| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 26 |
| Windscreen wiper does not clear the windscreen effectively | 19 |
| Registration plate lamp issues | 11 |
| Headlamp aim out of alignment | 8 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 6 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 5 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 5 |
| Parking brake: efficiency below requirements |3.7.B.7| | 5 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 4 |
| Brake hose excessively deteriorated | 4 |
| Rear parking brake recording little or no effort | 4 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 3 |
| Horn not working (7.7 (a) (ii)) | 3 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 3 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced at corner of cab (7.1.1 (a) (i)) | 2 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced at corner of cab (7.1.1 (a) (i)) | 2 |
| Offside Rear Suspension component mounting prescribed area is inadequately repaired chassis (5.3.6 (a) (i)) | 2 |
| Power steering inoperative (2.1.5 (c) (i)) | 2 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced outrigger |7.1.1 |a| |i|| | 2 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 2 |
| Brakes imbalanced across an axle | 2 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 2 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Hazard warning switch inoperative (4.4.2 (a) (ii)) | 2 |
| Offside Front front brake binding |3.7.B.1| | 2 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt n/s/f track rod ball joint cover split |2.1.3 |g| |ii|| | 1 |
| Nearside Upper Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Upper Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Front Service brake imbalanced across an axle (1.2.1 (b) (i)) | 1 |
| Offside Axle king pin is loose in the axle beam Has excessive lift (5.1.2 (d) (i)) | 1 |
| Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Front Headlamp aim not tested (4.1.2 (b)) | 1 |
| Outline marker lamp does not illuminate simultaneously with the position lamps both sides (4.2.2 (a)) | 1 |
| Offside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced sill (6.1.1 (c) (i)) | 1 |
| Rear Floor excessively deteriorated rear floor (6.2.4 (a) (i)) | 1 |
| Offside Front Floor excessively deteriorated inner support mount (6.2.4 (a) (i)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Nearside Rear Inner Seat belt anchorage prescribed area strength or continuity significantly reduced wheel arch |7.1.1 |a| |i|| | 1 |
| Nearside Front Inner Seat belt anchorage prescribed area strength or continuity significantly reduced wheel arch 2 places |7.1.1 |a| |i|| | 1 |
| Fuel tank insecure strap |6.1.3 |a| |i|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Offside Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
| Main beam tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Other passenger door cannot be opened from outside the vehicle side door (6.2.3 (a)) | 1 |
| Floor excessively deteriorated Floor coming away on rear both sides (6.2.4 (a) (i)) | 1 |
| Offside Rear Body mounting fixings insecure such that stability is seriously impaired rust holes around body mount (6.2.2 (c) (ii)) | 1 |
| Nearside Rear Integral body structure has excessive corrosion which adversely affects braking or steering Around under side of wheel arch (6.1.1 (c) (ii)) | 1 |
| Offside Rear Integral body structure has excessive corrosion which adversely affects braking or steering around under side of wheel arch. (6.1.1 (c) (ii)) | 1 |
| Parking brake mechanism/associated mounting prescribed area is excessively corroded and functionality of the braking system is affected cross member hand brake mounting (1.1.21 (e) (ii)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength near hanger (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength rear hanger (5.3.6 (a) (i)) | 1 |
| Suspension component mounting prescribed area excessively corroded significantly reducing structural strength rear cross member near hanger front (5.3.6 (a) (i)) | 1 |
| Offside Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill hole near seat belt / seat fixing (5.3.6 (a) (i)) | 1 |
| Central Seat belt anchorage likely to become detached in the event of a collision splits in floor rust holes in floor close to seat fixings (7.1.1 (a) (ii)) | 1 |
| Position lamp not working at rear |4.2.1 |a|| | 1 |
| Stop lamp|s| all not working |4.3.1 |a| |iii|| | 1 |
| Suspension component mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected middle to rear crossmember |5.3.6 |a| |ii|| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Offside Front Outline marker lamp does not illuminate simultaneously with the position lamps (4.2.2 (a)) | 1 |
| Offside Front Lower Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting step under side (6.2.2 (d) (i)) | 1 |
| Nearside Rear Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Offside Rear Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Offside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner wheel arch (6.1.1 (c) (i)) | 1 |
| Nearside Front Anti-roll bar pin or bush excessively worn x2 (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar pin or bush excessively worn x2 (5.3.4 (a) (i)) | 1 |
| Exhaust diesel particulate filter shows evidence of tampering. no dpf or exhaust box visible but sensors cable tied up (8.2.2.1 (c)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor (5.3.6 (a) (i)) | 1 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor (5.3.6 (a) (i)) | 1 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Front Passenger`s seat insecure Captain seat does not lock into forward position. |6.2.6 |a| |ii|| | 1 |
| Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 1 |
| Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |1.1.21 |e| |i|| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Rear brake application uneven | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
| Offside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Horn not working |1.6.2a| | 1 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 1 |
| Nearside Outer Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Front Anti-roll bar rubber bush deteriorated resulting in excessive movement nearside and offside 4 bushes |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement d link bush |2.4.G.2| | 1 |
| Brake linkage has restricted free movement |1.1.15 |e|| | 1 |
| Steering rack has excessive free play detected at the steering wheel |steering rack fitted| |2.3 |a| |i|| | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced inner wheelarch |7.1.1 |a| |i|| | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced inner sill |7.1.1 |a| |i|| | 1 |
| Central Front Seat belt anchorage prescribed area strength or continuity significantly reduced floor behind gearbox |7.1.1 |a| |i|| | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced behind wheels |7.1.1 |a| |i|| | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced behind wheels |7.1.1 |a| |i|| | 1 |
| Offside Headlamp levelling device inoperative |4.1.5 |a|| | 1 |
| Emergency exit door cannot be opened from inside the vehicle |9.1.2 |a|| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded 2 places |5.2.6| | 1 |
| Offside Rear Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength spring front mounting (5.3.6 (a) (i)) | 1 |
| Nearside Rear Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting both sides of shocker mount (6.2.2 (d) (i)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Exhaust emissions exceed level of metered smoke for a turbo charged engine (8.2.2.2 (b)) | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Nearside Rear Shock absorbers likely to become detached lower nut loose (5.3.2 (a) (ii)) | 1 |
| Offside Rear Shock absorbers likely to become detached lower nut loose (5.3.2 (a) (ii)) | 1 |
| Nearside Rear Position lamp likely to become detached (4.2.1 (c) (ii)) | 1 |
| Nearside Front Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Rear Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Lower Position lamp not working |4.2.1 |a|| | 1 |
| Brake warning device not identifying low pressure |1.1.4 |a| |ii|| | 1 |
| Exhaust emissions test aborted because smoke levels are significantly in excess of the specified limit values |8.2.2.2 |f|| | 1 |
| Offside Rear Position lamp lens seriously defective (4.2.1 (b)) | 1 |
| Fuel tank insecure front strap snapped (6.1.3 (a) (i)) | 1 |
| Offside Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting step (6.2.2 (d) (i)) | 1 |
| Nearside Rear Anti-roll bar linkage pin or bush likely to become detached (5.3.4 (a) (ii)) | 1 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Front Horn not working |1.6.2a| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Upper Rear position lamp|s| adversely affected by the operation of another lamp not working side lights |1.1.A.3f| | 1 |
| Offside Rear Upper Rear position lamp|s| not working side lights out |1.1.A.3b| | 1 |
| Nearside Rear Lower Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Lower Anti-roll bar rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Rear Lower Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Offside Rear Lower Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Emergency exit window ???break glass` hammer missing missing |6.2.D.2| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Brake performance not tested |1.2.1 |g|| | 1 |
| Offside Front Brake pipe leaking on a hydraulic braking system |1.1.11 |b| |ii|| | 1 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |
| Brake pressure/vacuum build up too slow (1.1.3 (b)) | 1 |
| Brake performance unable to be tested (1.2.1 (g)) | 1 |
| Nearside Obligatory mirror insecure (3.3 (b) (ii)) | 1 |
| Brake operation has insufficient reserve pressure/vacuum to provide assistance for at least four more brake applications after the warning device has operated (or gauge shows an unsafe reading) (1.1.3 (a) (i)) | 1 |
| Offside Rear Upper Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp light source and lamp not compatible (4.1.4 (c)) | 1 |
| Exhaust emissions exceed manufacturers specified limit (8.2.2.2 (a)) | 1 |
| Nearside Headlamp light source and lamp not compatible (4.1.4 (c)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front Seat belt anchorage prescribed area is inadequately repaired OUT RIGGER REPAIRED WITH ALUMINIUM AND POP RIVERTS (7.1.1 (a) (i)) | 1 |
| Nearside Retractable step not operating correctly |6.1.E.2| | 1 |
| Emergency exit sign missing both |6.2.D.3| | 1 |
| Nearside Front Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Offside Front Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Offside Rear Wheel bearing play so excessive it is likely to break up (5.1.3 (a) (ii)) | 1 |
| Offside Front Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Upper Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear reflector missing (4.8.2 (a) (ii)) | 1 |
| Offside Rear reflector missing (4.8.2 (a) (ii)) | 1 |
| Front Braking system leaking (1.1.3 (d)) | 1 |
| Nearside Front Windscreen wiper not working (3.4 (a)) | 1 |
| Nearside Front Suspension component mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected |5.3.6 |a| |ii|| | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced |7.1.1 |a| |i|| | 1 |
| Offside Rear Position lamp not working |4.2.1 |a|| | 1 |
| All direction indicators not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Inner Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
| Offside Rear Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Bonnet primary retaining device ineffective (3.1 (c)) | 1 |
| Offside Rear Position lamp has a product on the lens or light source which shows white light to the rear |4.2.3 |b| |ii|| | 1 |
| Offside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength inner wheel arch. |5.3.6 |a| |i|| | 1 |
| Nearside Front Road wheel more than one fixing loose |5.2.1 |a| |ii|| | 1 |
| Oil leaking continuously from engine posing a serious risk to road safety |8.4.1 |a| |ii|| | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Rear Upper Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Horn not working (7.7 (a)) | 1 |
| Rear Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Offside Rear fog lamp adversely affected by the operation of another lamp (4.5.4 (b)) | 1 |
| Nearside Front Brake hose excessively twisted (1.1.12 (b) (ii)) | 1 |
| Nearside Front Suspension rod ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Suspension rod ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Lower Steering linkage ball joint ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Upper Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Nearside Front Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced arch (6.1.1 (c) (i)) | 1 |
| Offside Front Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced arch (6.1.1 (c) (i)) | 1 |
| Seat belt not functioning as intended N/S/F does not retract/ work correctly (7.1.2 (c)) | 1 |
| Nearside Rear Anti-roll bar linkage fractured (5.3.3 (b) (ii)) | 1 |
| Nearside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Offside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Nearside Rear Leaf spring shackle pin or bush excessively worn rear (5.3.4 (a) (i)) | 1 |
| Offside Rear Leaf spring shackle pin or bush excessively worn rear (5.3.4 (a) (i)) | 1 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Battery insecure |1.9.1| | 1 |
| Offside Front Service brake excessively binding |1.2.1 |f|| | 1 |
| Fuel cap/sealing device ineffective (6.1.3 (b) (i)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Offside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Rear Brake pipe leaking marked yellow |3.6.A.1| | 1 |
| Drivers seat fore and aft adjustment mechanism not functioning as intended. (6.2.5 (b) (i)) | 1 |
| Nearside Seat belt buckle not functioning as intended (7.1.2 (d)) | 1 |
| Offside Seat belt buckle not functioning as intended (7.1.2 (d)) | 1 |
| Offside Rear Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
| Nearside Front Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting SILL (6.2.2 (d) (i)) | 1 |
| Offside Rear Lower Anti-roll bar linkage pin or bush excessively worn bush (5.3.4 (a) (i)) | 1 |
| Central Prop shaft bearing excessively worn (6.1.7 (b) (i)) | 1 |
| Windscreen damaged and affecting the drivers view of the road (3.2 (a) (ii)) | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Body mounting fixings insecure such that stability is seriously impaired (6.2.2 (c) (ii)) | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting outer sill (6.2.2 (d) (i)) | 1 |
| Front Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Windscreen wiper blade missing (3.4 (b) (ii)) | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |