Most common failures | No# failures |
---|
Headlamp aim out of alignment | 42 |
Rear brake binding | 20 |
Parking brake: efficiency below requirements |3.7.B.7| | 16 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 15 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 15 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 12 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 12 |
Windscreen wiper does not clear the windscreen effectively | 12 |
Registration plate lamp issues | 10 |
Parking brake lever has no reserve travel |3.1.6b| | 10 |
Rear parking brake recording little or no effort | 9 |
Brakes imbalanced across an axle | 8 |
Nearside Stop lamp not working |1.2.1b| | 8 |
Brake pipe excessively corroded | 8 |
Horn not working |1.6.2a| | 6 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 5 |
Offside front brake binding |3.7.B.1| | 5 |
Steering column top bearing excessively worn |2.1.2c| | 4 |
Front brake application uneven | 4 |
Registration plate issues | 4 |
Offside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 4 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
Offside Front Shock absorber has a serious fluid leak |2.7.3| | 3 |
Nearside front brake binding |3.7.B.1| | 3 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 3 |
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 3 |
Nearside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 3 |
Nearside Steering rack gaiter split |2.2.D.2d| | 3 |
Offside Stop lamp not working |1.2.1b| | 3 |
Offside Front Direction indicator not working |1.4.A.2c| | 3 |
Rear brake application uneven | 3 |
Service brake: efficiency below requirements |3.7.B.7| | 3 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 3 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 3 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
Offside Headlamp insecure |1.7.3| | 3 |
Brake hose damaged | 2 |
Nearside Front front brake binding |3.7.B.1| | 2 |
Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 2 |
Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
Offside Obligatory mirror missing |8.1.1| | 2 |
Offside Rear Stop lamp not working |1.2.1b| | 2 |
Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 2 |
Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
Emissions not tested |7.0| | 2 |
Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 2 |
Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 2 |
Centre Exhaust system not adequately supported |7.1.1| | 2 |
Offside Rear Suspension component mounting prescribed area is excessively corroded inner sill |2.4.A.3| | 2 |
Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
Offside Steering rack gaiter split |2.2.D.2d| | 2 |
Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Brake hose excessively deteriorated | 2 |
Front Brake pipe inadequately clipped |3.6.B.1| | 2 |
Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 2 |
Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 2 |
Nearside Headlamp insecure |1.7.3| | 2 |
Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 2 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
Offside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Offside Direction indicator flashing less than 60 times a minute |1.4.A.2g| | 2 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
Rear Mechanical brake component has restricted free movement | 2 |
Offside Front front brake binding |3.7.B.1| | 1 |
Offside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
Direction indicators not working |1.4.A.2c| | 1 |
Offside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
Rear Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
Offside Front Body has a sharp edge caused by corrosion wing |6.1.C.1| | 1 |
Steering wheel retaining device insecure |2.1.6| | 1 |
Nearside Front Lower Steering column flexible coupling has excessive play |2.1.5| | 1 |
Main beam `tell-tale` not working |1.7.4c| | 1 |
Indicator switch faulty |1.4.A.1| | 1 |
Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Headlamp insecure |1.7.3| | 1 |
Offside Front Headlamp insecure |1.7.3| | 1 |
Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Nearside Rear Lower Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Upper Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Front position lamp|s| obviously incorrectly positioned |1.1.A.3a| | 1 |
Brake pedal pad not secure to the pedal |3.3.A.1c| | 1 |
Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Front Parking brake lever has no reserve travel |3.1.6b| | 1 |
Nearside Lower Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded floor |2.4.A.3| | 1 |
Nearside Front Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Offside Front Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
Nearside Track rod end loose |2.2.B.1d| | 1 |
Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Lower Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
Nearside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
Offside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
Offside Rear Seat belt anchorage prescribed area is excessively corroded inner arch |5.2.6| | 1 |
Nearside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
Offside Front position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Hydraulic brake cylinder insecurely mounted |3.6.A.2a| | 1 |
Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
Offside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
Brake performance not tested |3.7.A.1| | 1 |
Offside Front brake caliper has restricted free movement |3.5.1k| | 1 |
Nearside Front Front position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Rear An item not tested |Manual| | 1 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Inner Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Inner Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Front Brake hose excessively damaged |3.6.B.4d| | 1 |
Steering column flexible coupling has excessive play |2.1.5| | 1 |
Nearside Front Brake pipe kinked |3.6.B.2b| | 1 |
Offside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Steering rack insecure rubber mounting deteriorated |2.2.B.1a| | 1 |
Offside Front Seat belt anchorage prescribed area is excessively corroded cross member |5.2.6| | 1 |
Nearside Track rod end ball joint dust cover missing |2.2.C.1c| | 1 |
Offside Front Lower Suspension arm ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Stop lamp not working |1.2.1b| | 1 |
Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Offside Side repeater not working |1.4.A.2c| | 1 |
Nearside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
Nearside Steering rack gaiter insecure |2.2.D.2d| | 1 |
Nearside Front Braking system leaking |3.6.A.1| | 1 |
Nearside Rear wheel cylinder leaking |3.6.A.1| | 1 |
Nearside Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
Nearside Steering rack insecure |2.2.B.1a| | 1 |
Offside Front Macpherson strut insecure |2.4.G.1| | 1 |
Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Fuel tank leaking |7.2.3| | 1 |
Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
Offside rear brake grabbing severely |3.7.A.5b| | 1 |
Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front All position lamps not working |1.1.A.3b| | 1 |
Nearside Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Steering rack insecure |2.2.B.1a| | 1 |
Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
Steering rack gaiter split |2.2.D.2d| | 1 |
Offside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Steering rack deformed and unserviceable |2.2.C.1d| | 1 |
Nearside Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Inner Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Inner Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Inner Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Inner Front Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Position lamp lens seriously defective interaction when foot brake applied |brake light| |4.2.1 |b|| | 1 |
Offside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
Offside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Nearside Headlamp not working on main beam |1.7.5a| | 1 |
Offside Headlamp not working on main beam |1.7.5a| | 1 |
Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Bootlid cannot be secured in the closed position |6.4.1| | 1 |
Nearside Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Nearside Brake cable locking device insecure |3.5.1l| | 1 |
Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Steering rack insecure |2.2.B.1a| | 1 |
Nearside Front Brake hose twisted and insecure |3.6.B.4c| | 1 |
Offside Front Brake hose twisted and insecure |3.6.B.4c| | 1 |
Steering system fouling clutch cable on steering column joint |2.2.D.2a| | 1 |
Rear Exhaust has a major leak of exhaust gases and loose |7.1.2| | 1 |
Nearside Rear Stop lamp not working |1.2.1b| | 1 |
Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Direction indicators flashing less than 60 times a minute 23/04/2017 retest |1.4.A.2g| | 1 |
Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
Service brake: efficiency below requirements |3.7.C.1a| | 1 |
Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
Offside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength spring hanger (5.3.6 (a) (i)) | 1 |
Driver`s door cannot be opened from outside the vehicle |6.2.3 |a|| | 1 |
Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis arount trailing arm mounting |5.3.6 |a| |i|| | 1 |
Nearside Front Upper Suspension component mounting prescribed area excessively corroded significantly reducing structural strength suspension mounting area |5.3.6 |a| |i|| | 1 |
Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner and outer sill area |5.3.6 |a| |i|| | 1 |
Offside Suspension component mounting prescribed area excessively corroded significantly reducing structural strength middle chassis |5.3.6 |a| |i|| | 1 |
Rear Exhaust system insecure |6.1.2 |a|| | 1 |
Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
Nearside Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
Parking brake lever is fouling adjacent parts of the vehicle |3.1.6b| | 1 |
Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
Offside Rear Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Trailing arm attachment bracket/mounting worn and its strength is seriously reduced |2.4.G.1| | 1 |
Battery insecure |1.9.1| | 1 |
Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Rear rear brakes release unevenly |3.7.B.4| | 1 |
Nearside Front Brake hose twisted twisted and fouling |3.6.B.4c| | 1 |
Fuel system component leaking at carb |7.2.3| | 1 |
Rear Stop lamp not working |1.2.1b| | 1 |
Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Fuel cap/sealing device missing |7.2.4a| | 1 |
Indicator tell tale inoperative |1.4.A.2a| | 1 |
Offside Rear Upper Shock absorber has an excessively worn bush |2.7.4| | 1 |
Nearside Rear Trailing arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Rear Trailing arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Direction indicator flashing less than 60 times a minute |1.4.A.2g| | 1 |
Offside Rear Parking brake lever, pawl mechanism pivot|s| locking device missing |3.1.4b| | 1 |
Parking brake mechanism/associated mounting prescribed area is fractured |3.1.9| | 1 |
Exhaust system not adequately supported |7.1.1| | 1 |
Offside Front Fuel system component insecure |7.2.1| | 1 |
Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Rear An item not tested |Manual| | 1 |
Offside Trailer electrical socket |13 pin| not operating the trailer lamps as intended |1.9.4| | 1 |
Trailer electrical socket |13 pin| not operating the trailer lamps as intended |1.9.4| | 1 |
Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
Nearside Steering locking device missing |2.2.C.1g| | 1 |
Offside Steering locking device missing |2.2.C.1g| | 1 |
Nearside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |