| Most common failures | No# failures |
|---|
| Registration plate issues | 6 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 4 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 4 |
| Service brake: efficiency below requirements |3.7.B.7| | 4 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 3 |
| Nearside Front front brake binding |3.7.B.1| | 3 |
| Offside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Steering damper leaking oil |2.2.C.1f| | 2 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 2 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 2 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 2 |
| Brake performance not tested |3.7.A.1| | 2 |
| Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Offside front brake binding |3.7.B.1| | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Rear brake binding | 2 |
| Offside Front front brake binding |3.7.B.1| | 2 |
| Registration plate lamp issues | 2 |
| Braking system leaking |3.6.A.1| | 2 |
| Rear parking brake recording little or no effort | 2 |
| Parking brake: efficiency below requirements |3.7.B.7| | 2 |
| Mechanical brake component has restricted free movement | 2 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Side repeater incomplete |1.5.A1b| | 1 |
| Offside Side repeater incomplete |1.5.A1b| | 1 |
| Rear Exhaust has a part missing |7.1.1a| | 1 |
| Central Exhaust silencer insecure offside |8.1.1 |b| |i|| | 1 |
| Offside Front Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |8.1.1 |a|| | 1 |
| Offside Front Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Brake performance not tested |1.2.1 |g|| | 1 |
| Emissions not tested |8.2.1.2 |d|| | 1 |
| Nearside Rear Upper Body component likely to become detached under vehicle |6.2.1 |a| |ii|| | 1 |
| Nearside Rear Upper Body component insecure under vehicle |6.2.1 |a| |i|| | 1 |
| Brake hose excessively deteriorated | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Brake pipe excessively corroded | 1 |
| Steering system excessively tight |2.2.D.1| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Headlamp aim out of alignment | 1 |
| Power steering pipe/hose leaking |2.1.5 |a|| | 1 |
| Nearside Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Offside Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Front Service brake imbalanced across an axle (1.2.1 (b) (i)) | 1 |
| Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 1 |
| Offside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Front Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Windscreen washer not working | 1 |
| Nearside Front Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Hazard warning lamps operated by more than one switch |1.4.B.1c| | 1 |
| Battery insecure |1.9.1| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Battery insecure temporary repair cable tied |1.9.1| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Direction indicators not working |1.4.A.2c| | 1 |
| Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Lower Shock absorber insecure |2.7.2b| | 1 |
| Offside Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Windscreen wiper does not clear the windscreen effectively | 1 |
| Offside Cab steps so insecure it is likely to cause injury rear body step under framework badly corroded (6.2.8 (a) (ii)) | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Rear Service brake excessively binding OS & NS |1.2.1 |f|| | 1 |
| Fuel cap/sealing device ineffective cap damaged and unable to inspect |6.1.3 |b| |i|| | 1 |
| Nearside Front Side repeater missing |1.4.A.2b| | 1 |
| Offside Front Side repeater missing |1.4.A.2b| | 1 |