Most common failures | No# failures |
---|
Registration plate lamp issues | 63 |
Parking brake: efficiency below requirements |3.7.B.7| | 34 |
Brake pipe excessively corroded | 33 |
Windscreen wiper does not clear the windscreen effectively | 26 |
Headlamp aim out of alignment | 17 |
Service brake: efficiency below requirements |3.7.B.7| | 15 |
Rear parking brake recording little or no effort | 15 |
Offside Rear fog lamp not working |1.3.2b| | 12 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 9 |
Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 6 |
Brakes imbalanced across an axle | 6 |
Horn not working |1.6.2a| | 6 |
Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 5 |
Registration plate issues | 5 |
Brake fluid warning lamp illuminated |3.6.G.2| | 5 |
Rear brake binding | 4 |
Parking brake lever has no reserve travel |3.1.6b| | 4 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 4 |
Battery insecure |1.9.1| | 4 |
Brake hose excessively deteriorated | 4 |
Nearside Stop lamp not working |1.2.1b| | 4 |
Rear fog lamp tell tale not working |1.3.1b| | 3 |
Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
Nearside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 3 |
Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 3 |
Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
Brake hose has insufficient room to move | 3 |
Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
Offside Rear Rear fog lamp not working |1.3.2b| | 3 |
Nearside Headlamp not working on main beam |1.7.5a| | 3 |
Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
Offside Stop lamp not working |1.2.1b| | 3 |
Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 3 |
Brake load sensing valve seized |3.6.E.3| | 3 |
Power steering component|s| leaking |2.3.3b| | 2 |
All position lamps not working |1.1.A.3b| | 2 |
Offside Rear Rear position lamp|s| insecure |1.1.A.3a| | 2 |
Brake load sensing valve linkage seized |3.6.E.3| | 2 |
Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 2 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Brake load sensing valve has been disconnected and was fitted as standard |3.6.E.2| | 2 |
Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
Offside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 2 |
Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 2 |
Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 2 |
Nearside Rear Leaf spring cracked |2.4.B.1a| | 2 |
Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Emissions not tested |7.0| | 2 |
Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Rear brake application uneven | 2 |
rear brakes release unevenly |3.7.B.4| | 2 |
Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
Offside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 2 |
Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 2 |
Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
Steering column top bearing excessively worn |2.1.2c| | 1 |
Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
Rear Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
Offside Front Lower Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Windscreen wiper blade deteriorated |8.2.2| | 1 |
Offside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
Offside Rear position lamp|s| insecure |1.1.A.3a| | 1 |
Exhaust system not adequately supported |7.1.1| | 1 |
Nearside Direction indicator not working |1.4.A.2c| | 1 |
Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |
Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Offside Rear rear brake juddering severely |3.7.A.5b| | 1 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Obligatory mirror insecure |8.1.1| | 1 |
Nearside Obligatory mirror insecure |8.1.1| | 1 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Statutory seat belt missing |5.1.1| | 1 |
Steering system excessively rough |2.2.D.1| | 1 |
Offside Direction indicator flashing more than 120 times a minute |1.4.A.2g| | 1 |
Nearside Headlamp insecure |1.7.3| | 1 |
Nearside Rear Leaf spring fractured |2.4.B.1a| | 1 |
Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
Nearside Front Statutory seat belt missing stalk |5.1.1| | 1 |
Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Rear Brake hose twisted insecure |3.6.B.4c| | 1 |
Offside Front Inner Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Nearside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
Rear fog lamp not working |1.3.2b| | 1 |
Nearside Statutory seat belt missing |5.1.1| | 1 |
Body has a projection caused by corrosion |6.1.C.1| | 1 |
Brake hydraulic reservoir leaking hydraulic fluid |3.6.A.1| | 1 |
Rear brake disc in such a condition that it is seriously weakened | 1 |
Speedometer cannot be illuminated. |6.7.3| | 1 |
Nearside Front Upper Shock absorber has an excessively worn bush |2.7.4| | 1 |
Nearside Rear Upper Anti-roll bar linkage rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Rear Anti-roll bar rubber mounting bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Offside Rear Leaf spring eye defective |shackle| |2.4.B.1b| | 1 |
Nearside Front Shock absorber detached |2.7.2b| | 1 |
Brake performance not tested |3.7.A.1| | 1 |
Nearside Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Rust along entire nearside underside of vehicle (yellow chalk) (6.1.1 (c) (i)) | 1 |
Offside Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Rust along offside underside of vehicle (yellow chalk) (6.1.1 (c) (i)) | 1 |
Nearside Rear Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
Nearside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Rust in arch (6.1.1 (c) (i)) | 1 |
Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
Brake performance not tested (1.2.1 (g)) | 1 |
Nearside Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Nearside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Rear reflector missing |1.5.1a| | 1 |
Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.4.B.1| | 1 |
Nearside rear brake juddering severely |3.7.A.5b| | 1 |
Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Anti-roll bar linkage worn and seriously weakened |2.4.G.1| | 1 |
Nearside Rear Anti-roll bar linkage worn and seriously weakened |2.4.G.1| | 1 |
Offside Rear Anti-roll bar linkage worn and seriously weakened |2.4.G.1| | 1 |
Nearside Rear Leaf spring saddle is moving relative to the spring |2.4.B.7a| | 1 |
Offside Rear Leaf spring saddle is moving relative to the spring |2.4.B.7a| | 1 |
Power steering inoperative |2.3.3a| | 1 |
Offside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Rear position lamp|s| obscured more than 50% |1.1.A.3c| | 1 |
Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Steering component excessively corroded and unserviceable |2.2.C.1d| | 1 |
Bonnet retaining device ineffective |8.4.2| | 1 |
Offside Rear Leaf spring to axle securing nut insecure |2.4.B.7b| | 1 |
Nearside Rear Leaf spring to axle securing nut insecure |2.4.B.7b| | 1 |
Offside Rear Lower Anti-roll bar linkage severely distorted |2.4.G.1| | 1 |
Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
Drivers seat fore and aft adjustment mechanism not functioning as intended. (6.2.5 (b) (i)) | 1 |
Offside Front Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting wing (6.2.2 (d) (i)) | 1 |
Nearside Front Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting wing (6.2.2 (d) (i)) | 1 |
Nearside Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced battery shelf (6.1.1 (c) (i)) | 1 |
Front Leaf spring fractured (5.3.1 (b) (i)) | 1 |
Nearside Rear Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
Brake load sensing valve linkage defective and function impaired missing (1.1.17 (a)) | 1 |
Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced |6.1.1 |c| |i|| | 1 |
Battery insecure and likely to fall from carrier |4.13 |a| |ii|| | 1 |
Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
Offside Front Upper All outline marker lamps not working (4.2.1 (a) (ii)) | 1 |
Nearside Rear Shock absorbers has a serious fluid leak | 1 |
Front Exhaust emissions likely to be affected by an exhaust leak exhaust box. (8.2.2.1 (b)) | 1 |
Nearside Brake cable has restricted free movement |3.5.1k| | 1 |
Offside Brake cable has restricted free movement |3.5.1k| | 1 |
Nearside Rear brake caliper has restricted free movement |3.5.1k| | 1 |
Offside Rear brake caliper has restricted free movement |3.5.1k| | 1 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
Offside Rear Shock absorber insecure |2.7.2b| | 1 |
Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Fuel tank insecure |7.2.1| | 1 |
Driver`s door does not latch securely closed |6.2.B.1a| | 1 |
Steering system excessively tight |2.2.D.1| | 1 |
Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Front brake application uneven | 1 |
Front front brakes release unevenly |3.7.B.4| | 1 |
Fuel system component insecure |7.2.1| | 1 |
Centre Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded over axle |2.4.A.3| | 1 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded over axle |2.4.A.3| | 1 |
Offside Seat belt insecurely fixed to the seat |5.2.1a| | 1 |
Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
Nearside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Rear Leaf spring has excessive side play at eye |anchor| |2.4.B.4| | 1 |
Offside Rear Leaf spring has excessive side play at eye |anchor| |2.4.B.4| | 1 |
Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Rear Braking system leaking |3.6.A.1| | 1 |
Offside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Loading door cannot be secured in the closed position |6.4.1| | 1 |
Brake master cylinder fluid level below minimum level |3.6.G.1e| | 1 |
Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
Rear Mechanical brake component has restricted free movement | 1 |
Offside Rear An item not tested |Manual| | 1 |
Centre Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
Nearside Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
Nearside Rear Anti-roll bar linkage fractured |2.4.G.1| | 1 |
Offside Rear Anti-roll bar linkage fractured |2.4.G.1| | 1 |
Stop lamp not working |1.2.1b| | 1 |
Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
Offside Rear Leaf spring splayed and action impaired |2.4.B.1c| | 1 |
Nearside Rear Leaf spring splayed and action impaired |2.4.B.1c| | 1 |
Outer Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
Offside Rear Stop lamp not working |1.2.1b| | 1 |
Offside Front Vehicle structure is damaged, seriously affecting its strength within 30cm of the body mountings inner arch |6.1.B.2| | 1 |
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner sill support |6.1.B.2| | 1 |
Nearside Rear Rear position lamp|s| incomplete |1.1.4a| | 1 |
Brake pedal anti-slip provision incomplete |3.3.A.1b| | 1 |
Nearside Parking (secondary brake) on a single line braking system has inadequate effort at a wheel (1.3.1 (a) (i)) | 1 |
Offside Parking (secondary brake) on a single line braking system has inadequate effort at a wheel (1.3.1 (a) (i)) | 1 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |