| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 64 |
| Brake pipe excessively corroded | 52 |
| Registration plate lamp issues | 51 |
| Parking brake: efficiency below requirements |3.7.B.7| | 39 |
| Windscreen wiper does not clear the windscreen effectively | 35 |
| Brakes imbalanced across an axle | 16 |
| Rear parking brake recording little or no effort | 15 |
| Service brake: efficiency below requirements |3.7.B.7| | 11 |
| Rear brake binding | 11 |
| Anti-lock braking system warning lamp indicates an ABS fault | 11 |
| Battery insecure |1.9.1| | 10 |
| Nearside Stop lamp not working |1.2.1b| | 8 |
| Parking brake lever has no reserve travel |3.1.6b| | 7 |
| Registration plate issues | 7 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 7 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 6 |
| Brake hose excessively deteriorated | 6 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 6 |
| Offside Stop lamp not working |1.2.1b| | 6 |
| Front brake application uneven | 6 |
| Offside Rear fog lamp not working |1.3.2b| | 6 |
| Transmission brake efficiency below requirements |3.8.A.9/10| | 4 |
| Nearside front brake binding |3.7.B.1| | 4 |
| Rear Emergency exit door cannot be opened from inside the vehicle |6.2.D.1a| | 4 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 4 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 3 |
| Fuel tank insecure |7.2.1| | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 3 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 3 |
| Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 3 |
| Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 3 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 3 |
| Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 3 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 3 |
| Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 3 |
| Offside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 3 |
| Nearside Side repeater not working |1.4.A.2c| | 3 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 3 |
| Exhaust system not adequately supported |7.1.1| | 3 |
| Brake pedal spongy |3.3.B.1b| | 3 |
| Nearside Headlamp not working on main beam |1.7.5a| | 3 |
| Rear fog lamp not working |1.3.2b| | 2 |
| Centre Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 2 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Nearside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 2 |
| Nearside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced inner sill |7.1.1 |a| |i|| | 2 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 2 |
| Offside Side repeater not working |4.4.1 |a| |ii|| | 2 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Nearside Front Suspension rod ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Offside Front Suspension rod ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Brake performance unable to be tested (1.2.1 (g)) | 2 |
| Windscreen has damage | 2 |
| Nearside Rear Stop lamp not working |1.2.1b| | 2 |
| Exhaust has a major leak of exhaust gases tail pipe |7.1.2| | 2 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 2 |
| Windscreen washer not working | 2 |
| Offside Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 2 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Headlamp switch faulty |1.7.1| | 2 |
| Offside Outer Rear Seat belt locking mechanism does not secure or release |5.1.B.6a| | 2 |
| Nearside Body has sharp edges or projections caused by corrosion or damage making the vehicle dangerous to other road users |6.5.10| | 2 |
| Emissions not tested |7.0| | 2 |
| Offside Side repeater not working |1.4.A.2c| | 2 |
| rear parking |secondary| brakes imbalanced | 2 |
| Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Brake pedal has insufficient reserve movement |3.3.A.5| | 2 |
| Front Shock absorber has an excessively worn bush |2.7.4| | 2 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 2 |
| Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 2 |
| Rear Emergency exit door cannot be opened from outside the vehicle |6.2.D.1a| | 2 |
| Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 2 |
| Nearside Rear position lamp|s| incorrect colour |1.1.A.3e| | 2 |
| Offside Headlamp not working on main beam |1.7.5a| | 2 |
| Offside front brake binding |3.7.B.1| | 2 |
| Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 2 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 2 |
| Rear Mechanical brake component has restricted free movement | 2 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Rear Rear outline marker lamp|s| not working |1.1.B.1c| | 1 |
| Offside Rear outline marker lamp|s| not working |1.1.B.1c| | 1 |
| Nearside Rear Emergency exit door does not latch securely closed |6.2.D.1b| | 1 |
| Offside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Rear engine mounting bracket insecure and likely to fail |6.1.D.1b| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Offside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Parking brake lever releases when knocked |3.1.6a| | 1 |
| Offside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Nearside Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Rear fog lamp excessively deteriorated so that it is not visible from a reasonable distance |1.3.2d| | 1 |
| Nearside Front Upper Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Brake warning device not working correctly |3.3.D.3a| | 1 |
| Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Brake cable has restricted free movement |3.5.1k| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Seat belt retracting mechanism defective (7.1.2 (e)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Seat belt not functioning as intended Drivers Belt (7.1.2 (c)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Inner Wing Rotten (5.3.6 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Inner Wing Rotten (5.3.6 (a) (i)) | 1 |
| Nearside Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Inner Sill Rotten (6.1.1 (c) (i)) | 1 |
| Offside Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Inner Sill Rotten (6.1.1 (c) (i)) | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.3| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.3| | 1 |
| Nearside Rear Braking system leaking |3.6.A.1| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front All position lamps adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Front All position lamps not working |1.1.A.3b| | 1 |
| Offside Front Direction indicators missing |1.4.A.2b| | 1 |
| Nearside Rear Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Nearside Front Obligatory mirror seriously deteriorated, affecting the rear view |8.1.2a| | 1 |
| Nearside Rear passenger door does not latch securely closed |6.2.B.1a| | 1 |
| Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Offside Rear wheel cylinder leaking |3.6.A.1| | 1 |
| Offside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Seat belt buckle not functioning as intended (7.1.2 (d)) | 1 |
| Offside Rear Position lamp showing white light to the rear (4.2.3 (a) (ii)) | 1 |
| Offside Rear Stop lamp(s) showing white light to the rear (4.3.3 (a) (ii)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Offside Front Shock absorbers insecurely attached (5.3.2 (a) (i)) | 1 |
| Offside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear Direction indicator incorrect colour |4.4.3 |a|| | 1 |
| Offside Rear Direction indicator incorrect colour |4.4.3 |a|| | 1 |
| Nearside Front Body component damaged and likely to cause injury indicator lens |6.2.1 |a| |i|| | 1 |
| Offside Rear Brake cable damaged |1.1.15 |a|| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill |5.3.6 |a| |i|| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill |5.3.6 |a| |i|| | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced inner sill |7.1.1 |a| |i|| | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 1 |
| Offside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Centre Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Central Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect Bulb retaining clip missing. |1.8.A.1b| | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Nearside Front Body component insecure Horn not secured |6.2.1 |a| |i|| | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Rear reflector likely to become detached (4.8.1 (b) (ii)) | 1 |
| Offside Front Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Nearside Front Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Nearside Front Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Rear Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Brake fluid significantly below minimum mark (1.1.10 (d) (ii)) | 1 |
| Parking brake lever ratchet not holding correctly (1.1.6 (a)) | 1 |
| Nearside Rear Seat belt buckle missing (7.1.2 (d)) | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Prop shaft bearing excessively worn ball bearings fallen out (6.1.7 (b) (i)) | 1 |
| Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced corrosion on inner sill below seat anchorage points (7.1.1 (a) (i)) | 1 |
| Nearside Front Front passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength rear (5.3.6 (a) (i)) | 1 |
| Nearside Suspension component mounting prescribed area excessively corroded significantly reducing structural strength center (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength rear (5.3.6 (a) (i)) | 1 |
| Windscreen damaged and affecting the driver`s view of the road |3.2 |a| |ii|| | 1 |
| Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Both centre outriggers to inner sills |6.1.1 |c| |i|| | 1 |
| Offside Upper Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Rear Lower Direction indicator incorrect colour |1.5.1d| | 1 |
| Nearside Front Lower Direction indicator not in good working order |not working| |1.5.1b| | 1 |
| Offside Rear Leaf spring shackle bracket nut missing U-BOLT |2.4.B.6c| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Exhaust has a major leak of exhaust gases fracture |7.1.2| | 1 |
| Offside Rear Leaf spring fractured |2.4.B.1a| | 1 |
| Nearside Front Front wheel bearing rough when rotated (2.5.A.2) | 1 |
| Offside Rear Rear wheel bearing has excessive play (2.6.2) | 1 |
| Hazard warning switch insecure |1.4.B.1d| | 1 |
| Offside Obligatory mirror insecure |8.1.1| | 1 |
| Front passenger door does not latch securely closed |6.2.B.1a| | 1 |
| Offside Rear Seat belt retracting mechanism defective |5.1.B.6b| | 1 |
| Nearside Rear Seat belt retracting mechanism defective |5.1.B.6b| | 1 |
| Headlamp not working on dipped beam both |1.7.5a| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded bulkhead holed |3.6.C.3| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Front Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Parking brake lever ratchet mechanism is excessively worn |3.1.5| | 1 |
| Rear Loading door cannot be secured in the closed position |6.4.1| | 1 |
| Nearside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Exhaust catalytic converter missing where one was fitted as standard |7.1.3| | 1 |
| Nearside Front outline marker lamp|s| not working |1.1.B.1c| | 1 |
| Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Seat belt locking mechanism does not secure or release 3rd row isle seat |5.2.5a| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| All position lamps not in good working order |not working| |1.1.4a| | 1 |
| Nearside Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Obligatory mirror seriously damaged, affecting the rear view (3.3 (b) (ii)) | 1 |
| Offside Front Lower Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wheel arch (5.3.6 (a) (i)) | 1 |
| Offside Front Upper Suspension component mounting prescribed area excessively damaged significantly reducing structural strength under bonnet front (5.3.6 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively damaged significantly reducing structural strength rear arch (5.3.6 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area is inadequately repaired front bulkhead (5.3.6 (a) (i)) | 1 |
| Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Offside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Nearside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Nearside Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Nearside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Nearside Rear Inner Body insecure to the extent that stability is seriously impaired (6.2.2 (a) (ii)) | 1 |
| Offside Rear Inner Body insecure to the extent that stability is seriously impaired (6.2.2 (a) (ii)) | 1 |
| Offside Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Leaf spring to axle securing bolt insecure |2.4.B.7b| | 1 |
| Offside Headlamp not in good working order affecting the beam image |1.2.4a| | 1 |
| Nearside Front Tie bar/rod ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Tie bar/rod ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Rear Seat belt locking mechanism does not secure or release 3rd row outer |5.2.5a| | 1 |
| Nearside Front Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt foremost |2.4.G.2| | 1 |
| Offside Front Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt foremost |2.4.G.2| | 1 |
| Body has a sharp edge caused by corrosion bonnet |6.1.C.1| | 1 |
| Nearside Front Entrance/exit step significantly damaged side step under support corroded away |9.7 |a| |ii|| | 1 |
| Nearside Rear Leaf spring shackle pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Passenger`s seat insecure 5th row |6.2.A.1| | 1 |
| Rear Exhaust has a major leak of exhaust gases silencer (6.1.2 (a)) | 1 |
| Offside Rear Upper Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Offside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Inner Rear Seat belt locking mechanism does not secure or release |5.1.B.6a| | 1 |
| Offside Front Seat belt locking mechanism does not secure or release |5.1.B.6a| | 1 |
| Offside Inner Rear Valve stem seriously damaged |4.1.C.1e| | 1 |
| Nearside All outline marker lamps not working centre |1.1.B.1c| | 1 |
| Centre Seat belt retracting mechanism defective 5th row |5.2.5b| | 1 |
| Nearside Headlamp not working on main beam |1.2.4a| | 1 |
| Offside Headlamp not working on main beam |1.2.4a| | 1 |
| Rear Exhaust has a major leak of exhaust gases |6.3.2a| | 1 |
| Offside Front Body has excessive displacement which may lead to loss of vehicle control |6.5.8a| | 1 |
| Nearside Stop lamp not working |1.3.2a| | 1 |
| Offside Inner Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Outer Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Exhaust fumes entering the driver`s area |7.1.5| | 1 |
| Nearside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Speed limiter plate not clearly and indelibly marked with the set speed sticker missing |6.5.A.2a| | 1 |
| Offside Rear Passenger`s seat insecure |6.2.A.1| | 1 |
| Offside Outer Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Offside Rear fog lamp not in good working order |not working| |1.1.6b| | 1 |
| Offside Rear Leaf spring to axle securing bolt insecure |2.4.B.7b| | 1 |
| Offside Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Offside Rear Leaf spring saddle is moving relative to the spring |2.4.B.7a| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Brake pipe leaking |3.6.A.1| | 1 |
| Nearside Front Tie bar/rod ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Tie bar/rod ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Seat belt missing (7.1.2 (a)) | 1 |
| Offside Front Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Offside Front Speedometer clearly inoperative (7.8 (b) (ii)) | 1 |
| Fuel system component leaking |6.7.1a| | 1 |
| Offside Rear brake caliper securing device loose |3.5.1j| | 1 |
| Nearside Front suspension has a suspension upper ball joint securing nut not locked |2.5.B.1a| | 1 |
| Offside Front suspension has a suspension upper ball joint securing nut not locked |2.5.B.1a| | 1 |
| Nearside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Front Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Offside Rear Position lamp showing white light to the rear |4.2.3 |a| |ii|| | 1 |
| Nearside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced |6.1.1 |c| |i|| | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced |6.1.1 |c| |i|| | 1 |
| Nearside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced inner sill slight corroded |6.1.1 |c| |i|| | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced inner sill corroded |6.1.1 |c| |i|| | 1 |
| Rear Brake valve leaking |3.6.A.1| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Nearside All position lamps not working |1.1.A.3b| | 1 |
| Fuel pipe leaking |7.2.3| | 1 |
| Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside All outline marker lamps not working |1.1.B.1c| | 1 |
| Offside All outline marker lamps not working |1.1.B.1c| | 1 |
| Nearside Rear Leaf spring splayed and action impaired |2.4.B.1c| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Steering locking device missing |2.2.C.1g| | 1 |
| Offside Front Cab or chassis has excessive corrosion to the extent that overall security or stability of the cab is impaired (6.2.2 (d) (ii)) | 1 |
| Offside Rear Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting cab chassis rail o/s/r (6.2.2 (d) (i)) | 1 |
| Nearside Rear Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting cab chassis rail n/s/r (6.2.2 (d) (i)) | 1 |
| Offside Front Upper Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting cab chassis rail (6.2.2 (d) (i)) | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Stop lamp not in good working order |function impaired| |1.3.2b| | 1 |
| Offside Outer Seat belt retracting mechanism defective |5.1.B.6b| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |6.3.1a| | 1 |
| Offside Rear Seat belt retracting mechanism defective last row |5.2.5b| | 1 |
| Offside Rear Seat belt retracting mechanism defective 3rd row from rear |5.2.5b| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded floor in places |5.2.6| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded arch in places |5.2.6| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded floor in places |5.2.6| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded chassis-box section in places |5.2.6| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded inner sill/box section |5.2.6| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded front of wheelarch |5.2.6| | 1 |
| Nearside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Speed limiter plate missing |6.5.A.1a| | 1 |
| Speed limiter tamperproof device showing evidence of obvious disturbance. |6.5.B.4| | 1 |
| Offside Brake master cylinder/servo mounting prescribed area is excessively corroded bulkhead |3.6.C.3| | 1 |
| Nearside Front Sub-frame insecure and impairing directional stability |5.3.3 |a| |ii|| | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting outer sill (6.2.2 (d) (i)) | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Brake pipe at imminent risk of failure or fracture front to rear (1.1.11 (a)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
| Offside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Chassis rail next to inner wing (6.1.1 (c) (i)) | 1 |
| Nearside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Chassis rail under battery box (6.1.1 (c) (i)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Brake hydraulic reservoir fluid level significantly below minimum level (1.1.10 (d) (ii)) | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Rear Exhaust fumes entering cabin (6.1.2 (b) (i)) | 1 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Rear reflector missing |1.5.1a| | 1 |
| Offside Rear Outer Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Rear Seat belt flexible stalk damaged likely to lead to failure under load stalk missing |5.2.4a| | 1 |
| Central Exhaust has a major leak of exhaust gases between flexy and rear box |7.1.2| | 1 |
| Nearside Rear Stop lamp incomplete |1.3.2b| | 1 |
| Offside Rear Outline marker lamp not working |4.2.1 |a|| | 1 |
| Nearside Outline marker lamp not working All 3 units |4.2.1 |a|| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Passenger`s seat insecure |6.2.A.1| | 1 |
| Brake pipe excessively chafed |3.6.B.2c| | 1 |
| Nearside Electrical wiring inadequately supported marker lamps |1.9.2a| | 1 |
| Offside Electrical wiring inadequately supported marker lamps |1.9.2a| | 1 |
| Nearside Rear Body or chassis is cracked, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Body or chassis is cracked, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Steering system excessively tight |2.2.D.1| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded rear cab panel |5.2.6| | 1 |
| Nearside Stop lamp has less than 50% of the light sources illuminating |1.2.1b| | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Nearside Front Upper Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Anti-lock braking system warning lamp does not illuminate |3.4.1b| | 1 |
| Offside Front Torsion bar excessive play at an end fixing |2.4.E.2| | 1 |
| Position lamp switch does not operate in accordance with the requirements (4.2.2 (a)) | 1 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Offside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Battery insecure and likely to cause a short circuit |4.13 |a| |ii|| | 1 |
| Headlamp aim so that beam "kick up" is not visible on the screen Both sides |4.1.2 |a|| | 1 |
| Oil leaking excessively from engine |8.4.1 |a| |i|| | 1 |
| Offside Front Suspension rod ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Front Lower Suspension arm ball joint excessively worn Both sides |5.3.4 |a| |i|| | 1 |
| Nearside Front Upper Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Electrical wiring insecure and connectors likely to become disconnected Positive terminal on battery (4.11 (a) (ii)) | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced Base of the cab at the rear, excessively corroded and 30cm from seatbelt mounting (7.1.1 (a) (i)) | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced Base of cab at the rear, excessively corroded and 30cm from seat belt (7.1.1 (a) (i)) | 1 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
| Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt both sides front covers (5.3.4 (b) (ii)) | 1 |
| Offside Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Bonnet retaining device ineffective |8.4.2| | 1 |
| Offside Rear Seat belt locking mechanism does not secure or release rear row, nearest isle seat belt locking mechanism missing |5.2.5a| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Speed limiter plate missing missing from drivers compartment |6.5.A.1a| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.6| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.5.1d| | 1 |
| Offside Rear Direction indicator incorrect colour |1.5.1d| | 1 |
| Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.3| | 1 |
| Offside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.3| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Outer Seat belt webbing significantly weakened (7.1.2 (b) (ii)) | 1 |
| Nearside Direction indicator flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Front passenger door cannot be opened from inside the vehicle Handle not fixed |6.2.B.1b| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Inner Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Electrical wiring insecure |1.9.2a| | 1 |
| Rear brake application uneven | 1 |
| Nearside Rear Lower Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Lower Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Offside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Offside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Fuel tank insecure strap corroded |7.2.1| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Brake pipe leaking on a hydraulic braking system front to rear brake pipe (1.1.11 (b) (ii)) | 1 |
| Nearside Rear Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Rear Anti-roll bar linkage pin or bush excessively worn both outers |5.3.4 |a| |i|| | 1 |
| Offside Rear front brake grabbing severely |3.7.A.2b| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Centre Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Obligatory mirror insecure |8.1.1| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings out rigger holed in front of rear wheel |6.1.B.2| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings out rigger holed behind rear wheel |6.1.B.2| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings out rigger holed behind rear wheel |6.1.B.2| | 1 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill holed plus damaged |6.1.B.2| | 1 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Obligatory mirror insecure |8.1.1| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Front Horn not working |1.6.2a| | 1 |
| Nearside Front Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear Rear position lamp|s| missing |1.1.A.3a| | 1 |
| Nearside Front Vehicle structure has a fracture which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Rear Brake hose leaking |3.6.A.1| | 1 |
| Nearside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Brake lining|s| wear indicator illuminated |1.1.13 |a| |i|| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Inner Seat belt anchorage prescribed area strength or continuity significantly reduced sill |7.1.1 |a| |i|| | 1 |
| Nearside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength arch by body mount |5.3.6 |a| |i|| | 1 |
| Nearside Front Brake pipe leaking on a hydraulic braking system Chassis front to rear (1.1.11 (b) (ii)) | 1 |
| Brake pedal has insufficient reserve travel (1.1.2 (a)) | 1 |
| Central Front Seat belt retracting mechanism defective (7.1.2 (e)) | 1 |
| Brake performance unable to be tested Leaking brake pipe (1.2.1 (g)) | 1 |
| Nearside Front Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Fuel tank insecure Strap broken (6.1.3 (a) (i)) | 1 |
| Offside Rear Upper Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Chassis leg upper u section near cross member above axle (6.1.1 (c) (i)) | 1 |
| Nearside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Rear most tubular cross member (6.1.1 (c) (i)) | 1 |
| Offside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Rear most tubular cross member (6.1.1 (c) (i)) | 1 |
| Offside Front Statutory seat belt missing |5.1.1| | 1 |
| Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced floor/step/arch (7.1.1 (a) (i)) | 1 |
| Offside Front Inner Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting arch (6.2.2 (d) (i)) | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Front Front passenger door does not latch securely closed |6.2.B.1a| | 1 |
| Nearside Indicator switch faulty cowling obstructing operation |1.4.A.1| | 1 |
| Offside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength Front spring mount (5.3.6 (a) (i)) | 1 |
| Offside Front Lower Seat belt anchorage prescribed area strength or continuity significantly reduced Inner b post (7.1.1 (a) (i)) | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced Cab floor (7.1.1 (a) (i)) | 1 |
| Offside Front Inner Seat belt anchorage prescribed area strength or continuity significantly reduced Rear of arch (7.1.1 (a) (i)) | 1 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Offside Front Upper Brake master cylinder/servo mounting prescribed area is excessively corroded Inner arch (1.1.21 (e) (i)) | 1 |
| Nearside Front Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Inner upper arch front body mount (6.2.2 (d) (i)) | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear rear brake recording little or no effort no hand brake ceffort |3.7.B.5a| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Front Inner Seat belt anchorage prescribed area strength or continuity significantly reduced Sill (7.1.1 (a) (i)) | 1 |
| Offside Front Outer Seat belt anchorage prescribed area strength or continuity significantly reduced Sill (7.1.1 (a) (i)) | 1 |
| Spare wheel insecure |6.4.2| | 1 |
| Power steering pump drive system defective |2.3.6| | 1 |
| Power steering fluid level below minimum |2.3.1| | 1 |
| Offside Front Lower All outline marker lamps not working |1.1.B.1c| | 1 |
| Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Fuel pipe insecure |7.2.1| | 1 |
| Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
| Nearside Front Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
| Offside Front Upper Front suspension has excessive play in a track control arm inner bush |2.5.B.2b| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |