| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 11 |
| Registration plate lamp issues | 9 |
| Windscreen wiper does not clear the windscreen effectively | 9 |
| Headlamp aim out of alignment | 4 |
| Brakes imbalanced across an axle | 4 |
| Battery insecure |1.9.1| | 2 |
| Offside Rear wheel bearing rough when rotated |2.6.1| | 2 |
| Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Offside front brake binding |3.7.B.1| | 2 |
| Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Brake hose has insufficient room to move | 1 |
| Offside Sub-frame corroded and seriously weakened |2.4.G.1| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Brake master cylinder leaking hydraulic fluid |3.6.G.1f| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
| Front brake application uneven | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Offside Front Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Rear Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Offside Rear Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear passenger seat cannot be secured in the upright position. |6.2.3| | 1 |
| Offside Rear Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Front Headlamp has a product on the lens so that the light output is severely reduced |4.1.4 |b|| | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Nearside Front Headlamp has a product on the lens so that the light output is severely reduced |4.1.4 |b|| | 1 |
| Offside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill |5.3.6 |a| |i|| | 1 |
| Offside Front Sub-frame corroded and seriously weakened |5.3.3 |b| |i|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Nearside Front Body has a projection caused by damage |6.1.C.1| | 1 |
| Offside Front Body has a projection caused by damage |6.1.C.1| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Front Lower Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Emissions not tested |7.0| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Registration plate issues | 1 |
| Offside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |