| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 48 |
| Parking brake: efficiency below requirements |3.7.B.7| | 47 |
| Rear parking brake recording little or no effort | 34 |
| Windscreen wiper does not clear the windscreen effectively | 33 |
| Brake pipe excessively corroded | 33 |
| Headlamp aim out of alignment | 23 |
| Brakes imbalanced across an axle | 12 |
| Service brake: efficiency below requirements |3.7.B.7| | 9 |
| Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 9 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 9 |
| Offside Stop lamp not working |1.2.1b| | 9 |
| Parking brake lever has no reserve travel |3.1.6b| | 9 |
| Offside Rear fog lamp not working |1.3.2b| | 8 |
| Nearside Stop lamp not working |1.2.1b| | 8 |
| Registration plate issues | 8 |
| Battery insecure |1.9.1| | 7 |
| Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 7 |
| Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 7 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 6 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 6 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 6 |
| Rear brake application uneven | 5 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 5 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
| Brake load sensing valve linkage seized |3.6.E.3| | 4 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 4 |
| Offside Rear Stop lamp not working |1.2.1b| | 4 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 4 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 4 |
| Rear Brake load sensing valve linkage seized |3.6.E.3| | 4 |
| Nearside Headlamp not working on main beam |1.7.5a| | 4 |
| Windscreen has damage | 4 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 4 |
| Front brake application uneven | 4 |
| Horn not working |1.6.2a| | 4 |
| Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 3 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 3 |
| Brake hose excessively deteriorated | 3 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 3 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 3 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 3 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 3 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 3 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Nearside Rear Stop lamp not working |1.2.1b| | 3 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 3 |
| Brake load sensing valve has been disconnected and was fitted as standard |3.6.E.2| | 3 |
| Brake pedal anti-slip provision incomplete |3.3.A.1b| | 3 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
| Brake load sensing valve seized |3.6.E.3| | 3 |
| Nearside Stop lamp emits other than a steady red light |1.2.1e| | 2 |
| Fuel system component insecure |7.2.1| | 2 |
| Nearside Rear Rear position lamp|s| incomplete |1.1.4a| | 2 |
| Nearside Front Upper Front position lamp|s| not working |1.1.A.3b| | 2 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 2 |
| Nearside Rear position lamp|s| incorrect colour |1.1.A.3e| | 2 |
| Nearside Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 2 |
| Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Offside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Rear fog lamp not working |1.3.2b| | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Nearside Front Lower Ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Front Lower Ball joint has excessive play |2.2.B.1f| | 2 |
| Spare wheel carrier insecure |6.4.2| | 2 |
| Offside Headlamp not working on main beam |1.7.5a| | 2 |
| Nearside Rear Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement |2.4.B.2| | 2 |
| Fuel system component leaking |7.2.3| | 2 |
| Bonnet retaining device ineffective |8.4.2| | 2 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 2 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 2 |
| Offside Rear Direction indicators not working |1.4.A.2c| | 2 |
| Nearside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 2 |
| Offside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 2 |
| Nearside Headlamp insecure |1.7.3| | 2 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside Rear Leaf spring fractured |2.4.B.1a| | 2 |
| Offside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 2 |
| Brake cable has wires broken and is significantly weakened |3.5.1b| | 2 |
| Headlamp switch faulty |1.7.1| | 2 |
| Horn not loud enough to be heard by another road user |1.6.2b| | 2 |
| Offside front brake binding |3.7.B.1| | 2 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Steering column universal joint has excessive play |2.1.5| | 2 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| An item not tested |Manual| | 2 |
| Rear Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 2 |
| Nearside Outer Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Outer Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Body component insecure tipper body on offside (6.2.1 (a) (i)) | 1 |
| Front Dipswitch operation does not deflect all main beam headlamps to make them dipped beams |1.7.4b| | 1 |
| Nearside Inner Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Front Road wheel badly damaged |4.2.A.1a| | 1 |
| Offside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Rear Braking system leaking |3.6.A.1| | 1 |
| Nearside Rear Leaf spring eye defective |shackle| |2.4.B.1b| | 1 |
| Offside Rear Leaf spring eye defective |shackle| |2.4.B.1b| | 1 |
| Nearside Obligatory mirror seriously deteriorated, affecting the rear view |8.1.2a| | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wheel arch (5.3.6 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wheel arch (5.3.6 (a) (i)) | 1 |
| Nearside Rear Inner Anti-roll bar pin or bush excessively worn D BUSH (5.3.4 (a) (i)) | 1 |
| Nearside Rear Outer Anti-roll bar pin or bush excessively worn D BUSH (5.3.4 (a) (i)) | 1 |
| Offside Rear Inner Anti-roll bar pin or bush excessively worn D BUSH (5.3.4 (a) (i)) | 1 |
| Offside Rear Outer Anti-roll bar pin or bush excessively worn D BUSH (5.3.4 (a) (i)) | 1 |
| Offside Front Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
| Brake pedal anti-slip provision missing |1.1.2 |c|| | 1 |
| Offside Seat belt anchorage prescribed area strength or continuity significantly reduced underbody sill |7.1.1 |a| |i|| | 1 |
| Offside Front Side repeater incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Offside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Rear Direction indicator lens defective such that the emitted light is adversely affected (4.4.1 (b) (ii)) | 1 |
| Offside Front Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Offside Front Headlamp incorrect colour (4.1.4 (a)) | 1 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Rear Anti-roll bar linkage fractured (5.3.3 (b) (ii)) | 1 |
| Nearside Front Direction indicator missing (4.4.1 (a) (ii)) | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Position lamp showing white light to the rear (4.2.3 (a) (ii)) | 1 |
| Nearside Rear Leaf spring shackle pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Leaf spring shackle pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Offside Trailer electrical socket damaged so that lead cannot be securely connected |1.9.3b| | 1 |
| Offside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Centre Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Offside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint top |2.4.G.2| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| inner rack has excessive play |2.2.A.1b| | 1 |
| Exhaust has a major leak of exhaust gases front to rear join area |7.1.2| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Vehicle structure has excessive corrosion which adversely affects braking or steering rear crossmember |on which handbrake mounted| corroded at both ends |6.1.A.1| | 1 |
| Offside Front Subframe mounting prescribed area is excessively corroded inner wing area |2.4.A.3| | 1 |
| Offside Front Upper Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Headlamp insecure |4.1.1 |c|| | 1 |
| Offside Headlamp levelling device inoperative |4.1.5 |a|| | 1 |
| Nearside Front Direction indicator incorrect colour |4.4.3 |a|| | 1 |
| Nearside Front Body component damaged and likely to cause injury indicator lense broken |6.2.1 |a| |i|| | 1 |
| Offside Rear Position lamp not working |4.2.1 |a| |ii|| | 1 |
| Nearside Rear Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner arch top |6.2.2 |d| |i|| | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner arch top |6.2.2 |d| |i|| | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting outrigger |6.2.2 |d| |i|| | 1 |
| Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting outrigger and floorpan |6.2.2 |d| |i|| | 1 |
| Offside Front Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced wheel arch holed. (6.1.1 (c) (i)) | 1 |
| Offside Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced outrigger holed (6.1.1 (c) (i)) | 1 |
| Nearside Rear Anti-roll bar linkage corroded and seriously weakened |2.4.G.1| | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Brake pipe twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Offside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Upper Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Offside Front Lower Sub-frame corroded and seriously weakened |2.4.G.1| | 1 |
| Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Emissions not tested |7.4.B.1| | 1 |
| Emissions not tested no tailpipe |7.4.B.1| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Rear Shock absorber insecure |2.7.2b| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Front Floor excessively deteriorated inner wheel arch (6.2.4 (a) (i)) | 1 |
| Offside Rear Brake pipe at imminent risk of failure or fracture (1.1.11 (a)) | 1 |
| Offside Front Brake prescribed area is excessively corroded (1.1.21 (e) (i)) | 1 |
| Nearside Front Subframe mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Front Subframe mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Rear Anti-roll bar linkage missing |2.4.G.1| | 1 |
| Offside Rear Anti-roll bar linkage missing |2.4.G.1| | 1 |
| Nearside Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Rear Direction indicator excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Nearside Rear Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Nearside Rear Lower Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Offside Rear Lower Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Offside Rear Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Nearside Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Offside Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Rear Brake load sensing valve inoperative not connected |3.6.E.3| | 1 |
| Offside Front Direction indicator incomplete |1.5.A1b| | 1 |
| Offside Front front brake juddering severely |3.7.A.2b| | 1 |
| Nearside Rear Valve stem seriously damaged |4.1.D.1e| | 1 |
| Nearside Rear Shock absorber detached |2.7.2b| | 1 |
| Rear Additional braking device insecure |3.6.I.1| | 1 |
| Brake valve damaged |3.6.A.2c| | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Rear Upper Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Outline marker lamp not working central (4.2.1 (a) (ii)) | 1 |
| Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded chassis as marked in yellow (1.1.21 (e) (i)) | 1 |
| Fuel tank insecure strap snapped (6.1.3 (a) (i)) | 1 |
| Offside Front Lower Sub-frame strengthening plate or fastening so insecure that structural rigidity is seriously reduced corroded and marked in yellow (6.1.1 (b) (ii)) | 1 |
| Offside Front Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting rear cab outrigger (6.2.2 (d) (i)) | 1 |
| Nearside Front Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting rear cab outrigger (6.2.2 (d) (i)) | 1 |
| Offside Front Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting front inner chassis leg (6.2.2 (d) (i)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Main beam `tell-tale` not working |1.7.4c| | 1 |
| Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Offside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Front Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Offside Parking |secondary brake| on a single line braking system has inadequate effort at a wheel |1.3.1 |a| |i|| | 1 |
| Nearside Rear Shock absorber casing damaged externally so the unit does not function |2.7.2a| | 1 |
| Offside Rear Shock absorber casing damaged externally so the unit does not function |2.7.2a| | 1 |
| Offside Upper Front position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 1 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Nearside Front Direction indicator missing |1.4.A.2b| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Nearside Front Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Fuel tank insecure |7.2.1| | 1 |
| Offside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Nearside Front Statutory seat belt missing |5.1.1| | 1 |
| Front Statutory seat belt missing |5.1.1| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Nearside Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Rear Passenger`s seat insecure |6.2.A.1| | 1 |
| Nearside Front All position lamps not working |1.1.A.3b| | 1 |
| Offside Rear All position lamps not working |1.1.A.3b| | 1 |
| Nearside Rear All position lamps not working |1.1.A.3b| | 1 |
| Offside Front Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Nearside passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Centre Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Nearside Rear Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Nearside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Centre Rear Statutory seat belt missing |5.1.1| | 1 |
| rear brakes release unevenly |3.7.B.4| | 1 |
| Nearside Dropside cannot be secured in the closed position |6.4.1| | 1 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Rear Tie bar/rod missing snapped |2.4.G.1| | 1 |
| Nearside Rear Tie bar/rod rubber bush deteriorated resulting in excessive movement d bush |2.4.G.2| | 1 |
| Offside Rear Tie bar/rod rubber bush deteriorated resulting in excessive movement d bush |2.4.G.2| | 1 |
| Offside Rear Tie bar/rod rubber bush deteriorated resulting in excessive movement tie bar bush |2.4.G.2| | 1 |
| Nearside Front brake caliper leaking |3.6.A.1| | 1 |
| Brake load sensing valve defective and function impaired |3.6.E.3| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Vehicle structure has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Centre Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Rear brake binding | 1 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Upper Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Rear Hinged tailboard cannot be secured in the closed position |6.4.1| | 1 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 1 |
| Offside Front Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Offside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Front Leaf spring deteriorated and seriously weakened |2.4.B.1a| | 1 |
| Nearside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Rear Fuel system component insecure |7.2.1| | 1 |
| Offside Brake cable has restricted free movement |3.5.1k| | 1 |
| Nearside Rear Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
| Offside Front Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Steering column shaft has excessive end float |2.1.3| | 1 |
| Nearside Front Sub-frame corroded and seriously weakened |2.4.G.1| | 1 |
| Offside Front Sub-frame corroded and seriously weakened |2.4.G.1| | 1 |
| Offside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Direction indicators not working |1.4.A.2c| | 1 |
| Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Nearside Lower Front suspension ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Nearside Front Body has a sharp edge caused by damage wing |6.1.C.1| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded step area |5.2.6| | 1 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Nearside Rear Leaf spring cracked |2.4.B.1a| | 1 |
| front brakes release unevenly |3.7.B.4| | 1 |
| Nearside Headlamp does not operate immediately when selected on main beam |1.7.4a| | 1 |
| Offside Headlamp does not operate immediately when selected on main beam |1.7.4a| | 1 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Rear Direction indicator incomplete |1.5.A1b| | 1 |
| Nearside Front Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Offside Rear An item not tested |Manual| | 1 |
| Offside Rear Leaf spring has excessive side play at eye |anchor| |2.4.B.4| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Leaf spring splayed and action impaired |2.4.B.1c| | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Offside Front Upper Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting cab chassis leg |6.2.2 |d| |i|| | 1 |
| Suspension component mounting prescribed area excessively corroded significantly reducing structural strength offside rear chassis by leaf spring anchor mounting |5.3.6 |a| |i|| | 1 |
| Suspension component mounting prescribed area excessively corroded significantly reducing structural strength offside rear chassis by rear shock absorber mounting |5.3.6 |a| |i|| | 1 |
| Suspension component mounting prescribed area excessively corroded significantly reducing structural strength nearside rear crossmember by shock absorber mounting |5.3.6 |a| |i|| | 1 |
| Suspension component mounting prescribed area excessively corroded significantly reducing structural strength offside rear crossmember by shock absorber mounting |5.3.6 |a| |i|| | 1 |
| Nearside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Offside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Centre Statutory seat belt missing |5.1.1| | 1 |
| Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside front brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Body insecure and dangerous to other road users tipper body mountings rotted through insecure |6.1.B.1b| | 1 |
| Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Brake hose has insufficient room to move | 1 |
| Rear Direction indicator incorrect colour both lenses broken |1.4.A.2f| | 1 |
| Nearside Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Offside Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Nearside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |