Most common failures | No# failures |
---|
Rear brake binding | 13 |
Brakes imbalanced across an axle | 13 |
Parking brake: efficiency below requirements |3.7.B.7| | 10 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 8 |
Windscreen wiper does not clear the windscreen effectively | 8 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 7 |
Rear parking brake recording little or no effort | 7 |
Offside Rear Braking system leaking |3.6.A.1| | 7 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 6 |
Registration plate lamp issues | 5 |
Service brake: efficiency below requirements |3.7.B.7| | 5 |
Offside rear brake recording little or no effort |3.7.B.5a| | 5 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
Headlamp aim out of alignment | 4 |
Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
Rear brake application uneven | 4 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 4 |
Horn not working |1.6.2a| | 4 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
Nearside Stop lamp not working |1.2.1b| | 4 |
Nearside Rear Braking system leaking |3.6.A.1| | 4 |
Brake hose excessively deteriorated | 3 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 3 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
Steering system excessively tight |2.2.D.1| | 3 |
Registration plate issues | 3 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 3 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
Windscreen washer not working | 2 |
Offside Rear Stop lamp not working |1.2.1b| | 2 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Rear Mechanical brake component has restricted free movement | 2 |
Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Indicator switch faulty |1.4.A.1| | 2 |
Main beam `tell-tale` not working |1.7.4c| | 2 |
Front brake application uneven | 2 |
Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Indicator tell tale inoperative |1.4.A.2a| | 2 |
Nearside Windscreen wiper not operating automatically when switched on |8.2.1b| | 2 |
Offside Windscreen wiper not operating automatically when switched on |8.2.1b| | 2 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
Nearside Front Steering pivot point has excessive play |2.2.B.1g| | 2 |
Nearside Inner Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
Nearside Headlamp not working on main beam |1.7.5a| | 2 |
Nearside Rear Stop lamp not working |1.2.1b| | 2 |
Nearside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Offside Stop lamp not working |1.2.1b| | 2 |
Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 2 |
Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
Nearside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Offside Rear Hydraulic brake cylinder leaking hydraulic fluid |3.6.A.1| | 2 |
Rear Exhaust system not adequately supported |7.1.1| | 2 |
Nearside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
Battery insecure |1.9.1| | 2 |
Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Windscreen wiper blade insecure | 2 |
Nearside Front Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt inner and outer |2.2.C.1c| | 2 |
Offside Front Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt inner and outer |2.2.C.1c| | 2 |
Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
Offside Front Upper Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front An item not tested |Manual| | 1 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Direction indicator adversely affected by the operation of another lamp (4.4.3 (b)) | 1 |
Offside Rear Position lamp adversely affected by the operation of another lamp (4.2.3 (c)) | 1 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Offside Outer Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings centre outer sill marked in yellow |6.1.B.2| | 1 |
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner sill marked in yellow |6.1.B.2| | 1 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings two places marked in yellow |6.1.B.2| | 1 |
Rear Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Horn not working (7.7 (a)) | 1 |
Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
Braking system leaking brake master cylinder is leaking brake fluid inside vehicle at brake pedal |3.6.A.1| | 1 |
Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
Nearside Drag link end seriously misaligned |2.2.C.1b| | 1 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Centre Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
Offside Front Upper Ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Headlamp not working on main beam |1.7.5a| | 1 |
Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded outer sill to floor |2.4.A.3| | 1 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded outer sill to floor |2.4.A.3| | 1 |
Offside Upper Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Inner Lower Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Exhaust has a major leak of exhaust gases downpipe to manifold flange insecure |7.1.2| | 1 |
front brakes release unevenly |3.7.B.4| | 1 |
Offside front brake binding |3.7.B.1| | 1 |
Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
Battery insecure and likely to fall from carrier |4.13 |a| |ii|| | 1 |
Nearside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner sill |6.2.2 |d| |i|| | 1 |
Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting o/s sill not welding correctly |6.2.2 |d| |i|| | 1 |
Nearside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
Offside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
Nearside Rear Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
Offside Rear Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
Nearside Front Upper Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Front Upper Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Front Radius arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Radius arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Front Lower Radius arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Lower Radius arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Exhaust emits dense blue smoke at idle |7.3.A.2b| | 1 |
Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
Nearside Front Suspension component mounting prescribed area is excessively corroded inner wheel arch/chassis |2.4.A.3| | 1 |
Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
Offside Outer Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Direction indicator incorrect colour |1.4.A.2f| | 1 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front Headlamp not in good working order |not working| |1.2.4a| | 1 |
Offside Indicator tell tale inoperative |1.4.A.2a| | 1 |
Offside Front Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Brake hose has insufficient room to move | 1 |
Offside Front Driver`s seat insecure |6.2.A.1| | 1 |
Fuel cap/sealing device sealing washer missing |7.2.4c| | 1 |
Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Horn not working |7.7 |a| |ii|| | 1 |
Dipswitch operation does not deflect all main beam headlamps to make them dipped beams |4.1.3 |b|| | 1 |
Exhaust silencer insecure System |8.1.1 |b| |i|| | 1 |
Headlamp aim not tested Both |4.1.2 |b|| | 1 |
Offside Front Hydraulic brake calliper leaking |1.1.16 |b| |i|| | 1 |
Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Direction indicators not working |1.4.A.2c| | 1 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Parking brake mechanism/associated mounting prescribed area is excessively corroded |3.1.9| | 1 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Centre Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
Offside Upper Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
Nearside Upper Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Nearside Rear brake drum contaminated by oil |3.5.1h| | 1 |
Offside Rear brake drum contaminated by oil |3.5.1h| | 1 |
Nearside Inner Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Inner Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Inner Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Fuel system component leaking pipe from filter to carb (6.1.3 (b) (i)) | 1 |
Fuel pipe insecure steering box arm rubbing on pipe (6.1.3 (a) (i)) | 1 |
Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill holed and corroded (5.3.6 (a) (i)) | 1 |
Nearside Rear Fuel pipe insecure |7.2.1| | 1 |
Service brake is causing the steering wheel to severely pull one way |3.7.C.2| | 1 |
Centre Bonnet retaining device ineffective |8.4.2| | 1 |
Rear Brake hose stretched |3.6.B.4c| | 1 |
Offside Rear Lower Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Rear Lower Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Lower Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Offside Front Lower Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Offside Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Front Exhaust system not adequately supported |7.1.1| | 1 |
Nearside Inner Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Inner Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Horn not loud enough to be heard by another road user |1.6.2b| | 1 |
Offside Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
Nearside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
Brake performance not tested |3.7.A.1| | 1 |
Offside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Direction indicators not working |1.4.A.2c| | 1 |
Offside Direction indicators not working |1.4.A.2c| | 1 |
Nearside Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Upper Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Upper Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Inner Rear Lower Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Inner Rear Lower Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Nearside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Nearside Front Horn not working |1.6.2a| | 1 |
Nearside Front Steering locking device missing |2.2.C.1g| | 1 |
Central Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Front Upper Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Offside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Rear Suspension component mounting prescribed area is excessively corroded inner sill |2.4.A.3| | 1 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded inner sill |2.4.A.3| | 1 |
Fuel cap/sealing device sealing washer deteriorated |7.2.4c| | 1 |
Bonnet retaining device ineffective |8.4.2| | 1 |
Nearside Front Upper Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
Offside Front Upper Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
All position lamps adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Nearside Rear Direction indicators not in good working order |function impaired| |1.5.A1b| | 1 |
Nearside Front Direction indicators not in good working order |function impaired| |1.5.A1b| | 1 |
Nearside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
Offside Front coil spring fractured |2.4.C.1a| | 1 |
Nearside Upper Ball joint has excessive play |2.2.B.1f| | 1 |
Brake hose damaged | 1 |
Service brake: efficiency below requirements |3.7.C.1a| | 1 |
Nearside Front Lower Suspension arm ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Lower Suspension arm ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Nearside Indicator tell tale inoperative |1.4.A.2a| | 1 |
Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Stop lamp not working |1.2.1b| | 1 |
Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
Offside Front Brake hose excessively damaged |3.6.B.4d| | 1 |
Centre Exhaust system not adequately supported |7.1.1| | 1 |
Parking brake lever has no reserve travel |3.1.6b| | 1 |
Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
Nearside Front Upper Suspension arm attachment bracket/mounting insecure |2.4.G.1| | 1 |
Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Offside Front front brake binding |3.7.B.1| | 1 |
Rear Brake hose leaking |3.6.A.1| | 1 |
Offside Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Front Upper Suspension arm locating pin locking device not properly locked insecure |2.4.G.3b| | 1 |
Nearside Front Upper Suspension arm locating pin locking device not properly locked |2.4.G.3b| | 1 |
Nearside Ball joint has excessive play |2.2.B.1f| | 1 |