| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 17 |
| Brake pipe excessively corroded | 15 |
| Registration plate lamp issues | 9 |
| Brake hose excessively deteriorated | 8 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 5 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 5 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 5 |
| Headlamp aim out of alignment | 4 |
| Windscreen washer not working | 4 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 4 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 3 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 3 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 3 |
| Brakes imbalanced across an axle | 3 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 3 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Nearside Front Shock absorbers has a serious fluid leak | 2 |
| Rear fog lamp not working |1.3.2b| | 2 |
| Registration plate issues | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Rear parking brake recording little or no effort | 2 |
| Offside Front Shock absorbers has a serious fluid leak | 2 |
| Offside Front Seat belt buckle not functioning as intended (7.1.2 (d)) | 2 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 2 |
| Nearside Front Direction indicator incorrect colour (4.4.3 (a)) | 2 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Offside Rear Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Body has a sharp edge caused by damage front number plate trim |6.1.C.1| | 1 |
| Offside Front Road wheel fixing missing |5.2.1 |a| |i|| | 1 |
| Nearside Rear Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear fog lamp not working |1.3.2b| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 1 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill area as marked |6.1.B.2| | 1 |
| rear parking |secondary| brakes imbalanced | 1 |
| Offside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Centre Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Nearside Rear Suspension arm cracked |2.4.G.1| | 1 |
| Nearside Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a| |ii|| | 1 |
| Nearside Rear Direction indicator incorrect colour |4.4.3 |a|| | 1 |
| Brake pedal anti-slip provision missing |1.1.2 |c|| | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 1 |
| Nearside Rear Brake relay lever has abnormal movement of levers indicating excessive wear or maladjustment |touching lower suspension arm| |1.1.15 |f|| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Horn not working |1.6.2a| | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Rear Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Central Exhaust system not adequately supported exhaust loose |7.1.1| | 1 |
| Fuel cap/sealing device missing (6.1.3 (b) (i)) | 1 |
| Central Front Prop shaft bearing excessively worn (6.1.7 (b) (i)) | 1 |
| Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 1 |
| Electronic stability control switch not functioning correctly (7.12 (d)) | 1 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
| Offside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Nearside Front Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Offside Front Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Nearside Rear Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Nearside Front Outer Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
| Offside Rear Outer Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Central Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Rear Lower Seat belt anchorage prescribed area strength or continuity significantly reduced mounting area holed and corroded (7.1.1 (a) (i)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Exhaust has a major leak of exhaust gases front pipe (6.1.2 (a)) | 1 |
| Front Exhaust system insecure where it joins centre (6.1.2 (a)) | 1 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Nearside Rear Upper Suspension component pin or bush excessively worn outer (5.3.4 (a) (i)) | 1 |
| Offside Rear Upper Suspension component pin or bush excessively worn outer (5.3.4 (a) (i)) | 1 |
| Nearside Front Upper Suspension component pin or bush excessively worn inner (5.3.4 (a) (i)) | 1 |
| Offside Front Upper Suspension component pin or bush excessively worn inner (5.3.4 (a) (i)) | 1 |
| Exhaust silencer insecure Pipe cracked (8.1.1 (b) (i)) | 1 |
| Front Bumper insecure (6.1.4 (a) (i)) | 1 |
| Offside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Nearside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Offside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.2.2 (g)) | 1 |
| Prop shaft bearing likely to break up (6.1.7 (b) (ii)) | 1 |
| Nearside Rear Suspension arm modified so the suspension is likely to foul other components suspension airbag fouling on driveshaft (5.3.3 (c) (ii)) | 1 |
| Hydraulic fluid leaking excessively gear box inter cooler and sump (8.4.1 (a) (i)) | 1 |
| Offside Lower Power steering pipe/hose leaking (2.1.5 (a)) | 1 |
| Power steering malfunctioning (2.1.5 (a)) | 1 |
| Nearside Rear Lower Suspension arm corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Offside Rear Lower Suspension arm corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Power steering pipe/hose leaking (2.1.5 (a)) | 1 |
| Nearside Rear Upper Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Upper Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Suspension component mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected (5.3.6 (a) (ii)) | 1 |
| Offside Front Suspension component mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected (5.3.6 (a) (ii)) | 1 |
| Nearside Front Upper Suspension arm modified so the suspension is likely to foul other components (5.3.3 (c) (ii)) | 1 |
| Offside Front Upper Suspension arm modified so the suspension is likely to foul other components (5.3.3 (c) (ii)) | 1 |
| Nearside Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced inner sill corroded within 30cm of stressed area (6.1.1 (c) (i)) | 1 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Offside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Front Drive shaft securing bolt loose (6.1.7 (a) (i)) | 1 |
| Offside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |