MOT History from tests of diesel IVECO 3510s year 1996

Review the list of common IVECO 3510 failures below or to perform a specific mot history check on your IVECO then use our popular KnowYourCar service

mot history

Pass percent:60.90%

(The average a diesel IVECO 3510 year 1996 passes without issue)

Based on:3,650 MOT Tests

Most common failures	No# failures
Brake pipe excessively corroded	420
Registration plate lamp issues	394
Headlamp aim out of alignment	286
Parking brake: efficiency below requirements \|3.7.B.7\|	266
Service brake: efficiency below requirements \|3.7.B.7\|	211
Windscreen wiper does not clear the windscreen effectively	198
Brakes imbalanced across an axle	196
Front brake disc in such a condition that it is seriously weakened	137
Rear parking brake recording little or no effort	135
Rear brake application uneven	121
Brake hose excessively deteriorated	105
Registration plate issues	84
Nearside rear brake recording little or no effort \|3.7.B.5a\|	67
Nearside Front position lamp\|s\| not working \|1.1.A.3b\|	57
Offside Rear fog lamp not working \|1.3.2b\|	54
Nearside Stop lamp not working \|1.2.1b\|	52
Offside Track rod end ball joint has excessive play \|2.2.B.1f\|	49
Offside rear brake recording little or no effort \|3.7.B.5a\|	49
Offside Stop lamp not working \|1.2.1b\|	47
Exhaust has a major leak of exhaust gases \|7.1.2\|	46
Offside Front position lamp\|s\| not working \|1.1.A.3b\|	44
Nearside Front Seat belt anchorage prescribed area is excessively corroded \|5.2.6\|	43
Fuel system component insecure \|7.2.1\|	40
Front brake application uneven	39
Nearside Track rod end ball joint has excessive play \|2.2.B.1f\|	39
Nearside Front wheel bearing has excessive play \|2.5.A.3c\|	38
Offside Front Seat belt anchorage prescribed area is excessively corroded \|5.2.6\|	37
Nearside Rear rear brake recording little or no effort \|3.7.B.5a\|	37
Horn not working \|1.6.2a\|	36
Rear brake binding	36
Offside Front wheel bearing has excessive play \|2.5.A.3c\|	34
Nearside Front Track rod end ball joint has excessive play \|2.2.B.1f\|	33
Offside Front wheel bearing rough when rotated \|2.5.A.2\|	33
Fuel system component leaking \|7.2.3\|	30
Nearside Headlamp not working on dipped beam \|1.7.5a\|	30
Exhaust system not adequately supported \|7.1.1\|	29
Offside Rear rear brake recording little or no effort \|3.7.B.5a\|	29
Parking brake lever has no reserve travel \|3.1.6b\|	27
Nearside Front wheel bearing rough when rotated \|2.5.A.2\|	27
Emissions not tested \|7.0\|	27
Offside Headlamp not working on dipped beam \|1.7.5a\|	26
Offside Rear position lamp\|s\| excessively deteriorated so that it is not visible from a reasonable distance \|1.1.A.3d\|	25
Windscreen has damage	25
Nearside Rear position lamp\|s\| excessively deteriorated so that it is not visible from a reasonable distance \|1.1.A.3d\|	24
Offside Front Track rod end ball joint has excessive play \|2.2.B.1f\|	24
Nearside Front Direction indicator not working \|1.4.A.2c\|	24
Nearside Side repeater not working \|1.4.A.2c\|	23
Nearside Front Side repeater not working \|1.4.A.2c\|	22
Rear Exhaust system not adequately supported \|7.1.1\|	21
Nearside Rear Stop lamp not working \|1.2.1b\|	21
Nearside Headlamp not working on main beam \|1.7.5a\|	20
Offside Front Suspension component mounting prescribed area is excessively corroded \|2.4.A.3\|	19
Offside Obligatory mirror seriously damaged, affecting the rear view \|8.1.2a\|	19
Offside Headlamp not working on main beam \|1.7.5a\|	19
Nearside Headlamp not in good working order adversely affecting beam image \|1.2.4a\|	19
rear brakes release unevenly \|3.7.B.4\|	18
Offside Side repeater not working \|1.4.A.2c\|	18
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings \|6.1.B.2\|	18
Offside Front brake disc excessively pitted \|3.5.1h\|	18
Offside Front Front wheel bearing has excessive play \|2.5.A.3c\|	18
Nearside Windscreen wiper blade deteriorated \|8.2.2\|	18
Offside Front Body has a sharp edge caused by corrosion \|6.1.C.1\|	17
Nearside Front Torsion bar excessive play at an end fixing \|2.4.E.2\|	17
Offside Rear Body has a sharp edge caused by corrosion \|6.1.C.1\|	17
Brake load sensing valve linkage seized \|3.6.E.3\|	16
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings \|6.1.B.2\|	16
Nearside Front Suspension component mounting prescribed area is excessively corroded \|2.4.A.3\|	16
Nearside Seat belt anchorage prescribed area is excessively corroded \|5.2.6\|	15
Nearside Steering rack gaiter split \|2.2.D.2d\|	15
Exhaust emits excessive smoke or vapour of any colour \|7.4.B.4\|	15
Offside Rear Stop lamp not working \|1.2.1b\|	15
Nearside Front Front position lamp\|s\| not working \|1.1.A.3b\|	15
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings \|6.1.B.2\|	15
Nearside Front Body has a sharp edge caused by corrosion \|6.1.C.1\|	15
Nearside Rear position lamp\|s\| adversely affected by the operation of another lamp \|1.1.A.3f\|	14
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings \|6.1.B.2\|	14
Offside Front Front position lamp\|s\| not working \|1.1.A.3b\|	14
Offside Windscreen wiper blade deteriorated \|8.2.2\|	14
Offside Rear Rear fog lamp not working \|1.3.2b\|	14
Brake hose has insufficient room to move	14
Body has a sharp edge caused by corrosion \|6.1.C.1\|	14
Nearside Rear Anti-roll bar has excessive play in a pin/bush \|2.4.G.2\|	13
Battery insecure \|1.9.1\|	13
Front Windscreen wiper not operating automatically when switched on \|8.2.1b\|	13
Nearside Rear Body has a sharp edge caused by corrosion \|6.1.C.1\|	13
Nearside Front Headlamp not working on dipped beam \|1.7.5a\|	13
Rear Exhaust has part of the system excessively deteriorated \|7.1.1a\|	13
Brake pedal spongy \|3.3.B.1b\|	13
Nearside Body has a sharp edge caused by corrosion \|6.1.C.1\|	13
Offside Seat belt anchorage prescribed area is excessively corroded \|5.2.6\|	12
Brake performance not tested \|3.7.A.1\|	12
Rear Exhaust has a major leak of exhaust gases \|7.1.2\|	12
Nearside Front Front wheel bearing has excessive play \|2.5.A.3c\|	12
Nearside Front Direction indicator incorrect colour \|1.4.A.2f\|	12
Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush \|2.4.B.2\|	12
Nearside Front Front wheel bearing rough when rotated \|2.5.A.2\|	12
Front Exhaust has a major leak of exhaust gases \|7.1.2\|	12
Centre Statutory seat belt missing \|5.1.1\|	12
Offside Front Torsion bar excessive play at an end fixing \|2.4.E.2\|	12
Brake hose damaged	12
Offside Body has a sharp edge caused by corrosion \|6.1.C.1\|	11
Stop lamp not working \|1.2.1b\|	11
Front passenger door cannot be opened from outside the vehicle \|6.2.B.1b\|	11
Nearside Rear brake drum contaminated by oil \|3.5.1h\|	11
Offside Rear Anti-roll bar has excessive play in a pin/bush \|2.4.G.2\|	11
Offside Front Windscreen wiper blade deteriorated \|8.2.2\|	11
Offside rear brake grabbing severely \|3.7.A.5b\|	11
Offside Headlamp not in good working order adversely affecting beam image \|1.2.4a\|	11
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings \|6.1.B.2\|	11
Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush \|2.4.B.2\|	11
Offside Rear Direction indicator incomplete \|1.5.A1b\|	10
Nearside Front brake disc excessively pitted \|3.5.1h\|	10
Exhaust has part of the system excessively deteriorated \|7.1.1a\|	10
Offside Steering rack gaiter split \|2.2.D.2d\|	10
Driver`s door cannot be opened from outside the vehicle \|6.2.B.1b\|	10
Nearside Front Seat belt locking mechanism does not secure or release \|5.2.5a\|	10
Nearside Obligatory mirror seriously damaged, affecting the rear view \|8.1.2a\|	10
Offside Front Brake pipe leaking \|3.6.A.1\|	10
Nearside Rear Rear position lamp\|s\| excessively deteriorated so that it is not visible from a reasonable distance \|1.1.A.3d\|	10
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement \|7.2.4b\|	10
Offside Rear position lamp\|s\| adversely affected by the operation of another lamp \|1.1.A.3f\|	9
Offside Rear Anti-roll bar linkage corroded and seriously weakened \|2.4.G.1\|	9
Exhaust emits an excessive level of metered smoke for a turbo charged engine \|7.4.B.3b\|	9
Nearside Rear Direction indicator not working \|1.4.A.2c\|	9
Windscreen wiper not operating automatically when switched on \|8.2.1b\|	9
Rear fog lamp not working \|1.3.2b\|	9
Fuel cap/sealing device sealing washer missing \|7.2.4c\|	9
Steering rack insecure \|2.2.B.1a\|	9
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings \|6.1.B.2\|	9
Offside Front Direction indicator not working \|1.4.A.2c\|	9
Rear Rear fog lamp not working \|1.3.2b\|	9
Nearside Rear Suspension component mounting prescribed area is excessively corroded \|2.4.A.3\|	8
Offside Front Headlamp not working on dipped beam \|1.7.5a\|	8
Hazard warning lamps not flashing in phase, with ignition on \|1.4.B.1f\|	8
Rear fog lamp tell tale not working \|1.3.1b\|	8
Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings \|6.1.B.2\|	8
Offside Front Body has a sharp edge caused by damage \|6.1.C.1\|	8
Offside Front Front wheel bearing rough when rotated \|2.5.A.2\|	8
Centre Exhaust has a major leak of exhaust gases \|7.1.2\|	8
Nearside Rear Leaf spring fractured \|2.4.B.1a\|	8
Nearside Rear Braking system leaking \|3.6.A.1\|	8
Nearside rear brake grabbing severely \|3.7.A.5b\|	8
Service brake: efficiency below requirements \|3.7.D.4\|	8
Offside Rear Rear position lamp\|s\| excessively deteriorated so that it is not visible from a reasonable distance \|1.1.A.3d\|	8
Nearside Front Windscreen wiper blade deteriorated \|8.2.2\|	8
Nearside front brake juddering severely \|3.7.A.2b\|	7
Nearside Rear Direction indicator incomplete \|1.5.A1b\|	7
Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` \|8.3.1e\|	7
Offside Rear position lamp\|s\| incomplete \|1.1.4a\|	7
Power steering pipe\|s\| or hose\|s\| leaking \|2.3.3b\|	7
Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings \|6.1.B.2\|	7
Hazard warning lamps not flashing in phase, with ignition off \|1.4.B.1f\|	7
Offside Front Side repeater not working \|1.4.A.2c\|	7
Brake pedal anti-slip provision incomplete \|3.3.A.1b\|	7
Offside Rear Suspension spring mounting prescribed area is excessively corroded \|2.4.A.3\|	7
Nearside Front Brake hose twisted \|found during steering lock to lock check\| \|2.2.D.2b\|	7
Offside Rear Suspension component mounting prescribed area is excessively corroded \|2.4.A.3\|	7
Steering system has excessive free play detected at the steering wheel \|steering rack fitted\| \|2.2.A.1b\|	7
Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings \|6.1.B.2\|	7
Exhaust mounting missing \|7.1.1b\|	7
Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement \|2.4.G.2\|	7
Steering system excessively tight \|2.2.D.1\|	7
Brake load sensing valve linkage defective and function impaired \|3.6.E.3\|	7
Windscreen wiper blade insecure	7
Power steering component\|s\| leaking \|2.3.3b\|	7
Nearside Front Upper Tie bar/rod has excessive play in a ball joint \|2.4.G.2\|	7
Nearside Stop lamp adversely affected by the operation of another lamp \|1.2.1f\|	6
Nearside Rear Anti-roll bar linkage corroded and seriously weakened \|2.4.G.1\|	6
Offside Rear position lamp\|s\| not working \|1.1.A.3b\|	6
Offside Front Direction indicator incorrect colour \|1.4.A.2f\|	6
Exhaust emits an excessive level of metered smoke for a non-turbo charged engine \|7.4.B.3b\|	6
Offside Front Braking system leaking \|3.6.A.1\|	6
Rear Stop lamp not working \|1.2.1b\|	6
Brake pedal has insufficient reserve movement \|3.3.A.5\|	6
Nearside Rear Brake pipe inadequately clipped \|3.6.B.1\|	6
Offside Rear Leaf spring fractured \|2.4.B.1a\|	6
Steering system excessively rough \|2.2.D.1\|	6
Offside front brake binding \|3.7.B.1\|	6
Nearside Front Direction indicator incomplete \|1.5.A1b\|	6
Exhaust has a part missing \|7.1.1a\|	6
Offside Body has a sharp edge caused by damage \|6.1.C.1\|	6
Rear Anti-roll bar has excessive play in a pin/bush \|2.4.G.2\|	6
Fuel tank leaking \|7.2.3\|	6
Nearside Rear Rear position lamp\|s\| insecure \|1.1.A.3a\|	6
Front brake disc excessively pitted \|3.5.1h\|	6
Nearside Rear Leaf spring longitudinally displaced \|2.4.B.1d\|	6
Offside Rear position lamp\|s\| insecure \|1.1.A.3a\|	6
Offside Front Headlamp not working on main beam \|1.7.5a\|	6
Nearside Front suspension has excessive play in a lower suspension ball joint \|2.5.B.1a\|	6
Driver`s seat insecure \|6.2.A.1\|	6
Offside Rear Braking system leaking \|3.6.A.1\|	6
Nearside Rear Leaf spring splayed and action impaired \|2.4.B.1c\|	6
Nearside Rear Leaf spring has excessive wear in an anchor pin and/or bush \|2.4.B.2\|	6
Bonnet cannot be secured in the closed position \|8.4.1\|	5
Nearside Seat belt retracting mechanism defective \|5.2.5b\|	5
Centre Exhaust system not adequately supported \|7.1.1\|	5
Mechanical brake component has restricted free movement	5
Offside Rear position lamp\|s\| incorrect colour \|1.1.A.3e\|	5
Service brake efficiency below requirements (1.2.2 (a) (i))	5
Offside Rear fog lamp emits a light other than red \|1.3.2e\|	5
Rear Brake load sensing valve linkage seized \|3.6.E.3\|	5
Direction indicators not working \|1.4.A.2c\|	5
Offside Front Lower Suspension arm has excessive play in a ball joint \|2.4.G.2\|	5
Offside Front Brake pipe inadequately clipped \|3.6.B.1\|	5
Nearside front brake binding \|3.7.B.1\|	5
Nearside Front Headlamp not in good working order adversely affecting beam image \|1.2.4a\|	5
Nearside Front Body has a sharp edge caused by damage \|6.1.C.1\|	5
Offside Rear fog lamp excessively deteriorated so that it is not visible from a reasonable distance \|1.3.2d\|	5
Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings \|6.1.B.2\|	5
Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement \|2.4.G.2\|	5
Nearside Front suspension has excessive play in a upper suspension ball joint \|2.5.B.1a\|	5
Brake pedal creeps down while the pedal is held under pressure \|3.3.B.1a\|	5
Brake hydraulic reservoir fluid level below minimum level \|3.6.G.1b\|	5
Nearside Front Shock absorber has a serious fluid leak \|2.7.3\|	5
Offside Front Subframe mounting prescribed area is excessively corroded \|2.4.A.3\|	5
Nearside Rear Suspension spring mounting prescribed area is excessively corroded \|2.4.A.3\|	5
Offside Front Brake hose twisted \|found during steering lock to lock check\| \|2.2.D.2b\|	5
Offside Front Upper Tie bar/rod has excessive play in a ball joint \|2.4.G.2\|	5
Nearside Rear Direction indicator adversely affected by the operation of another lamp \|1.4.A.2h\|	5
Offside Rear Leaf spring longitudinally displaced \|2.4.B.1d\|	5
Offside Rear Direction indicator not working \|1.4.A.2c\|	5
Power steering malfunctioning \|2.3.3a\|	5
Windscreen washer not working	5
Nearside Rear Direction indicator incorrect colour \|1.4.A.2f\|	5
Nearside Rear Brake pipe inadequately supported \|3.6.B.1\|	5
Rear Exhaust mounting missing \|7.1.1b\|	5
Front passenger door cannot be opened from inside the vehicle \|6.2.B.1b\|	5
Offside Rear wheel bearing has excessive play \|2.6.2\|	5
Offside Headlamp aim not tested \|1.8.A.1c\|	5
Fuel cap/sealing device does not fasten securely by positive means \|7.2.4b\|	5
Nearside Front Steering rack gaiter split \|2.2.D.2d\|	5
Offside Front Steering rack gaiter split \|2.2.D.2d\|	5
Brake pedal creeps down when held under pressure \|3.3.B.1a\|	5

We get to these numbers by trawling through over 1 billion MOT test results since 2004 and crunched the numbers. We remove anything to do with Tyres, as they are model independent and group together common non-model specific issues. We are trying to get to a picture of what models have what issues.

Please note: We take the data from the DVSA. This data is raw and can contain typos and spelling mistakes that garages may have entered while recording a MOT result. Specifically miss-match on names of models and makes. We are constantly cleaning the data so bear with the odd issue.

Got suggestions? We’re improving this section all the time. If you have any suggestions, please let us know.

MOT History from tests of diesel IVECO 3510s year 1996

Find us on Facebook