| Most common failures | No# failures |
|---|
| Parking brake: efficiency below requirements |3.7.B.7| | 67 |
| Brake pipe excessively corroded | 61 |
| Registration plate lamp issues | 49 |
| Headlamp aim out of alignment | 43 |
| Rear parking brake recording little or no effort | 34 |
| Windscreen wiper does not clear the windscreen effectively | 25 |
| Service brake: efficiency below requirements |3.7.B.7| | 18 |
| Brakes imbalanced across an axle | 16 |
| Parking brake lever has no reserve travel |3.1.6b| | 14 |
| Offside Stop lamp not working |1.2.1b| | 10 |
| Brake load sensing valve seized |3.6.E.3| | 9 |
| Rear brake binding | 9 |
| Registration plate issues | 9 |
| Brake load sensing valve linkage seized |3.6.E.3| | 8 |
| Nearside Stop lamp not working |1.2.1b| | 8 |
| Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 8 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 8 |
| Battery insecure |1.9.1| | 7 |
| Horn not working |1.6.2a| | 7 |
| Offside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 7 |
| Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 6 |
| Offside Rear fog lamp not working |1.3.2b| | 6 |
| Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 6 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 5 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 5 |
| Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 5 |
| Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 5 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 5 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 5 |
| Nearside Rear Leaf spring to axle securing bolt insecure |2.4.B.7b| | 4 |
| Windscreen wiper blade insecure | 4 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 4 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 4 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 4 |
| Offside Headlamp not working on main beam |1.7.5a| | 4 |
| Brake load sensing valve inoperative |3.6.E.3| | 3 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 3 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 3 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
| Offside Rear Leaf spring to axle securing bolt insecure |2.4.B.7b| | 3 |
| Front brake application uneven | 3 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 3 |
| Nearside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 3 |
| Offside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 3 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Brake hose excessively deteriorated | 3 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 3 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 3 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 3 |
| Nearside Rear Lower Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 3 |
| Offside Rear Lower Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 3 |
| Offside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 3 |
| Nearside Rear All position lamps not working |1.1.A.3b| | 3 |
| Windscreen has damage | 3 |
| Nearside Headlamp not working on main beam |1.7.5a| | 3 |
| Brake hose damaged | 3 |
| Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 2 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Front Upper Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 2 |
| Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Offside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 2 |
| Rear Brake load sensing valve linkage seized |3.6.E.3| | 2 |
| Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 2 |
| Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 2 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
| Offside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 2 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Centre Front Seat belt locking mechanism does not secure or release |5.2.5a| | 2 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 2 |
| Rear fog lamp not working |1.3.2b| | 2 |
| Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 2 |
| Offside Rear brake disc contaminated by oil |3.5.1h| | 2 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
| Nearside Rear position lamp|s| incorrect colour |1.1.A.3e| | 2 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 2 |
| Nearside Headlamp insecure |1.7.3| | 2 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Brake pedal anti-slip provision incomplete |3.3.A.1b| | 2 |
| Nearside Brake cable locking device insecure |3.5.1l| | 2 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside Rear Leaf spring to axle securing nut insecure |2.4.B.7b| | 2 |
| Nearside front brake binding |3.7.B.1| | 2 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Fuel tank insecure |7.2.1| | 2 |
| Rear Lower Body component insecure rear light support panel badly corrodid (6.2.1 (a) (i)) | 2 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Front Leaf spring deteriorated and seriously weakened |2.4.B.1a| | 2 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 2 |
| Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 2 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 2 |
| Nearside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 2 |
| Nearside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Offside Rear All position lamps not working |1.1.A.3b| | 2 |
| Offside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 2 |
| Front brake disc in such a condition that it is seriously weakened | 2 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
| Brake load sensing valve linkage defective and function impaired (1.1.17 (a)) | 2 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Horn not working (7.7 (a) (ii)) | 2 |
| Steering system excessively rough |2.2.D.1| | 2 |
| Brake warning device not working correctly |3.3.D.3a| | 2 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 2 |
| Main beam `tell-tale` not working |1.7.4c| | 2 |
| Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Steering rack gaiter split |2.2.D.2d| | 2 |
| Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 2 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 2 |
| Offside Rear Leaf spring shackle pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| All position lamps not working |1.1.A.3b| | 1 |
| Nearside Rear Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Rear Brake pipe excessively chafed |3.6.B.2c| | 1 |
| Brake load sensing valve defective and function impaired |3.6.E.3| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Offside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Rear Leaf spring cracked |2.4.B.1a| | 1 |
| Offside Rear Leaf spring fractured |2.4.B.1a| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Headlamps matched pair are incorrectly positioned |1.7.3| | 1 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Wheel nut|s| loose |4.2.A.1e| | 1 |
| Nearside Front Wheel bolt|s| loose |4.2.A.1e| | 1 |
| Offside Rear Rear position lamp|s| incomplete |1.1.4a| | 1 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Offside Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Nearside Steering locking device insecure |2.2.C.1g| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Nearside Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Nearside Front Seat belt insecurely fixed to the seat |5.2.1a| | 1 |
| Offside Rear brake caliper has restricted free movement |3.5.1k| | 1 |
| Offside Brake cable has restricted free movement |3.5.1k| | 1 |
| Offside Rear Brake back plate|s| securing device excessively deteriorated |3.5.1j| | 1 |
| Nearside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Horn not loud enough to be heard by another road user |1.6.2b| | 1 |
| Offside Front Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner chasse |6.1.B.2| | 1 |
| Offside Front Vehicle structure has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings inner chasse as marked up with an yellow chalk |6.1.B.2| | 1 |
| Offside Front Brake hose excessively damaged |3.6.B.4d| | 1 |
| Nearside Rear Position lamp adversely affected by the operation of another lamp (4.2.3 (c)) | 1 |
| Nearside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Rear Leaf spring fractured (5.3.1 (b) (i)) | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Fuel tank insecure both tank straps broken |7.2.1| | 1 |
| Brake load sensing valve defective and function impaired linkage broken |3.6.E.3| | 1 |
| Nearside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Offside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear Brake load sensing valve has been disconnected and was fitted as standard |3.6.E.2| | 1 |
| Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Rear Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Offside Front Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Sub-frame corroded and seriously weakened |2.4.G.1| | 1 |
| Offside Front Sub-frame corroded and seriously weakened |2.4.G.1| | 1 |
| Nearside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Offside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Nearside Rear Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Nearside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
| Centre Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Offside Front Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting inner sill (6.2.2 (d) (i)) | 1 |
| Offside Front Outer Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting sill (6.2.2 (d) (i)) | 1 |
| Offside Front Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting box section (6.2.2 (d) (i)) | 1 |
| Offside Front Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting front cab mounting section inadequately repaired glass fibre repair (6.2.2 (d) (i)) | 1 |
| Nearside Front Inner Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting sill (6.2.2 (d) (i)) | 1 |
| Nearside Front Inner Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting box section (6.2.2 (d) (i)) | 1 |
| Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Brake pipe at imminent risk of failure or fracture (1.1.11 (a)) | 1 |
| Offside Rear Service brake lagging in operation (1.2.1 (d)) | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Offside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Nearside Rear Brake cable has restricted free movement |3.5.1k| | 1 |
| Nearside Rear brake caliper has restricted free movement |3.5.1k| | 1 |
| Offside Rear reflector missing |1.5.1a| | 1 |
| Power steering malfunctioning |2.3.3a| | 1 |
| Nearside Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Leaf spring to axle securing bolt insecure |2.4.B.7b| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Rear Loading door cannot be secured in the closed position |6.4.1| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Rear Lower Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Rear Leaf spring to axle securing nut insecure |2.4.B.7b| | 1 |
| Nearside Front Lower Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar linkage fractured |2.4.G.1| | 1 |
| Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Obligatory mirror insecure |8.1.1| | 1 |
| Fuel system component insecure |7.2.1| | 1 |
| Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Nearside passenger door does not latch securely closed |6.2.B.1a| | 1 |
| passenger door catch insecure |6.2.B.2| | 1 |
| Nearside All position lamps not working |1.1.A.3b| | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar linkage missing |2.4.G.1| | 1 |
| Offside Front Upper Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Front All position lamps not working |1.1.A.3b| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Offside Front Direction indicators not working |1.4.A.2c| | 1 |
| Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Rear Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
| Offside Front Lower Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced outer step (6.1.1 (c) (i)) | 1 |
| Nearside Rear Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Rear Service brake has no recorded effort at a wheel |1.2.1 |a| |ii|| | 1 |
| Rear Parking brake inoperative on one side Boths |1.4.1 |a|| | 1 |
| Offside Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Nearside Front Lower Fuel system component leaking |7.2.3| | 1 |
| Nearside Steering rack insecure |2.2.B.1a| | 1 |
| Nearside Front Steering component damaged and unserviceable |2.2.C.1d| | 1 |
| Offside Front Steering component damaged and unserviceable |2.2.C.1d| | 1 |
| Nearside Front Body or chassis is cracked, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Rear brake application uneven | 1 |
| rear brakes release unevenly |3.7.B.4| | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Power steering pipe/hose leaking (2.1.5 (a)) | 1 |
| Front Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Nearside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Offside Rear position lamp|s| incomplete |1.1.4a| | 1 |
| Nearside Indicator switch faulty |1.4.A.1| | 1 |
| Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Wheel stud|s| missing |4.2.A.1e| | 1 |
| Nearside Front Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Nearside Front suspension has excessive play in a pin or bush of an upper wishbone inner bearing |2.5.B.1a| | 1 |
| Nearside Rear Leaf spring has excessive side play at eye |anchor| |2.4.B.4| | 1 |
| Nearside Rear Leaf spring has excessive side play at eye |shackle| |2.4.B.4| | 1 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.4.B.1| | 1 |
| Nearside Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Centre Seat belt insecurely fixed to the seat |5.2.1a| | 1 |
| Nearside Rear Upper Anti-roll bar linkage synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Upper Anti-roll bar linkage synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Lower Anti-roll bar linkage synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Lower Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Front position lamp|s| not working |1.1.A.3b| | 1 |
| Centre Front Seat belt flexible stalk damaged likely to lead to failure under load |5.2.4a| | 1 |
| Offside Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Rear Emissions not tested |7.0| | 1 |
| Front passenger door does not latch securely closed |6.2.B.1a| | 1 |
| Centre Front Brake pipe leaking |3.6.A.1| | 1 |
| Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Emissions not tested |7.0| | 1 |
| Brake pedal has insufficient reserve travel (1.1.2 (a)) | 1 |
| Brake lever has abnormal movement of levers indicating excessive wear or maladjustment (1.1.15 (f)) | 1 |
| Offside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect Reflector is not connected to adjuster (4.1.2 (c)) | 1 |
| Offside Front Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Outline marker lamp missing (4.2.1 (a) (ii)) | 1 |
| Offside Rear Outline marker lamp missing (4.2.1 (a) (ii)) | 1 |
| Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength The crossmember for the rear shock absorbers and the chassis both sides where that crossmember is attached (5.3.6 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Subframe in two places adjacent to wishbone mounts (5.3.6 (a) (i)) | 1 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Front Upper Position lamp not working top side light (4.2.1 (a) (ii)) | 1 |
| Offside Front Body panel corroded and likely to cause injury sill has sharp edges (6.2.1 (a) (i)) | 1 |
| Central Exhaust has a major leak of exhaust gases centre pipe (6.1.2 (a)) | 1 |
| Offside Front Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting (6.2.2 (d) (i)) | 1 |
| Nearside Front Upper Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Front Leaf spring damaged and permanently distorted |2.4.B.1a| | 1 |
| Offside Leaf spring fitted in such a way that the axle is misaligned |2.4.B.1e| | 1 |
| Nearside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Brake pedal has insufficient reserve travel |1.1.2 |a|| | 1 |
| Offside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Offside Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Offside Rear Direction indicator incorrect colour |4.4.3 |a|| | 1 |
| Offside Rear Direction indicator lens defective such that the emitted light is adversely affected |4.4.1 |b| |ii|| | 1 |
| Central Rear Body component likely to become detached Tipper body. |6.2.1 |a| |ii|| | 1 |
| Offside Rear Body component corroded and likely to cause injury tipper body |6.2.1 |a| |i|| | 1 |
| Offside Front Body component corroded and likely to cause injury tipper body |6.2.1 |a| |i|| | 1 |
| Nearside Rear Body component corroded and likely to cause injury tipper body |6.2.1 |a| |i|| | 1 |
| Nearside Front Body component corroded and likely to cause injury tipper body |6.2.1 |a| |i|| | 1 |
| Central Rear Body component corroded and likely to cause injury |6.2.1 |a| |i|| | 1 |
| Central Rear Body component corroded and likely to cause injury tipper body |6.2.1 |a| |i|| | 1 |
| Central Rear Trailer electrical socket |13 pin| not functioning at all |4.10 |c| |ii|| | 1 |
| Central Parking brake lever has excessive movement indicating incorrect adjustment No reserve travel. |1.1.6 |c|| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Rear Brake load sensing valve linkage defective and function impaired (1.1.17 (a)) | 1 |
| Central Brake lever has abnormal movement of levers indicating excessive wear or maladjustment (1.1.15 (f)) | 1 |
| Offside Front Windscreen in such a condition that visibility through swept area is seriously affected (3.2 (c) (ii)) | 1 |
| Windscreen washer not working | 1 |
| Nearside Front Vehicle Identification Number obviously falsified (0.2 (b)) | 1 |
| Nearside Rear Outline marker lamp does not illuminate simultaneously with the position lamps (4.2.2 (a)) | 1 |
| Offside Rear Outline marker lamp does not illuminate simultaneously with the position lamps (4.2.2 (a)) | 1 |
| Nearside Rear Stop lamp(s) lens defective such that the emitted light is adversely affected Wrong side of light (4.3.1 (b) (ii)) | 1 |
| Rear fog lamp does not emit a steady red light (4.5.4 (a)) | 1 |
| Offside Front Suspension component ball joint dust cover no longer prevents the ingress of dirt Tie bar front (5.3.4 (b) (ii)) | 1 |
| Offside Front Lower Steering column universal joint likely to become detached (2.1.3 (a) (ii)) | 1 |
| Nearside Rear Lower Floor excessively deteriorated Sill corroded (6.2.4 (a) (i)) | 1 |
| Offside Front Lower Floor excessively deteriorated Corroded at rear sill (6.2.4 (a) (i)) | 1 |
| Nearside Rear Parking (secondary brake) on a single line braking system has no recorded effort at a wheel (1.3.1 (a) (ii)) | 1 |
| Offside Rear Parking (secondary brake) on a single line braking system has no recorded effort at a wheel (1.3.1 (a) (ii)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Exhaust system insecure After cat (6.1.2 (a)) | 1 |
| Nearside Rear Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Bumper likely to become detached (6.1.4 (a) (ii)) | 1 |
| Nearside Front Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Steering system fouling |2.2.D.2a| | 1 |
| Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Inner Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Power steering component|s| leaking |2.3.3b| | 1 |
| Nearside Rear Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Offside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Nearside Rear Brake lever has restricted free movement |3.5.1k| | 1 |
| Offside Rear Brake lever has restricted free movement |3.5.1k| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Centre Rear Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Offside Rear Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Outer All position lamps not working |1.1.A.3b| | 1 |
| Nearside Outer All position lamps not working |1.1.A.3b| | 1 |
| Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| All direction indicators not working (4.4.1 (a) (ii)) | 1 |
| Nearside Rear Body component damaged and likely to cause injury lamp (6.2.1 (a) (i)) | 1 |
| Offside Front Body component corroded and likely to cause injury outer sill (6.2.1 (a) (i)) | 1 |
| Front Headlamp not working on main beam both |1.7.5a| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Front Side repeater not working both |1.4.A.2c| | 1 |
| Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Offside Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Oil leaking excessively from engine |8.4.1 |a| |i|| | 1 |
| Offside Front Brake hose excessively damaged |1.1.12 |b| |ii|| | 1 |
| Brake load sensing valve defective and function impaired linkage missing |3.6.E.3| | 1 |
| Windscreen wiper blade missing both front blades split |8.2.2| | 1 |
| Nearside Front Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Nearside Rear Valve stem seriously damaged |4.1.D.1e| | 1 |
| Offside Rear Valve stem seriously damaged |4.1.D.1e| | 1 |
| Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Brake valve locking device insecure |3.6.A.2d| | 1 |
| Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Indicator switch faulty |1.4.A.1| | 1 |
| Brake load sensing valve has been disconnected and was fitted as standard |3.6.E.2| | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Hinged tailboard cannot be secured in the closed position |6.4.1| | 1 |
| Offside Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Nearside All direction indicators not working all |4.4.1 |a| |ii|| | 1 |
| Offside All direction indicators not working all |4.4.1 |a| |ii|| | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner arch |5.3.6 |a| |i|| | 1 |
| Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Rear Anti-roll bar linkage pin or bush likely to become detached (5.3.4 (a) (ii)) | 1 |
| Offside Rear Inner Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Emissions not tested exhaust leak (8.2.2.2 (e)) | 1 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Other passenger door cannot be opened from outside the vehicle bonnet (6.2.3 (a)) | 1 |
| Nearside Rear Leaf spring fractured |2.4.B.1a| | 1 |
| Offside Front Brake master cylinder/servo mounting prescribed area is fractured |3.6.C.3| | 1 |
| Brake load sensing valve linkage defective and function impaired not connected |3.6.E.3| | 1 |
| Offside Rear Anti-roll bar linkage cracked broken |2.4.G.1| | 1 |
| Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Rear Direction indicator incomplete |1.5.A1b| | 1 |
| Nearside Rear Leaf spring anchor bracket insecure to the extent that relative movement is visible |5.3.1 |a| |ii|| | 1 |
| Offside Rear Leaf spring anchor bracket insecure to the extent that relative movement is visible |5.3.1 |a| |ii|| | 1 |
| Fluid leaking continuously posing a serious risk to road safety engine derv leak |8.4.1 |a| |ii|| | 1 |
| Offside Rear Position lamp not working marker lamp insecure and not working |4.2.1 |a|| | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Nearside Rear Anti-roll bar linkage pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Fuel tank insecure fixing strap broken |7.2.1| | 1 |
| Offside Rear Front position lamp|s| not working side marker lamp insecure |1.1.A.3b| | 1 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |
| Rear Brake valve retaining device insecure |3.6.A.2d| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| lower universal joint worn |2.2.A.1b| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded body support mount |2.4.A.3| | 1 |
| Offside Front Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Lower Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Outer Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Upper Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front Battery insecure |1.9.1| | 1 |
| Offside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Brake pedal anti-slip provision worn smooth (1.1.2 (c)) | 1 |
| Power steering component leaking (2.1.5 (a)) | 1 |
| Offside Front Upper Suspension component pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Leaf spring shackle pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Upper Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Headlamp aim not tested (4.1.2 (b)) | 1 |
| Rear fog lamp switch inoperative (4.5.3 (a)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Front Outer Seat belt missing (7.1.2 (a)) | 1 |
| Nearside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Nearside Front Direction indicator lens defective such that the emitted light is adversely affected (4.4.1 (b) (ii)) | 1 |
| Nearside Rear Brake pipe at imminent risk of failure or fracture leaking (1.1.11 (a)) | 1 |
| Rear Brake load sensing valve linkage defective and function impaired linkage missing (1.1.17 (a)) | 1 |
| Rear Brake load sensing valve seized and ABS not fitted or inoperative (1.1.17 (c) (ii)) | 1 |
| Offside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Brake performance not tested leaking pipe lav not working (1.2.1 (g)) | 1 |
| Offside Front Headlamp missing |4.1.1 |a| |ii|| | 1 |
| Offside Rear Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Offside Rear Stop lamp|s| lens defective such that the emitted light is adversely affected |4.3.1 |b| |ii|| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Rear Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Nearside Front Upper Suspension arm ball joint likely to become detached (5.3.4 (a) (ii)) | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Below B post inside plus inner sill. (6.2.2 (d) (i)) | 1 |
| Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Under B post. Inside. (6.2.2 (d) (i)) | 1 |
| Bonnet primary retaining device insecure (3.1 (c)) | 1 |
| Exhaust emissions exceed level of metered smoke for a turbo charged engine (8.2.2.2 (b)) | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Bonnet retaining device ineffective |8.4.2| | 1 |
| Spare wheel insecure |6.4.2| | 1 |
| Rear Brake valve leaking Load sensing |3.6.A.1| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Rear Brake linkage locking device missing |3.5.1l| | 1 |
| Rear Brake rod locking device insecure |3.5.1l| | 1 |
| Offside Front Statutory seat belt missing |5.1.1| | 1 |
| Outline marker lamp not working Four |4.2.1 |a|| | 1 |
| Parking brake lever is not capable of being maintained in operation by direct mechanical action only (1.1.6 (f)) | 1 |
| Offside Front Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced step (6.1.1 (c) (i)) | 1 |
| Nearside Lower Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner body/ sill (6.1.1 (c) (i)) | 1 |
| Offside Front Upper Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner body panel (6.1.1 (c) (i)) | 1 |
| Nearside Front Cab mounting fixings insecure such that stability is seriously impaired (6.2.2 (c) (ii)) | 1 |
| Offside Front Cab mounting fixings insecure such that stability is seriously impaired (6.2.2 (c) (ii)) | 1 |
| Nearside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced under bonnet (6.1.1 (c) (i)) | 1 |
| Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced under bonnet (6.1.1 (c) (i)) | 1 |
| Nearside Front Lower Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced step (6.1.1 (c) (i)) | 1 |
| Offside Front Lower Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced step (6.1.1 (c) (i)) | 1 |
| Offside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering (6.1.1 (c) (ii)) | 1 |
| Nearside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering (6.1.1 (c) (ii)) | 1 |
| Nearside Rear Upper Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced wheel arch (6.1.1 (c) (i)) | 1 |
| Offside Rear Leaf spring to axle fixing bolt insecure (5.3.1 (a) (i)) | 1 |
| Nearside Front Vehicle structure has a fracture which is likely to adversely affect braking or steering (6.1.1 (a) (ii)) | 1 |
| Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 1 |