| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 7 |
| Parking brake: efficiency below requirements |3.7.B.7| | 6 |
| Brakes imbalanced across an axle | 6 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Windscreen wiper does not clear the windscreen effectively | 3 |
| Headlamp aim out of alignment | 3 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Steering box insecure |2.2.B.1a| | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Brake pedal has insufficient reserve movement |3.3.A.5| | 2 |
| Offside Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Rear parking brake recording little or no effort | 2 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Mechanical brake component has restricted free movement | 2 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Fuel cap/sealing device sealing washer deteriorated |7.2.4c| | 1 |
| Nearside Rear Service brake effort inadequate at a wheel |1.2.1 |a| |i|| | 1 |
| Nearside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Offside Front Direction indicator incorrect colour |4.4.3 |a|| | 1 |
| Nearside Front Direction indicator incorrect colour white |4.4.3 |a|| | 1 |
| Offside Front Service brake excessively binding |1.2.1 |f|| | 1 |
| Rear Fuel system component leaking excessively or a risk of fire clip loose |6.1.3 |b| |ii|| | 1 |
| Front Steering box insecure |2.2.B.1a| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Front Lower Suspension arm attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
| Nearside Outer Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Nearside Front Front suspension has a suspension lower ball joint securing nut loose |2.5.B.1a| | 1 |
| Nearside Rear Wheel insecure |4.2.A.1c| | 1 |
| Nearside Rear Brake pipe connection leaking on a hydraulic braking system |1.1.11 |b| |ii|| | 1 |
| Offside Rear Brake pipe connection leaking on a hydraulic braking system |1.1.11 |b| |ii|| | 1 |
| Rear brake application uneven | 1 |
| Offside Front Suspension arm severely distorted |2.4.G.1| | 1 |
| Offside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
| Front Coil spring mounting loose |2.4.C.3a| | 1 |
| Offside Front suspension has excessive movement at a suspension ball joint |2.5.A.1c| | 1 |
| Offside Front brake caliper locking device insecure |3.5.1l| | 1 |
| Nearside Front brake caliper locking device missing |3.5.1l| | 1 |
| front brake binding |3.7.B.1| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Direction indicators not working |1.4.A.2c| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Macpherson strut insecure |2.4.G.1| | 1 |
| Nearside Front Drag link end cracked and unserviceable |2.2.C.1d| | 1 |
| Front Drag link end cracked and unserviceable |2.2.C.1d| | 1 |
| Nearside Inner Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Front brake caliper securing device loose |3.5.1j| | 1 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Front Upper Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
| Nearside Rear Braking system leaking |3.6.A.1| | 1 |
| Front Steering box has a significant oil leak |2.2.D.2e| | 1 |
| Nearside Front Outer Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Also inner sills |6.1.B.2| | 1 |
| Offside Front Outer Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Also inner sills |6.1.B.2| | 1 |
| Nearside Rear Outer Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Inner sills also |6.1.B.2| | 1 |
| Offside Front front parking |secondary| brake grabbing severely |3.7.B.6b| | 1 |
| Brake hose excessively deteriorated | 1 |
| Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Vehicle floor |6.1.B.2| | 1 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Dipswitch operation does not extinguish all main beam headlamps leaving at least one pair of dipped beam headlamps |1.7.4b| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Offside Inner Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Outer Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Inner Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Suspension component mounting prescribed area is excessively corroded chassis rail by front floor |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded floor |2.4.A.3| | 1 |
| Offside Suspension component mounting prescribed area is excessively corroded outer sill at front |2.4.A.3| | 1 |
| Rear Exhaust has a major leak of exhaust gases section |7.1.2| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Lower Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
| Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Braking system leaking wheel cylinder |3.6.A.1| | 1 |
| Offside Front Steering component mounting prescribed area is fractured |2.2.C.1h| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Anti-roll bar attachment bracket/mounting damaged and its strength is seriously reduced |2.4.G.1| | 1 |
| Offside Front Anti-roll bar attachment bracket/mounting damaged and its strength is seriously reduced |2.4.G.1| | 1 |
| Offside Front Upper Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Offside Stop lamp has a product on the light source so it is not visible from a reasonable distance |1.2.1d| | 1 |
| Nearside Front Upper Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Lower Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Upper Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Lower Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Horn emits two or more alternating tones |1.6.2d| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Front Parking brake lever is fouling adjacent parts of the vehicle exhaust pipe |3.1.6b| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Steering component mounting prescribed area is fractured steering box |2.2.C.1h| | 1 |
| Nearside Steering locking device missing |2.2.C.1g| | 1 |
| Offside Steering locking device missing |2.2.C.1g| | 1 |