| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 73 |
| Windscreen wiper does not clear the windscreen effectively | 69 |
| Brake pipe excessively corroded | 59 |
| Headlamp aim out of alignment | 57 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 17 |
| Registration plate issues | 13 |
| Offside Stop lamp not working |1.2.1b| | 13 |
| Nearside Stop lamp not working |1.2.1b| | 11 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 10 |
| Engine MIL inoperative or indicates a malfunction (8.2.2.2 (g)) | 10 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 9 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 9 |
| Centre Stop lamp not working |1.2.1b| | 9 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 8 |
| Parking brake: efficiency below requirements |3.7.B.7| | 8 |
| Brakes imbalanced across an axle | 8 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 8 |
| Offside Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 7 |
| Front brake disc in such a condition that it is seriously weakened | 7 |
| Nearside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 7 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 7 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 7 |
| Anti-lock braking system warning lamp indicates an ABS fault | 6 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 6 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 5 |
| Battery insecure |1.9.1| | 5 |
| Windscreen has damage | 5 |
| Nearside Rear Stop lamp not working |1.2.1b| | 5 |
| Offside Rear Stop lamp not working |1.2.1b| | 5 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 5 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Nearside Inner Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 5 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 5 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 4 |
| Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill (7.1.1 (a) (i)) | 4 |
| Centre Rear Stop lamp not working |1.2.1b| | 4 |
| Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 4 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 4 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 4 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 4 |
| Stop lamp not working |1.2.1b| | 4 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 4 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 4 |
| Nearside Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 4 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 3 |
| Nearside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 3 |
| Offside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 3 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 3 |
| Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 3 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 3 |
| Rear brake binding | 3 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 3 |
| Engine MIL inoperative or indicates a malfunction |8.2.2.2 |g|| | 3 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 3 |
| Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 3 |
| Centre Upper Stop lamp not working |1.2.1b| | 3 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 3 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Nearside Front Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 3 |
| Fuel tank leaking (6.1.3 (b) (i)) | 3 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 3 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 3 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 3 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 3 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 3 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 3 |
| Nearside Front Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Offside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 3 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 3 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Offside Front Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 3 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 3 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 3 |
| Offside Steering rack gaiter split |2.2.D.2d| | 2 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 2 |
| Nearside Outer Seat belt anchorage prescribed area is excessively corroded sill |5.2.6| | 2 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 2 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 2 |
| Brake pedal anti-slip provision incomplete |3.3.A.1b| | 2 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Emissions not tested (8.2.2.2 (e)) | 2 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 2 |
| Exhaust emissions exceed default limit of 1.5m-1 (8.2.2.2 (b)) | 2 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 2 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Nearside Headlamp not working on main beam |1.7.5a| | 2 |
| Nearside Front Road wheel cracked |4.2.A.1a| | 2 |
| Offside Front Inner Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Fuel system component leaking (6.1.3 (b) (i)) | 2 |
| Offside Front Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Lower engine mounting deteriorated resulting in excessive movement |6.1.D.1a| | 2 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Offside Rear Position lamp lens seriously defective (4.2.1 (b)) | 2 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 2 |
| Upper Stop lamp not working |1.2.1b| | 2 |
| Central Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 2 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 2 |
| Front Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 2 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Service brake grabbing severely both rear (1.2.1 (c)) | 2 |
| Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 2 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Nearside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Nearside Outer Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 2 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 2 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 2 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Nearside Rear Position lamp has a product on the lens or light source which shows white light to the rear (4.2.3 (b) (ii)) | 2 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 2 |
| Battery insecure and likely to fall from carrier |4.13 |a| |ii|| | 2 |
| Nearside Rear Service brake excessively binding |1.2.1 |f|| | 2 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Offside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 2 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 2 |
| Exhaust emissions exceed manufacturers specified limit (8.2.2.2 (a)) | 2 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Rear Upper Stop lamp not working |1.2.1b| | 2 |
| Exhaust on a vehicle fitted with a diesel particulate filter emits visible smoke of any colour (8.2.2.2 (d)) | 2 |
| Offside Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 2 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Oil leaking excessively from engine |8.4.1 |a| |i|| | 2 |
| Offside Front Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Nearside Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 2 |
| Rear parking brake recording little or no effort | 2 |
| Offside Headlamp insecure (4.1.1 (c)) | 2 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 2 |