Most common failures | No# failures |
---|
Registration plate lamp issues | 27 |
Brake pipe excessively corroded | 26 |
Headlamp aim out of alignment | 19 |
Windscreen wiper does not clear the windscreen effectively | 15 |
Parking brake: efficiency below requirements |3.7.B.7| | 11 |
Front brake disc in such a condition that it is seriously weakened | 7 |
Offside Front coil spring fractured |2.4.C.1a| | 6 |
Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 6 |
Rear brake binding | 6 |
Offside Front coil spring incomplete |2.4.C.1a| | 5 |
Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 5 |
Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 5 |
Nearside Front coil spring incomplete |2.4.C.1a| | 5 |
Parking brake lever has no reserve travel |3.1.6b| | 4 |
Offside Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 4 |
Nearside Front coil spring fractured |2.4.C.1a| | 4 |
Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 4 |
Centre Rear Seat belt retracting mechanism defective |5.2.5b| | 4 |
Offside Rear fog lamp not working |1.3.2b| | 4 |
Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 4 |
Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
Nearside Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 3 |
Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 3 |
Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 3 |
Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 3 |
Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 3 |
Rear parking brake recording little or no effort | 3 |
Registration plate issues | 3 |
Rear Body has a sharp edge caused by damage |6.1.C.1| | 2 |
Windscreen has damage | 2 |
Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
Exhaust engine idle speed too high |7.3.D.1| | 2 |
Offside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
Front brake application uneven | 2 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Brakes imbalanced across an axle | 2 |
Offside Front brake disc excessively scored |3.5.1h| | 2 |
Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Offside Outer Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Front Exhaust system not adequately supported |7.1.1| | 2 |
Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
Offside Headlamp not working on main beam |1.7.5a| | 1 |
Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Nearside Rear passenger door catch deteriorated so the door cannot be readily opened or closed handle sticking |6.2.B.2| | 1 |
Offside Rear passenger door catch deteriorated so the door cannot be readily opened or closed handle sticking |6.2.B.2| | 1 |
Nearside Front Tie bar/rod ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Rear Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
Offside Rear Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
Nearside Rear Outer Suspension component mounting prescribed area is excessively corroded cill |2.4.A.3| | 1 |
Nearside Rear Inner Suspension component mounting prescribed area is excessively corroded cill |2.4.A.3| | 1 |
Offside Rear Outer Suspension component mounting prescribed area is excessively corroded cill |2.4.A.3| | 1 |
Offside Rear Inner Suspension component mounting prescribed area is excessively corroded cill |2.4.A.3| | 1 |
Offside Outer Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
All position lamps not working |1.1.A.3b| | 1 |
Nearside Side repeater not working |1.4.A.2c| | 1 |
Nearside Rear coil spring incomplete |2.4.C.1a| | 1 |
Nearside Front Bonded suspension unit attachment loose |2.4.F.1a| | 1 |
Offside Front Bonded suspension unit attachment loose |2.4.F.1a| | 1 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Offside Rear Radius arm severely distorted |2.4.G.1| | 1 |
Driver`s seat insecure |6.2.A.1| | 1 |
Nearside Front Front drive shaft damaged |2.5.C.2a| | 1 |
Centre Rear Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Brake load sensing valve linkage seized |3.6.E.3| | 1 |
An item not tested |Manual| | 1 |
Rear Rear passenger seat cannot be secured in the upright position. |6.2.3| | 1 |
Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
Horn not working |1.6.2a| | 1 |
Offside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Anti-lock braking system warning lamp indicates an ABS fault | 1 |
Offside Rear coil spring incomplete |2.4.C.1a| | 1 |
Nearside Headlamp not working on main beam |1.7.5a| | 1 |
Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Steering rack gaiter split |2.2.D.2d| | 1 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
Nearside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
Nearside Front brake disc excessively scored |3.5.1h| | 1 |
Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
Rear brake application uneven | 1 |
Nearside Track rod end loose |2.2.B.1d| | 1 |
Nearside Front Suspension arm insecure |2.4.G.1| | 1 |
Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
Nearside Rear Service brake indicates brake bind |3.7.D.2a| | 1 |
Nearside Steering rack insecure |2.2.B.1a| | 1 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Fuel tank leaking |7.2.3| | 1 |
Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Stop lamp not working |1.2.1b| | 1 |
Offside Front Track rod end ball pin shank loose |2.2.B.1c| | 1 |
Offside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
Nearside Rear An item not tested |Manual| | 1 |
Offside Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
Nearside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Front brake disc excessively pitted |3.5.1h| | 1 |
Nearside Front suspension has excessive play in a track control arm inner bush |2.5.B.2b| | 1 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 1 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Nearside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
Offside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Service brake: efficiency below requirements |3.7.B.7| | 1 |
Rear Mechanical brake component has restricted free movement | 1 |
Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Front Power steering component|s| leaking |2.3.3b| | 1 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Front Driver`s seat insecure |6.2.A.1| | 1 |
Offside Rear coil spring fractured |2.4.C.1a| | 1 |
Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Offside Outer Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Outer Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front coil spring cracked |2.4.C.1a| | 1 |
Offside Rear Rear reflector excessively damaged so that its function is impaired |1.5.1c| | 1 |
Nearside Direction indicators not working |1.4.A.2c| | 1 |
Nearside Direction indicators incorrect colour |1.4.A.2f| | 1 |
Headlamp switch faulty |1.7.1| | 1 |
Nearside Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
Offside Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
Nearside Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
Offside Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Nearside Front Lower Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Lower Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front coil spring broken |2.4.C.1a| | 1 |
Nearside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Rear Fuel system component insecure |7.2.1| | 1 |
Centre Braking system leaking |3.6.A.1| | 1 |
Nearside Front Braking system leaking |3.6.A.1| | 1 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Front Headlamp aim not tested |1.8.A.1c| | 1 |
Nearside Front Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 1 |