| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 24 |
| Brakes imbalanced across an axle | 16 |
| Parking brake: efficiency below requirements |3.7.B.7| | 14 |
| Brake hose excessively deteriorated | 13 |
| Service brake: efficiency below requirements |3.7.B.7| | 12 |
| Windscreen wiper does not clear the windscreen effectively | 11 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 10 |
| Headlamp aim out of alignment | 9 |
| Registration plate lamp issues | 9 |
| Rear parking brake recording little or no effort | 7 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 7 |
| Nearside Side repeater not working |1.4.A.2c| | 6 |
| Rear brake application uneven | 6 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 5 |
| Offside Side repeater not working |1.4.A.2c| | 4 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 4 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 4 |
| Nearside Headlamp not working on main beam |1.7.5a| | 4 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 4 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Offside Headlamp not working on main beam |1.7.5a| | 3 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Horn not working |1.6.2a| | 3 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Emissions not tested |7.0| | 2 |
| Electrical wiring inadequately supported |1.9.2a| | 2 |
| Exhaust system not adequately supported |7.1.1| | 2 |
| Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Steering rack gaiter split |2.2.D.2d| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Rear Brake pipe inadequately clipped |3.6.B.1| | 2 |
| Nearside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 2 |
| Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Offside Rear fog lamp emits a light other than red |1.3.2e| | 2 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 2 |
| Front brake application uneven | 2 |
| Direction indicators not working |1.4.A.2c| | 2 |
| Registration plate issues | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Offside Rear wheel cylinder securing device loose |3.5.1j| | 2 |
| Offside Rear Brake lining|s| insecure |3.5.1g| | 2 |
| Front brake disc excessively scored |3.5.1h| | 2 |
| Nearside rear parking |secondary| brake grabbing severely |3.7.B.6b| | 2 |
| Offside Rear Brake pipe inadequately supported |3.6.B.1| | 2 |
| Rear Mechanical brake component has restricted free movement | 2 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Front Brake performance not tested |3.7.A.1| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Centre Brake pipe excessively damaged |3.6.B.2c| | 1 |
| Offside Front All position lamps not working |1.1.A.3b| | 1 |
| Offside Front Brake pipe leaking |3.6.A.1| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
| Lower Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
| Nearside Steering rack insecure |2.2.B.1a| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Nearside Front Torsion bar excessive play at an end fixing |2.4.E.2| | 1 |
| Offside Front Torsion bar excessive play at an end fixing |2.4.E.2| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |
| Lower Steering column top mounting bracket insecure |2.1.2d| | 1 |
| Centre Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Front Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Brake hose has insufficient room to move | 1 |
| Offside rear brake grabbing severely |3.7.A.5b| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Front Fuel pipe leaking |7.2.3| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Centre Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Rear Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Hydraulic brake cylinder leaking hydraulic fluid |3.6.A.1| | 1 |
| Nearside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Brake servo defective or ineffective (1.1.10 (a) (i)) | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Windscreen wiper not working (3.4 (a)) | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Steering system fouling |2.2.D.2a| | 1 |
| Nearside Rear rear brake grabbing severely |3.7.A.5b| | 1 |
| Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Steering system excessively tight |2.2.D.1| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Rear rear brake juddering severely |3.7.A.5b| | 1 |
| Front front brake juddering severely |3.7.A.2b| | 1 |
| Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Nearside Rear Braking system leaking |3.6.A.1| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Nearside Front Wheel nut|s| loose |4.2.A.1e| | 1 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front Body has a sharp edge caused by corrosion door........ |6.1.C.1| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Offside Rear Anti-roll bar attachment bracket/mounting damaged and its strength is seriously reduced |2.4.G.1| | 1 |
| Nearside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Front Brake hose kinked |3.6.B.4b| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Nearside Front Upper Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Rear Rear position lamp|s| incomplete |1.1.4a| | 1 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
| Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Rear Braking system leaking |3.6.A.1| | 1 |
| Nearside Front Sub-frame corroded and seriously weakened |2.4.G.1| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Braking system leaking |3.6.A.1| | 1 |
| Nearside Front position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
| Nearside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Front Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Headlamp aim not tested |1.8.A.1c| | 1 |
| Nearside Front Brake pipe inadequately supported |3.6.B.1| | 1 |
| Lower Steering column universal joint damaged and unserviceable column bearing carrier damaged |2.2.C.1d| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Battery insecure |1.9.1| | 1 |
| Nearside Braking system leaking |3.6.A.1| | 1 |
| Nearside Body insecure to the extent that stability is seriously impaired step (6.2.2 (a) (ii)) | 1 |
| Offside Body insecure to the extent that stability is seriously impaired step (6.2.2 (a) (ii)) | 1 |
| Nearside Rear Body insecure to the extent that stability is seriously impaired inner sill (6.2.2 (a) (ii)) | 1 |
| Central Rear Body insecure to the extent that stability is seriously impaired inner sill (6.2.2 (a) (ii)) | 1 |
| Offside Front Body insecure to the extent that stability is seriously impaired outer sill (6.2.2 (a) (ii)) | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Direction indicator incomplete |1.5.A1b| | 1 |
| Nearside Front Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
| Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Fuel system component insecure |7.2.1| | 1 |