| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 13 |
| Windscreen wiper does not clear the windscreen effectively | 8 |
| Registration plate lamp issues | 8 |
| Parking brake: efficiency below requirements |3.7.B.7| | 7 |
| Brake hose excessively deteriorated | 6 |
| Brakes imbalanced across an axle | 6 |
| Horn not working |1.6.2a| | 6 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 6 |
| Brake pipe excessively corroded | 5 |
| Registration plate issues | 5 |
| Service brake: efficiency below requirements |3.7.B.7| | 4 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Direction indicators not working |1.4.A.2c| | 4 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Rear brake application uneven | 3 |
| Rear parking brake recording little or no effort | 3 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Nearside Seat belt retracting mechanism defective |5.2.5b| | 3 |
| Battery insecure |1.9.1| | 3 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 3 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Brake hose damaged | 3 |
| Rear Exhaust system not adequately supported |7.1.1| | 3 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Rear Mechanical brake component has restricted free movement | 2 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 2 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Driver`s seat insecure |6.2.A.1| | 2 |
| Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Offside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 2 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 2 |
| Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Stop lamp not working |1.2.1b| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Nearside Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Rear brake binding | 2 |
| Offside Front front brake binding |3.7.B.1| | 2 |
| Exhaust system not adequately supported |7.1.1| | 2 |
| Front Steering locking device missing |2.2.C.1g| | 2 |
| Exhaust mounting missing |7.1.1b| | 2 |
| Brake pedal spongy |3.3.B.1b| | 2 |
| Offside Front Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Nearside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Rear Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Front Headlamp not working on main beam |1.7.5a| | 1 |
| Front Brake pipe leaking |3.6.A.1| | 1 |
| Front Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front Drag link end ball pin shank loose |2.2.B.1c| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Suspension spring mounting prescribed area is deliberately modified which significantly reduces the original strength |2.4.A.3| | 1 |
| Offside Front Suspension spring mounting prescribed area is deliberately modified which significantly reduces the original strength |2.4.A.3| | 1 |
| Offside Stop lamp|s| lens defective such that the emitted light is adversely affected |4.3.1 |b| |ii|| | 1 |
| Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Nearside Front Steering component mounting prescribed area is excessively corroded step/floor |2.1.2 |e| |i|| | 1 |
| Nearside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Front Seat belt stitching badly frayed |5.2.2b| | 1 |
| Nearside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| All position lamps not in good working order |function impaired| |1.1.A.2a| | 1 |
| Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Stop lamp excessively deteriorated so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Offside Stop lamp excessively deteriorated so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Rear Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Nearside Obligatory mirror seriously deteriorated, affecting the rear view |8.1.2a| | 1 |
| Offside Obligatory mirror seriously deteriorated, affecting the rear view |8.1.2a| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Centre Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Front Lower Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Indicator switch insecure |1.4.A.1| | 1 |
| Passenger`s seat insecure |6.2.A.1| | 1 |
| Nearside Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Front Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Nearside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Rear Brake hose exposed to excessive heat |3.6.B.4f| | 1 |
| Steering box insecure |2.2.B.1a| | 1 |
| Intermediate drop arm insecure |2.2.B.1a| | 1 |
| Ball joint has excessive play |2.2.B.1f| | 1 |
| rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Road wheel badly damaged |4.2.A.1a| | 1 |
| Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Rear Fuel system component insecure |7.2.1| | 1 |
| Horn not working (7.7 (a)) | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Lower Steering column flexible coupling is excessively deteriorated |2.1.5| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Indicator switch faulty |1.4.A.1| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Steering wheel retaining device insecure |2.1.6| | 1 |
| Nearside Rear Suspension weakened allowing body or other component to foul a road wheel or would do so if laden |2.4.A.1b| | 1 |
| Offside Rear Suspension weakened allowing body or other component to foul a road wheel or would do so if laden |2.4.A.1b| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Front Parking brake lever, pawl mechanism pivot|s| or their associated mountings locking device insecure |3.1.4b| | 1 |
| Rear Brake hose leaking |3.6.A.1| | 1 |
| Brake hose has insufficient room to move | 1 |
| Fuel system component insecure |7.2.1| | 1 |
| Nearside Front Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Direction indicator flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Front Horn not loud enough to be heard by another road user |1.6.2b| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Headlamp aim not tested |1.8.A.1c| | 1 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Brake pedal actuating linkage has excessive wear in the eye of the clevis joint |3.3.A.1g| | 1 |
| Front Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear rear brake grabbing severely |3.7.A.5b| | 1 |
| Nearside Rear Leaf spring fractured |2.4.B.1a| | 1 |
| Nearside Obligatory mirror missing |8.1.1| | 1 |
| Nearside Obligatory mirror does not provide a view to the rear |8.1.2b| | 1 |
| Offside Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Front brake application uneven | 1 |
| Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front passenger seat insecure |6.2.3| | 1 |
| Offside Front Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Steering rack insecure |2.2.B.1a| | 1 |
| Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Nearside Steering locking device missing |2.2.C.1g| | 1 |
| Offside Steering locking device missing |2.2.C.1g| | 1 |
| Nearside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Nearside Headlamp aim headlamp not in good working order adversely affecting beam image |1.2.4b| | 1 |
| Offside Headlamp aim headlamp not in good working order adversely affecting beam image |1.2.4b| | 1 |
| Nearside Outer Front Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Offside Outer Front Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Nearside Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Front Wheel insecure |4.2.A.1c| | 1 |
| Offside Front Wheel insecure |4.2.A.1c| | 1 |
| Nearside Rear Wheel insecure |4.2.A.1c| | 1 |
| Offside Rear Wheel insecure |4.2.A.1c| | 1 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Brake pipe kinked |3.6.B.2b| | 1 |
| Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Rear position lamp|s| obviously incorrectly positioned |1.1.A.3a| | 1 |
| Brake master cylinder fluid level below minimum level |3.6.G.1e| | 1 |
| Exhaust has a part missing |7.1.1a| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.3.B.1| | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
| Offside Rear wheel cylinder leaking |3.6.A.1| | 1 |
| Offside Rear Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Rear Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Rear Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front Statutory seat belt missing |5.1.1| | 1 |
| Nearside Front Statutory seat belt missing |5.1.1| | 1 |
| Front Brake pedal has excessive side movement indicating a badly worn bearing or pivot |3.3.A.1d| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Front Battery insecure |1.9.1| | 1 |
| Nearside Front Braking system leaking |3.6.A.1| | 1 |
| Brake rod locking device insecure |3.5.1l| | 1 |
| Nearside Rear Hydraulic brake cylinder insecurely mounted |3.6.A.2a| | 1 |
| Offside Rear Hydraulic brake cylinder insecurely mounted |3.6.A.2a| | 1 |
| Nearside Rear Leaf spring to axle securing nut insecure |2.4.B.7b| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp indicator |1.1.A.3f| | 1 |
| Offside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Windscreen wiper blade insecure | 1 |
| Nearside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Front wheel bearing has excessive play both |2.5.A.3c| | 1 |