| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 15 |
| Headlamp aim out of alignment | 11 |
| Brakes imbalanced across an axle | 9 |
| Brake pipe excessively corroded | 6 |
| Horn not working |1.6.2a| | 5 |
| Parking brake: efficiency below requirements |3.7.B.7| | 4 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 4 |
| Offside Rear fog lamp not working |1.3.2b| | 4 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Indicator switch faulty |1.4.A.1| | 3 |
| Rear parking brake recording little or no effort | 3 |
| Steering column top bearing excessively worn |2.1.2c| | 3 |
| Offside front brake binding |3.7.B.1| | 3 |
| Offside Side repeater not working |1.4.A.2c| | 2 |
| Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 2 |
| Battery insecure |1.9.1| | 2 |
| Front position lamp|s| incorrect colour |1.1.A.3e| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 2 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 2 |
| Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 2 |
| Offside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Registration plate issues | 2 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Direction indicators not working |1.4.A.2c| | 2 |
| Rear brake application uneven | 2 |
| Rear brake binding | 2 |
| Registration plate lamp issues | 2 |
| Power steering component|s| leaking |2.3.3b| | 2 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Fuel pipe leaking by tank |7.2.3| | 1 |
| Offside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Rear fog lamp does not emit a steady red light (4.5.4 (a)) | 1 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Stop lamp not working both |1.2.1b| | 1 |
| Steering box has a significant oil leak |2.2.D.2e| | 1 |
| Hazard warning switch missing |1.4.B.1d| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Offside Front Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner sill (6.2.2 (d) (i)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Central Rear Electrical wiring likely to touch hot or rotating parts (4.11 (a) (iii)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Front Steering locking device insecure |2.2.C.1g| | 1 |
| Offside Service brake is causing the steering wheel to severely pull one way |3.7.C.2| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Nearside Inner Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Rear Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Service brake is causing the vehicle to swerve to the offside |3.7.C.2| | 1 |
| Offside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Rear All position lamps not working |4.2.1 |a|| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Parking brake mechanism/associated mounting prescribed area is excessively corroded |3.1.9| | 1 |
| Offside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Centre Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Emissions not tested |7.0| | 1 |
| Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 1 |
| Fuel cap/sealing device missing |7.2.4a| | 1 |
| Nearside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Rear Rear fog lamp missing |1.3.2a| | 1 |
| Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Steering wheel locking device insecure |2.1.6| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Front brake application uneven | 1 |
| Electrical wiring damaged and bare connector exposed |1.9.2c| | 1 |
| Electrical wiring damaged, likely to cause a short |1.9.2b| | 1 |
| Electrical wiring damaged and bare wires exposed |1.9.2c| | 1 |
| Offside Rear fog lamp insecure |1.3.2a| | 1 |
| Horn control missing |1.6.1| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Nearside front brakes release unevenly |3.7.B.4| | 1 |
| rear brakes release unevenly |3.7.B.4| | 1 |
| Offside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Rear Braking system leaking |3.6.A.1| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Brake hose excessively deteriorated | 1 |
| Rear Exhaust has a part missing |7.1.1a| | 1 |
| Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front brake caliper locking device insecure |3.5.1l| | 1 |
| Nearside Axle king pin is loose in the axle beam |2.5.A.3a| | 1 |
| Offside Front Axle king pin is loose in the axle beam |2.5.A.3a| | 1 |
| Offside Indicator switch faulty |1.4.A.1| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Rear fog lamp tell tale missing |1.3.1b| | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Front Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Nearside Rear Leaf spring main leaf fractured (5.3.1 (b) (ii)) | 1 |
| Exhaust emissions carbon monoxide content excessive very high at adle |7.3.B.1a| | 1 |
| Rear fog lamp missing |1.3.2a| | 1 |
| Brake load sensing valve inoperative |3.6.E.3| | 1 |
| Offside Front Brake pipe leaking |3.6.A.1| | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Central Exhaust emissions likely to be affected by an exhaust leak Exhaust has major leak at front of centre silencer. (8.2.1.1 (b)) | 1 |
| Emissions unable to be completed Major exhaust leak (8.2.1.2 (d)) | 1 |
| Central Front Steering linkage ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Inner front sill at previous repair corroded/holed. (6.1.1 (c) (i)) | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Hazard warning switch inoperative (4.4.2 (a) (ii)) | 1 |
| Nearside Front Seat belt retracting mechanism defective (7.1.2 (e)) | 1 |
| Offside Front Seat belt retracting mechanism defective (7.1.2 (e)) | 1 |
| Nearside Front Shock absorbers has a serious fluid leak | 1 |
| Offside Front Shock absorbers has a serious fluid leak | 1 |
| Offside Exhaust has a major leak of exhaust gases silencer blown |6.1.2 |a|| | 1 |
| Offside Rear Exhaust has a major leak of exhaust gases rear pipe holed |6.1.2 |a|| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Nearside Front Inner Drag link end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Front Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Anti-roll bar synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside front brake juddering severely |3.7.A.2b| | 1 |
| Offside front brake juddering severely |3.7.A.2b| | 1 |
| Nearside rear brake juddering severely |3.7.A.5b| | 1 |
| Offside rear brake juddering severely |3.7.A.5b| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |