| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 20 |
| Registration plate lamp issues | 18 |
| Windscreen wiper does not clear the windscreen effectively | 18 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 13 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 8 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 7 |
| Nearside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 4 |
| Nearside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 4 |
| Offside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 4 |
| Parking brake lever has no reserve travel |3.1.6b| | 3 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Engine MIL inoperative or indicates a malfunction (8.2.2.2 (g)) | 3 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Brakes imbalanced across an axle | 2 |
| Offside Front Position lamp not working |4.2.1 |a|| | 2 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Offside Front position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 2 |
| Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 2 |
| Nearside Side repeater incorrect colour |1.4.A.2f| | 2 |
| Offside Side repeater incorrect colour |1.4.A.2f| | 2 |
| Battery insecure |1.9.1| | 2 |
| Rear brake disc in such a condition that it is seriously weakened | 2 |
| Position lamp not working both front (4.2.1 (a) (ii)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Nearside Front Position lamp not working side light (4.2.1 (a) (ii)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 1 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Battery insecure and likely to cause a short circuit loose and standing high (4.13 (a) (ii)) | 1 |
| passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Brake lever has insufficient reserve travel |1.1.2 |a|| | 1 |
| Front Windscreen wiper not working (3.4 (a)) | 1 |
| Offside Front Side repeater incorrect colour ** side repeater lens missing ** |1.4.A.2f| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Offside Front Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Nearside Rear Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Offside Rear Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Offside Rear Brake back plate|s| securing device loose |3.5.1j| | 1 |
| Nearside Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Central Rear Upper Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Fuel system component leaking excessively or a risk of fire fuel filter area (6.1.3 (b) (ii)) | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Supplementary Restraint System warning lamp indicates a fault air bag light goes out momentarily then comes back on |5.4.2| | 1 |
| Nearside Side repeater incorrect colour (4.4.3 (a)) | 1 |
| Exhaust emits an excessive level of metered smoke |7.4.B.3a| | 1 |
| Offside Side repeater incorrect colour (4.4.3 (a)) | 1 |
| Rear Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Offside Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Front brake excessively fluctuating | 1 |
| Offside Front Suspension component ball joint excessively worn lower ball joint (5.3.4 (a) (i)) | 1 |
| Offside Front Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Nearside Front Headlamp insecure (4.1.1 (c)) | 1 |
| Exhaust emissions likely to be affected by an exhaust leak |8.2.1.1 |b|| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Rear Road wheel fixing loose |5.2.1 |a| |i|| | 1 |
| Nearside Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Lower Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength Arm (5.3.6 (a) (i)) | 1 |
| Offside Rear Lower Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength Arm (5.3.6 (a) (i)) | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Rear Subframe mounting prescribed area excessively corroded significantly reducing structural strength suspension arm mounting area (5.3.6 (a) (i)) | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Front position lamp|s| not working both |1.1.A.3b| | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Emissions not tested Leak from intercooler unable to test (8.2.1.2 (d)) | 1 |
| Nearside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Rear Other passenger door cannot be opened from outside the vehicle |6.2.3 |a|| | 1 |
| Front Brake fluid contaminated (1.8 (a)) | 1 |
| Nearside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Offside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
| Exhaust emissions exceed default limit of 1.5m-1 |8.2.2.2 |b|| | 1 |
| Central Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Front Steering locking device missing (2.1.3 (d)) | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Access panel cannot be secured in the closed position |6.4.1| | 1 |