Most common failures | No# failures |
---|
Brake pipe excessively corroded | 26 |
Headlamp aim out of alignment | 20 |
Rear parking brake recording little or no effort | 16 |
Brakes imbalanced across an axle | 16 |
Parking brake: efficiency below requirements |3.7.B.7| | 16 |
Service brake: efficiency below requirements |3.7.B.7| | 13 |
Registration plate lamp issues | 13 |
Windscreen wiper does not clear the windscreen effectively | 12 |
Rear brake application uneven | 11 |
Brake hose excessively deteriorated | 8 |
Rear brake binding | 6 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 4 |
Parking brake lever has no reserve travel |3.1.6b| | 4 |
Offside Side repeater not working |1.4.A.2c| | 4 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 4 |
Offside rear brake recording little or no effort |3.7.B.5a| | 3 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
Nearside Front Direction indicator not working |1.4.A.2c| | 3 |
Offside Stop lamp not working |1.2.1b| | 3 |
Offside Rear fog lamp not working |1.3.2b| | 3 |
Fuel system component leaking |7.2.3| | 3 |
Exhaust system not adequately supported |7.1.1| | 3 |
Offside front brake binding |3.7.B.1| | 3 |
Front brake application uneven | 3 |
Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 3 |
Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 2 |
Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 2 |
Offside Front Brake pipe leaking |3.6.A.1| | 2 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
Offside Front brake disc excessively pitted |3.5.1h| | 2 |
Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
Nearside Stop lamp not working |1.2.1b| | 2 |
Hazard warning tell tale not working correctly |1.4.B.1e| | 2 |
Nearside Rear Anti-roll bar attachment bracket/mounting fractured |2.4.G.1| | 2 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
Steering rack insecure |2.2.B.1a| | 2 |
Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
Nearside Headlamp not working on main beam |1.7.5a| | 2 |
Horn not working |1.6.2a| | 2 |
Windscreen wiper not working (3.4 (a)) | 2 |
Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
Nearside Front Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings SILL |6.1.B.2| | 2 |
Nearside front brake binding |3.7.B.1| | 2 |
Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Nearside Side repeater not working |1.4.A.2c| | 2 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Headlamp levelling device inoperative |4.1.5 |a|| | 1 |
All position lamps not working |1.1.A.3b| | 1 |
Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
Nearside Upper Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Front Statutory seat belt missing |5.1.1| | 1 |
rear brakes release unevenly |3.7.B.4| | 1 |
Emissions not tested |7.0| | 1 |
Nearside Front Upper Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Side repeater not working |4.4.1 |a| |ii|| | 1 |
Nearside Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
Nearside Inner Front Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Outer Front Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Brake load sensing valve linkage seized |3.6.E.3| | 1 |
Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.3| | 1 |
Nearside Front Fuel hose leaking |6.7.1a| | 1 |
Brake performance not tested |3.8| | 1 |
Nearside Front Direction indicator not in good working order |not working| |1.5.1b| | 1 |
Nearside Front Anti-roll bar worn and seriously weakened |2.4.G.1| | 1 |
Offside Front Anti-roll bar worn and seriously weakened |2.4.G.1| | 1 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Nearside Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Direction indicator excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
Nearside Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
Windscreen has damage | 1 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Offside Rear position lamp|s| insecure |1.1.A.3a| | 1 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
Nearside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Offside Steering component fractured and unserviceable |2.2.C.1d| | 1 |
Offside Steering component is not secure to the vehicle structure |2.2.B.1a| | 1 |
Front position lamp|s| not working |1.1.A.3b| | 1 |
Centre Exhaust system not adequately supported |7.1.1| | 1 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
Nearside Front Side repeater not working |1.4.A.2c| | 1 |
Rear Exhaust has a part missing |7.1.1a| | 1 |
Offside Front Obligatory mirror seriously deteriorated, affecting the rear view |8.1.2a| | 1 |
Offside Rear Anti-roll bar attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
Rear Brake valve leaking |3.6.A.1| | 1 |
Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Rear Brake pipe leaking |3.6.A.1| | 1 |
Offside Front Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
Nearside Front Torsion bar excessive play at an end fixing |2.4.E.2| | 1 |
Offside Front Torsion bar excessive play at an end fixing |2.4.E.2| | 1 |
Exhaust mounting missing |7.1.1b| | 1 |
Front Front position lamp|s| not working Side lights |1.1.A.3b| | 1 |
Nearside Upper Stop lamp not working |1.2.1b| | 1 |
Offside Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
Offside Front Side repeater not working |1.4.A.2c| | 1 |
Stop lamp not working |1.2.1b| | 1 |
Nearside Headlamp not in good working order |not working| |1.2.4a| | 1 |
Centre Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Offside Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Windscreen washer not working | 1 |
Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced marked in yellow (6.1.1 (c) (i)) | 1 |
Front Suspension rod ball joint dust cover no longer prevents the ingress of dirt both sides marked in yellow (5.3.4 (b) (ii)) | 1 |
All direction indicators adversely affected by the operation of another lamp (4.4.3 (b)) | 1 |
Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Headlamp not working on main beam |1.7.5a| | 1 |
Nearside Obligatory mirror seriously deteriorated, affecting the rear view |8.1.2a| | 1 |
Nearside Front All position lamps not working |1.1.A.3b| | 1 |
Offside Front All position lamps not working |1.1.A.3b| | 1 |
Nearside Rear Lower All position lamps not working |1.1.A.3b| | 1 |
Nearside Rear Upper All position lamps not working |1.1.A.3b| | 1 |
Offside Rear Upper All position lamps not working |1.1.A.3b| | 1 |
Hazard warning lamps inoperative |1.4.B.1b| | 1 |
Nearside Rear Brake pedal does not operate a brake fitted to each wheel |3.3.A.3| | 1 |
Offside Rear Brake pedal does not operate a brake fitted to each wheel |3.3.A.3| | 1 |
Nearside Inner Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Inner Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
Nearside Rear position lamp|s| incomplete |1.1.4a| | 1 |
Fuel system component insecure |7.2.1| | 1 |
Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.4.B.1| | 1 |
Offside Front Outer Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings SILL |6.1.B.2| | 1 |
Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings PANEL |6.1.B.2| | 1 |
Offside Rear Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings SILL |6.1.B.2| | 1 |
Offside Front Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings SILL AND STEP |6.1.B.2| | 1 |
Nearside Rear Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings SILL |6.1.B.2| | 1 |
Offside Rear Leaf spring fractured |2.4.B.1a| | 1 |
Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
Front Seat belt installation does not use the standard seat belt mounting bolts and washers |5.3.1c| | 1 |
Offside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Steering column movement between the shaft and steering wheel |2.1.2b| | 1 |
Brake pipe inadequately supported |3.6.B.1| | 1 |
Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
Offside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Offside Rear Anti-roll bar attachment bracket/mounting fractured |2.4.G.1| | 1 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
Brake pedal spongy |3.3.B.1b| | 1 |
Nearside Rear Brake load sensing valve linkage seized |3.6.F.4| | 1 |
Offside Seat belt locking mechanism does not secure or release |5.1.B.6a| | 1 |
Hazard warning switch inoperative (4.4.2 (a) (ii)) | 1 |
Nearside Front Position lamp not working sidelight (4.2.1 (a) (ii)) | 1 |
Offside Front Position lamp not working sidelight (4.2.1 (a) (ii)) | 1 |
Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
Nearside Rear Service brake effort inadequate at a wheel |1.2.1 |a| |i|| | 1 |
Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
Offside Inner Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Inner Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings wheel arch |6.1.B.2| | 1 |
Nearside Inner Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill |6.1.B.2| | 1 |
Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings under step |6.1.B.2| | 1 |
Rear Inner Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sills |6.1.B.2| | 1 |
Nearside Front Inner Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings wheel arch |6.1.B.2| | 1 |
Offside Inner Rear position lamp|s| not working |1.1.A.3b| | 1 |
Mechanical brake component locking device insecure |3.5.1j| | 1 |
Driver`s door does not latch securely closed |6.5.11b| | 1 |
Offside Front Lower Front outline marker lamp|s| not working |1.1.B.1c| | 1 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Fuel system component leaking |7.2.3| | 1 |
Offside Obligatory mirror not clearly visible from the drivers seat or incapable of being adjusted to be clearly visible from the driver`s seat |6.6.1d| | 1 |
Steering component mounting prescribed area is fractured |2.2.C.1g| | 1 |
Nearside Rear Direction indicator incomplete |1.5.A1b| | 1 |
Nearside Rear rear brake grabbing severely |3.7.A.5b| | 1 |
Rear Exhaust system not adequately supported |7.1.1| | 1 |
Electrical wiring insecure |1.9.2a| | 1 |
Nearside Electrical wiring inadequately supported |1.9.2a| | 1 |
Offside Electrical wiring inadequately supported |1.9.2a| | 1 |
Offside Electrical wiring insecure |1.9.2a| | 1 |
Centre Rear Electrical wiring inadequately supported |1.9.2a| | 1 |
Nearside Rear Upper Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
Nearside Rear Upper Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Fuel pipe union leaking |7.2.3| | 1 |
Offside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Parking brake mechanism/associated mounting prescribed area is excessively corroded |3.1.9| | 1 |
Offside Rear fog lamp missing |1.3.2a| | 1 |
Offside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
Nearside Front Tie bar/rod attachment bracket/mounting bolt missing |2.4.G.1| | 1 |
Lower Steering system fouling |2.2.D.2a| | 1 |
Offside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
Nearside Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside Front Battery insecure |1.9.1| | 1 |
Nearside Outer Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Rear Anti-roll bar fractured |2.4.G.1| | 1 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Vehicle structure has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Brake pipe leaking |3.6.A.1| | 1 |
Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Rear Stop lamp not working |1.2.1b| | 1 |
Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Inner Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Nearside Rear Lower Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Rear Wheel nut|s| loose |4.2.A.1e| | 1 |
Offside Rear Leaf spring shackle pin excessively loose in its bracket |2.4.B.3a| | 1 |
Nearside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
Offside Front brake disc excessively scored |3.5.1h| | 1 |
Offside Front Direction indicator not working |1.4.A.2c| | 1 |
Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Nearside Outer Rear Anti-roll bar which is adjustable, locking device insecure |2.4.G.1| | 1 |
Offside Outer Rear Anti-roll bar which is adjustable, locking device insecure |2.4.G.1| | 1 |
Centre Front Body is excessively corroded seriously affecting its strength within 30cm of body mountings significantly reducing overall body security |6.5.9| | 1 |
Nearside Front Body is excessively corroded seriously affecting its strength within 30cm of body mountings significantly reducing overall body security |6.5.9| | 1 |
Offside Rear Body is excessively corroded seriously affecting its strength within 30cm of body mountings significantly reducing overall body security |6.5.9| | 1 |
Offside Body is excessively corroded seriously affecting its strength within 30cm of body mountings significantly reducing overall body security |6.5.9| | 1 |
Front Driving control|s| functionally incomplete |6.8.1a| | 1 |
Nearside Front Emergency exit door cannot be opened from inside the vehicle |6.2.D.1a| | 1 |
Nearside Front Emergency exit door cannot be opened from outside the vehicle |6.2.D.1a| | 1 |
Rear Emergency exit door cannot be opened from inside the vehicle |6.2.D.1a| | 1 |
Rear Emergency exit door cannot be opened from outside the vehicle |6.2.D.1a| | 1 |
Nearside Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Offside Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Battery insecure |1.9.1| | 1 |
Nearside Front Radius arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front Radius arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Rear wheel bearing has excessive play |2.6.2| | 1 |
Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
Rear Anti-roll bar linkage corroded and seriously weakened |2.4.G.1| | 1 |
Front Electrical wiring damaged and bare connector exposed |1.9.2c| | 1 |
Offside Steering rack gaiter split |2.2.D.2d| | 1 |
Brake performance not tested |3.7.A.1| | 1 |
Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
Brake load sensing valve linkage obviously incorrectly adjusted |3.6.F.4| | 1 |
Nearside Torque/reaction arm has excessive play in a pin/bush |2.4.G.3| | 1 |
Offside Torque/reaction arm has excessive play in a pin/bush |2.4.G.3| | 1 |
Nearside Front Upper Front suspension has excessive movement at a suspension ball joint |2.5.A.1c| | 1 |
Rear Rear fog lamp not working |1.3.2b| | 1 |
Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |