| Most common failures | No# failures |
|---|
| Parking brake: efficiency below requirements |3.7.B.7| | 65 |
| Rear parking brake recording little or no effort | 44 |
| Parking brake lever has no reserve travel |3.1.6b| | 24 |
| Headlamp aim out of alignment | 23 |
| Windscreen wiper does not clear the windscreen effectively | 21 |
| Registration plate lamp issues | 15 |
| Rear fog lamp not working |1.3.2b| | 12 |
| Brake pipe excessively corroded | 11 |
| Brake hose excessively deteriorated | 8 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 7 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 6 |
| Windscreen washer not working | 5 |
| Offside Side repeater incorrect colour |1.4.A.2f| | 4 |
| Offside Front Direction indicator not working |1.4.A.2c| | 4 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 4 |
| Rear Exhaust system not adequately supported |7.1.1| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Offside Rear Stop lamp not working |1.2.1b| | 3 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 3 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 3 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 3 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 3 |
| Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 2 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 2 |
| Offside Front Direction indicators incorrect colour |1.4.A.2f| | 2 |
| Front brake excessively fluctuating | 2 |
| Centre Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Side repeater incorrect colour |1.4.A.2f| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Front brake disc in such a condition that it is seriously weakened | 2 |
| Brakes imbalanced across an axle | 2 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Offside Front Brake hose leaking |3.6.A.1| | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 2 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Nearside Rear Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 2 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Horn not working |1.6.2a| | 1 |
| Offside Front Brake hose bulging under pressure |1.1.12 |d|| | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Rear Upper Suspension arm pin or bush excessively worn Outer rose joint |5.3.4 |a| |i|| | 1 |
| Offside Rear Upper Suspension arm pin or bush excessively worn Outer rose joint |5.3.4 |a| |i|| | 1 |
| Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Rear fog lamp tell tale missing |1.3.1b| | 1 |
| Rear fog lamp switch missing |1.3.1a| | 1 |
| Nearside rear brake excessively fluctuating |3.7.B.3| | 1 |
| Offside rear brake excessively fluctuating |3.7.B.3| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Rear Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Windscreen wiper blade insecure | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded sill |5.2.6| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Centre Rear Rear fog lamp not working |1.3.2b| | 1 |
| Front Exhaust system not adequately supported |7.1.1| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front Windscreen wiper not working |3.4 |a|| | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Direction indicator missing |1.4.A.2b| | 1 |
| Offside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Side repeater incorrect colour faded to white in places |1.4.A.2f| | 1 |
| Exhaust has a major leak of exhaust gases rear box corroded and leaking |7.1.2| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint VERY WORN |2.4.G.2| | 1 |
| Nearside Side repeater incorrect colour bulb colour has deteriorated |1.4.A.2f| | 1 |
| Offside Side repeater incorrect colour bulb colour has deteriorated |1.4.A.2f| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Centre Front Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Front Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside Front Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside Rear brake caliper leaking |3.6.A.1| | 1 |
| Offside Lower Front suspension has excessive movement at a suspension ball joint |2.5.A.1c| | 1 |
| Offside Front Side repeater missing |1.4.A.2b| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a| |ii|| | 1 |
| Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside front brake juddering severely |3.7.A.2b| | 1 |
| Offside Front Anti-roll bar attachment bracket/mounting fractured |2.4.G.1| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Rear Radius arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded inner sill |2.4.A.3| | 1 |
| Nearside Rear Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Nearside Rear Upper Brake pipe inadequately clipped under wheel arch |3.6.B.1| | 1 |
| Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar linkage inappropriately repaired |2.4.A.2| | 1 |
| Offside Front Anti-roll bar linkage inappropriately repaired |2.4.A.2| | 1 |
| Nearside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Nearside Inner Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Inner Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm ball joint likely to become detached |5.3.4 |a| |ii|| | 1 |
| Front Undertray likely to become detached |6.2.1 |a| |ii|| | 1 |
| Front Brake pedal has insufficient reserve travel |1.1.2 |a|| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Rear fog lamp switch faulty |1.3.1a| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Side repeater incorrect colour (4.4.3 (a)) | 1 |
| Nearside Outer Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wheel arch (5.3.6 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wheel arch (5.3.6 (a) (i)) | 1 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced Sill (7.1.1 (a) (i)) | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced Sill (7.1.1 (a) (i)) | 1 |
| Nearside Front Fuel system component leaking excessively or a risk of fire Fuel Filter (6.1.3 (b) (ii)) | 1 |
| Offside Rear Other passenger door likely to open inadvertently or not remain closed (6.2.3 (b) (ii)) | 1 |
| Central Prop shaft bearing likely to break up (6.1.7 (b) (ii)) | 1 |
| Central Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front Brake hose damaged and likely to fail (1.1.12 (a)) | 1 |
| Front Brake disc significantly and obviously worn ns/os (1.1.14 (a) (i)) | 1 |
| Front Windscreen wiper not working Both sides (3.4 (a)) | 1 |
| Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Offside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Sill (5.3.6 (a) (i)) | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 1 |
| Central Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Front Inner Direction indicator incorrect colour side repeater (4.4.3 (a)) | 1 |
| Emissions not tested (8.2.1.2 (d)) | 1 |
| Offside Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Offside Front Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
| Offside Rear Outer Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced sill (6.1.1 (c) (i)) | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits c/o 540 max 200 (8.2.1.2 (a)) | 1 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front Side repeater incorrect colour (4.4.3 (a)) | 1 |
| Offside Front Headlamp are incorrectly positioned (4.1.4 (a)) | 1 |
| Offside Rear Outer Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced sill (6.1.1 (c) (i)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Central Prop shaft bearing excessively worn (6.1.7 (b) (i)) | 1 |
| Suspension component mounting prescribed area excessively corroded significantly reducing structural strength both sides inner sills at rear (5.3.6 (a) (i)) | 1 |
| Exhaust has a major leak of exhaust gases back box (6.1.2 (a)) | 1 |
| Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Seat belt missing both rear outer seats (7.1.2 (a)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Prop shaft joint excessively worn centre bush (6.1.7 (c) (i)) | 1 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Offside Rear Stop lamp(s) not working stuck on (4.3.1 (a) (ii)) | 1 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
| Nearside Front Upper Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Wheel arch (6.1.1 (c) (i)) | 1 |
| Offside Front All direction indicators not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Upper Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Wheel arch (6.1.1 (c) (i)) | 1 |
| Windscreen wiper not working (3.4 (a)) | 1 |
| Offside Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Emissions unable to be completed (8.2.1.2 (d)) | 1 |
| Offside Rear Valve stem seriously damaged (5.2.3 (j)) | 1 |
| Nearside Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Nearside Rear Valve stem seriously damaged (5.2.3 (j)) | 1 |
| Brake performance unable to be tested (1.2.1 (g)) | 1 |
| Nearside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Offside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively damaged significantly reducing structural strength inner arch/turret spring mount (5.3.6 (a) (i)) | 1 |