| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 7 |
| Brakes imbalanced across an axle | 7 |
| Brake pipe excessively corroded | 6 |
| Windscreen wiper does not clear the windscreen effectively | 6 |
| Exhaust system not adequately supported |7.1.1| | 4 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 3 |
| Brake hose excessively deteriorated | 3 |
| Rear parking brake recording little or no effort | 3 |
| Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 3 |
| Battery insecure |1.9.1| | 3 |
| Nearside Front Side repeater not working |1.4.A.2c| | 3 |
| Service brake: efficiency below requirements |3.7.C.1a| | 2 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Side repeater not working |1.4.A.2c| | 2 |
| Brake servo vacuum pipe collapsed |3.6.C.1b| | 2 |
| Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside front brake recording little or no effort |3.7.B.5a| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Offside Rear Body has a sharp edge caused by damage |6.1.C.1| | 2 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 2 |
| Offside Obligatory mirror insecure |8.1.1| | 2 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 2 |
| Rear Mechanical brake component has restricted free movement | 2 |
| Nearside Front Statutory seat belt missing |5.1.1| | 2 |
| Headlamp aim out of alignment | 2 |
| Nearside Front Brake pipe leaking |3.6.A.1| | 1 |
| Offside Front Torque/reaction arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Rear fog lamp switch inoperative doesn`t illuminate |4.5.3 |a| |ii|| | 1 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Central Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Offside Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Brake pedal anti-slip provision worn smooth /torn |1.1.2 |c|| | 1 |
| Floor excessively deteriorated corroded drivers seat prescribed area |6.2.4 |a| |i|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Tie bar/rod ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Tie bar/rod ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Anti-roll bar attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| Offside Rear Anti-roll bar attachment bracket/mounting fractured |2.4.G.1| | 1 |
| Offside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Offside Rear Bonded suspension unit deteriorated and cannot function as intended |2.4.F.3| | 1 |
| Nearside Rear Bonded suspension unit deteriorated and cannot function as intended |2.4.F.3| | 1 |
| Bonnet cannot be secured in the closed position (3.1 (b) (i)) | 1 |
| Nearside Front Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Arch corroded marked yellow (6.1.1 (c) (i)) | 1 |
| Offside Front Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Arch corroded marked yellow (6.1.1 (c) (i)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Rear Service brake effort inadequate at a wheel BOTH SIDES (1.2.1 (a) (i)) | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Battery insecure |1.9.1| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Side repeater insecure |1.4.A.2b| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Battery insecure |1.9.1| | 1 |
| Nearside Headlamp does not operate immediately when selected on main beam |1.7.4a| | 1 |
| Nearside Headlamp does not operate immediately when selected on dipped beam |1.7.4a| | 1 |
| Offside Rear passenger door does not latch securely closed |6.2.B.1a| | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Fuel cap/sealing device missing |7.2.4a| | 1 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Nearside Front Brake hose twisted |3.6.B.4c| | 1 |
| Rear brake application uneven | 1 |
| Offside Rear Leaf spring cracked |2.4.B.1a| | 1 |
| Nearside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Offside Front Braking system leaking |3.6.A.1| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Offside front brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front Lower Radius arm has excessive play in a ball joint |2.4.G.3| | 1 |
| Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Offside Rear Rear fog lamp not in good working order |not working| |1.1.6b| | 1 |
| Offside Front Torsion bar insecure at an end fixing |2.4.E.2| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Offside Front Braking system leaking Brake pipe |3.6.A.1| | 1 |
| Offside Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Nearside Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Nearside Rear Anti-roll bar linkage corroded and seriously weakened |2.4.G.1| | 1 |
| Offside Rear Anti-roll bar linkage corroded and seriously weakened |2.4.G.1| | 1 |
| Rear brake binding | 1 |
| Access panel cannot be secured in the closed position |6.4.1| | 1 |
| Headlamp not working on main beam both |1.7.5a| | 1 |
| Nearside Passenger`s seat insecure |6.2.A.1| | 1 |
| Electrical wiring insecure ignition switch |1.9.2a| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Side repeater missing |1.4.A.2b| | 1 |
| Offside Side repeater missing |1.4.A.2b| | 1 |
| Offside Fuel tank insecure |7.2.1| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Passenger`s seat insecure |6.2.A.1| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Battery insecure and likely to fall from carrier |4.13 |a| |ii|| | 1 |
| Offside Front Bumper insecure |6.1.4 |a| |i|| | 1 |
| Offside Front Body component insecure trim insecure |6.2.1 |a| |i|| | 1 |
| Offside Rear Body component insecure body trim |6.2.1 |a| |i|| | 1 |
| Offside Rear Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Rear Drag link end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Front Drag link end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Steering column fractured and unserviceable |2.2.C.1d| | 1 |
| Front brake application uneven | 1 |
| Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear position lamp|s| insecure |1.1.A.3a| | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Rear position lamp|s| insecure |1.1.A.3a| | 1 |
| Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Centre Front Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Nearside Rear Upper Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Steering system excessively tight |2.2.D.1| | 1 |
| Exhaust has a major leak of exhaust gases tail pipe missing |7.1.2| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded step at |5.2.6| | 1 |
| Front Fuel tank insecure strap inedequate |7.2.1| | 1 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded inner sill at |2.4.A.3| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded inner sill at |2.4.A.3| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded step at |5.2.6| | 1 |
| Offside Front Body insecure and dangerous to other road users inner wing gaurd |6.1.B.1b| | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Offside Air/vacuum reservoir insecurely mounted |3.6.A.2a| | 1 |
| Nearside Rear Upper Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Front Service brake has no recorded effort at a wheel both sides |1.2.1 |a| |ii|| | 1 |
| Front Steering linkage ball joint ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt all both sides |2.1.3 |g| |ii|| | 1 |
| Service brake efficiency less than 50% of the required value |1.2.2 |a| |ii|| | 1 |
| Offside Front Statutory seat belt missing |5.1.1| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Braking system leaking |3.6.A.1| | 1 |
| Brake load sensing valve seized and ABS not fitted or inoperative (1.1.17 (c) (ii)) | 1 |