| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 44 |
| Registration plate lamp issues | 28 |
| Windscreen wiper does not clear the windscreen effectively | 18 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 9 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 8 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 7 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 7 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 6 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 4 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 4 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 4 |
| Parking brake lever has no reserve travel |3.1.6b| | 4 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 4 |
| Registration plate issues | 4 |
| Anti-lock braking system warning lamp indicates an ABS fault | 4 |
| Battery insecure |1.9.1| | 4 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 4 |
| Nearside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 3 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 3 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
| Nearside Headlamp cleaning device inoperative |1.7.2| | 2 |
| Offside Headlamp cleaning device inoperative |1.7.2| | 2 |
| Offside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 2 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 2 |
| Rear parking brake recording little or no effort | 2 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Anti-lock braking system warning lamp does not illuminate |3.4.1b| | 2 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Rear Mechanical brake component has restricted free movement | 2 |
| Offside Front Anti-roll bar linkage damaged and seriously weakened |2.4.G.1| | 1 |
| Offside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Nearside Front All position lamps not working |1.1.A.3b| | 1 |
| Front All position lamps not working |1.1.A.3b| | 1 |
| Centre Rear Stop lamp not working |1.2.1b| | 1 |
| Rear brake binding | 1 |
| Nearside Outer Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Offside Front Upper Ball joint has excessive play |2.2.B.1f| | 1 |
| Front Upper Headlamp aim so that beam "kick up" is not visible on the screen and o/s/f |4.1.2 |a|| | 1 |
| Nearside Rear Suspension arm pin or bush excessively worn and o/s/r |5.3.4 |a| |i|| | 1 |
| Power steering pump leaking |2.1.5 |a|| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 1 |
| Offside Headlamp aim beam image obviously incorrect no image |1.8.A.1b| | 1 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Brake pedal anti-slip provision incomplete |3.3.A.1b| | 1 |
| Offside Rear Inner Position lamp not working |4.2.1 |a|| | 1 |
| Rear Anti-roll bar ball joint excessively worn x 2 (5.3.4 (a) (i)) | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Emissions not tested (8.2.1.2 (d)) | 1 |
| Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Main beam `tell-tale` not working |1.7.4c| | 1 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` sun visor not staying up. |8.3.1b| | 1 |
| Nearside Front Upper Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Headlamp aim beam image obviously incorrect no pattern |1.8.A.1b| | 1 |
| Nearside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar linkage worn and seriously weakened |2.4.G.1| | 1 |
| Offside Rear Anti-roll bar linkage worn and seriously weakened |2.4.G.1| | 1 |
| Offside Front Braking system leaking |3.6.A.1| | 1 |
| Offside Front Suspension arm has excessive play in a pin/bush yellow chalked |2.4.G.2| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Upper Front suspension retaining device missing SPLIT PIN BALL JOINT |2.5.A.4| | 1 |
| Brake pedal anti-slip provision worn smooth BRAKE |3.3.A.1b| | 1 |
| Nearside Wheel nut|s| missing |4.2.A.1e| | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| Offside Front Road wheel more than one fixing missing (5.2.1 (a) (ii)) | 1 |
| Front Suspension arm pin or bush likely to become detached both sides (5.3.4 (a) (ii)) | 1 |
| Offside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Windscreen washer not working | 1 |
| Offside Front Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Front brake excessively fluctuating | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Front Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc and outer |2.5.C.1a| | 1 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive lpg failure |7.3.D.3| | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Steering locking device missing |2.2.C.1g| | 1 |
| Offside Steering locking device missing |2.2.C.1g| | 1 |
| Nearside Front Upper Front suspension locking device missing |2.5.A.4| | 1 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Front Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Offside Rear Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Anti-roll bar worn and seriously weakened |2.4.G.1| | 1 |
| Brake pedal anti-slip provision worn smooth WORN DOWN TO METAL ON THE EDGE (1.1.2 (c)) | 1 |
| Electronic stability system warning lamp indicates a fault |3.4.1c| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Road wheel fixing loose (5.2.1 (a) (i)) | 1 |
| Nearside Headlamp has a product on the light source so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Headlamp has a product on the light source so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 1 |
| Nearside Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 1 |
| Front brake application uneven | 1 |
| Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Rear Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Front Anti-roll bar linkage ball joint likely to become detached |5.3.4 |a| |ii|| | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Nearside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Offside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Nearside Front Side repeater obscured more than 50% |1.4.A.2d| | 1 |
| Nearside Rear Inner Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Central Front Exhaust emissions likely to be affected by an exhaust leak |8.2.2.1 |b|| | 1 |
| Front Position lamp not working Both Sides (4.2.1 (a) (ii)) | 1 |
| Offside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Centre Rear Upper Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Inner Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement front bush |2.4.G.2| | 1 |
| Nearside Inner Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Inner Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Power steering pipe/hose leaking |2.1.5 |a|| | 1 |
| Offside Rear Wheel nut|s| missing wheel nut missing 1 of 5 |4.2.A.1e| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced both n/s and o/s side sills holed (6.1.1 (c) (i)) | 1 |
| Nearside Rear Seat belt buckle not functioning as intended (7.1.2 (d)) | 1 |
| Nearside Front Inner Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill ( hole ) (6.2.2 (d) (i)) | 1 |
| Offside Front Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.5 |b| |i|| | 1 |
| Offside Stop lamp|s| all not working |4.3.1 |a| |iii|| | 1 |
| Nearside Rear Lower Anti-roll bar linkage inappropriately repaired |2.4.A.2| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar rubber mounting bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Headlamp aim projected beam image is obviously incorrect Both front head lights (4.1.2 (c)) | 1 |
| Front Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Windscreen has damage | 1 |
| Offside Front Steering locking device missing |2.2.C.1g| | 1 |
| Offside Rear Brake lining|s| less than 1.5 mm thick |3.5.1g| | 1 |
| Nearside Front Steering system fouling brake pipe bracket adrift rubbing wheel |2.2.D.2a| | 1 |
| Offside Front Steering system fouling brake pipe bracket adrift rubbing wheel |2.2.D.2a| | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Offside Rear Body has a projection caused by damage bumper sticking out |6.1.C.1| | 1 |
| Offside Power steering component|s| leaking steering rack/gaiter area |2.3.3b| | 1 |