the windscreen effectively | 7 |
| Registration plate lamp issues | 6 |
| Service brake: efficiency below requirements |3.7.B.7| | 5 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 4 |
| Battery insecure |1.9.1| | 3 |
| Windscreen washer not working | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Rear brake application uneven | 3 |
| Drivers seat insecure (6.2.5 (a) (ii)) | 3 |
| Nearside Rear Brake drum contaminated (1.1.14 (b)) | 3 |
| rear brakes release unevenly |3.7.B.4| | 2 |
| Rear brake binding | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Registration plate issues | 2 |
| Nearside Headlamp insecure |1.7.3| | 2 |
| Nearside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 2 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 2 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Brake load sensing valve seized |3.6.E.3| | 2 |
| Horn not working |1.6.2a| | 2 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 2 |
| Nearside Front Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front Tie bar/rod insecure |2.4.G.1| | 1 |
| Offside Front Brake hose stretched |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Offside Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Front brake application uneven | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
| Offside Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
| Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Nearside rear brake grabbing severely |3.7.A.5b| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front Headlamp aim beam image too far to the right |1.6.B4| | 1 |
| Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Front Brake pipe leaking |3.6.A.1| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Offside All direction indicators not working |4.4.1 |a| |ii|| | 1 |
| Nearside Front Direction indicator incorrect colour |4.4.3 |a|| | 1 |
| Nearside Front Upper All position lamps not working |4.2.1 |a|| | 1 |
| Front Oil leaking excessively from engine |8.4.1 |a| |i|| | 1 |
| Nearside Front Brake hose excessively damaged |1.1.12 |b| |ii|| | 1 |
| Rear Spare wheel carrier insecure |6.1.5 |a|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Battery insecure |1.9.1| | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Emissions unable to be completed (8.2.2.2 (e)) | 1 |
| Offside Front Inner Integral body structure inadequately repaired such that structural rigidity is significantly reduced wings (6.1.1 (d) (i)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Front Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting bulkhead at battery (6.2.2 (d) (i)) | 1 |
| Front Inner Integral body structure inadequately repaired such that structural rigidity is significantly reduced wheel arch x2 (6.1.1 (d) (i)) | 1 |
| Nearside Front Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
| Towbar with an unsafe modification to primary components (6.1.6 (g) (ii)) | 1 |
| Prop shaft bearing likely to break up front and rear x2 (6.1.7 (b) (ii)) | 1 |
| Rear Oil leaking excessively from transmission diff (8.4.1 (a) (i)) | 1 |
| Nearside Front Inner Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting wheel arch (6.2.2 (d) (i)) | 1 |
| Offside Front Inner Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting wheel arch (6.2.2 (d) (i)) | 1 |
| Passengers seat insecure (6.2.6 (a) (ii)) | 1 |
| Nearside Front Seat belt likely to become detached in the event of a collision (7.1.1 (a) (ii)) | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting door pillar (6.2.2 (d) (i)) | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill (6.2.2 (d) (i)) | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting step (6.2.2 (d) (i)) | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting bulkhead (6.2.2 (d) (i)) | 1 |
| Battery insecure and likely to cause a short circuit x2 (4.13 (a) (ii)) | 1 |
| Offside Front Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting wing (6.2.2 (d) (i)) | 1 |
| Offside Front Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting wheel arch (6.2.2 (d) (i)) | 1 |
| Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting wheel arch inner and outer (6.2.2 (d) (i)) | 1 |
| Offside Front Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill (6.2.2 (d) (i)) | 1 |
| Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner sill (6.2.2 (d) (i)) | 1 |
| Front Direction indicator likely to become detached x2 (4.4.1 (c) (ii)) | 1 |
| Emissions not tested (8.2.2.2 (e)) | 1 |
| Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting wheel arch (6.2.2 (d) (i)) | 1 |
| Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting under battery x2 (6.2.2 (d) (i)) | 1 |
| Towbar component excessively damaged partially detached (6.1.6 (a)) | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Nearside Front Upper Tie bar/rod ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Upper Tie bar/rod ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Upper Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Side repeater insecure |1.4.A.2b| | 1 |
| Offside Front position lamp|s| insecure |1.1.A.3a| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Front Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Brake load sensing valve inoperative |3.6.E.3| | 1 |
| Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Bonnet retaining device excessively deteriorated |8.4.2| | 1 |
| Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Nearside Rear Braking system leaking |3.6.A.1| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Bonnet cannot be secured in the closed position |8.4.1| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Front Bonnet cannot be secured in the closed position |8.4.1| | 1 |
| Nearside Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Nearside Front Statutory seat belt of the wrong type. |5.1.1| | 1 |
| Offside Front Statutory seat belt of the wrong type. |5.1.1| | 1 |
| Nearside Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Offside Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Brake valve has an excessive discharge of oil |3.6.E.1| | 1 |
| Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Offside Front Parking brake mechanism/associated mounting prescribed area is excessively corroded |3.1.9| | 1 |
| Nearside Passenger`s seat insecure |6.2.A.1| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Tie bar/rod ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Tie bar/rod ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Brake pipe leaking |3.6.A.1| | 1 |
| Nearside Front Battery insecure battery box corroded and bulk head by battery box |1.9.1| | 1 |
| Nearside Front Vehicle structure has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering bulk head by brake servo |6.1.A.1| | 1 |