| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 39 |
| Headlamp aim out of alignment | 15 |
| Brake pipe excessively corroded | 13 |
| Parking brake: efficiency below requirements |3.7.B.7| | 11 |
| Windscreen wiper does not clear the windscreen effectively | 11 |
| Rear parking brake recording little or no effort | 10 |
| Centre Stop lamp not working |1.2.1b| | 6 |
| Nearside Stop lamp not working |1.2.1b| | 5 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Registration plate issues | 5 |
| Front brake disc in such a condition that it is seriously weakened | 4 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 4 |
| Anti-lock braking system warning lamp indicates an ABS fault | 3 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Offside Rear Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 3 |
| Brakes imbalanced across an axle | 3 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Centre Exhaust system not adequately supported |7.1.1| | 3 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Offside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Rear brake binding | 3 |
| Nearside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 3 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Rear brake application uneven | 2 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 2 |
| Brake performance not tested (1.2.1 (g)) | 2 |
| Nearside Rear Service brake excessively fluctuating (1.2.1 (e)) | 2 |
| Offside Rear Service brake excessively fluctuating (1.2.1 (e)) | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded outer sill |2.4.A.3| | 2 |
| rear brake excessively fluctuating |3.7.B.3| | 2 |
| Nearside Front Inner Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Battery insecure |1.9.1| | 2 |
| Offside Rear Stop lamp not working |1.2.1b| | 2 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Engine MIL inoperative or indicates a malfunction (8.2.2.2 (g)) | 2 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 2 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Nearside Front Side repeater not working |1.4.A.2c| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Brake performance not tested |1.2.1 |g|| | 1 |
| Rear Brake pipe leaking on a hydraulic braking system |1.1.11 |b| |ii|| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Rear Exhaust system insecure (6.1.2 (a)) | 1 |
| Offside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Nearside Outer Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
| Offside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt Wishbone and is leaking. |2.4.G.2| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded outer sill area |2.4.A.3| | 1 |
| Nearside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Outer Suspension component mounting prescribed area is excessively corroded sill |2.4.A.3| | 1 |
| Nearside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Stop lamp(s) remains on when the brakes are released (4.3.2 (a) (iii)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Inner Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced offside outer sill in multiple places (6.1.1 (c) (i)) | 1 |
| Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced offside inner sill in multiple places (6.1.1 (c) (i)) | 1 |
| Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced nearside outer sill corroded and detached from inner sill (6.1.1 (c) (i)) | 1 |
| Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced nearside rear inner sill (6.1.1 (c) (i)) | 1 |
| Nearside Outer Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill |6.1.B.2| | 1 |
| Offside Outer Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill |6.1.B.2| | 1 |
| Central Stop lamp not working |1.2.1b| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Exhaust has a major leak of exhaust gases at back box |6.1.2 |a|| | 1 |
| Emissions not tested due to exhaust blow |8.2.2.2 |e|| | 1 |
| Offside Suspension spring mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected at full sill |5.3.6 |a| |ii|| | 1 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Power steering fluid level below minimum |2.3.1| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded outer sill |5.2.6| | 1 |
| Nearside Inner Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded sill |2.4.A.3| | 1 |
| Indicator tell tale missing |1.4.A.2a| | 1 |
| Main beam `tell-tale` not working |1.7.4c| | 1 |
| Brake pedal anti-slip provision incomplete |3.3.A.1b| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front suspension ball joint dust cover missing |2.4.G.2| | 1 |
| Offside Front suspension ball joint dust cover missing |2.4.G.2| | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Front Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Nearside Front Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Offside Front Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Offside Front Anti-roll bar ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Outer Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Offside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt steering rack gaiter damaged (2.1.3 (g) (ii)) | 1 |
| Nearside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Rear Vehicle structure has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill corrosion within 30cm of prescribed area (5.3.6 (a) (i)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Fuel system component leaking suspect injectors |7.2.3| | 1 |
| Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Nearside Front Vehicle structure has a fracture which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Rear Leaf spring shackle bracket loose |2.4.B.6a| | 1 |
| Battery insecure and likely to cause a short circuit |4.13 |a| |ii|| | 1 |
| Offside Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill |5.3.6 |a| |i|| | 1 |
| Offside Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill |5.3.6 |a| |i|| | 1 |
| Engine mounting damaged or deteriorated resulting in excessive movement lower |6.1.8 |a| |i|| | 1 |
| Nearside Front Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc split |2.5.C.1a| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded outer sill area near door |5.2.6| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded outer sill area |5.2.6| | 1 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill |6.1.B.2| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill |6.1.B.2| | 1 |
| Offside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Body has a projection caused by corrosion offside front outer lower sill corroded resulting in x2 holes |6.1.C.1| | 1 |
| Offside Inner Body has a sharp edge caused by corrosion sill corroded |6.1.C.1| | 1 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Front Obligatory mirror insecure |8.1.1| | 1 |
| Brake fluid contaminated |1.8 |a|| | 1 |
| Horn not working |1.6.2a| | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Nearside Front Wheel bearing rough when rotated |5.1.3 |b| |i|| | 1 |
| Front Exhaust emissions likely to be affected by an exhaust leak |8.2.2.1 |b|| | 1 |
| Exhaust fumes causing a danger to health of persons on board |6.1.2 |b| |ii|| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Brake pedal anti-slip provision worn smooth (1.1.2 (c)) | 1 |
| Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Offside Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Exhaust silencer insecure (8.1.1 (b) (i)) | 1 |
| Emissions unable to be completed (8.2.2.2 (e)) | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Nearside Rear Position lamp has a product on the lens or light source which shows white light to the rear (4.2.3 (b) (ii)) | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced as marked. (7.1.1 (a) (i)) | 1 |
| Nearside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Valve stem seriously damaged (5.2.3 (j)) | 1 |
| Nearside Front Outer Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced sill |6.1.1 |c| |i|| | 1 |
| Nearside Rear Bumper damaged and likely to cause injury when grazed or contacted end bumper cap |6.1.4 |a| |i|| | 1 |
| Offside Rear Bumper damaged and likely to cause injury when grazed or contacted end bumper cap |6.1.4 |a| |i|| | 1 |
| Nearside Rear Stop lamp|s| lens defective such that the emitted light is adversely affected lens damaged |4.3.1 |b| |ii|| | 1 |
| Nearside Rear Headlamp reflector missing (4.1.1 (b) (ii)) | 1 |
| Offside Rear Outer Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Nearside Rear Position lamp showing white light to the rear lens damaged (4.2.3 (a) (ii)) | 1 |
| Exhaust fumes causing a danger to health of persons on board (6.1.2 (b) (ii)) | 1 |
| Offside Rear Bumper damaged and likely to cause injury when grazed or contacted bumper end cap missing (6.1.4 (a) (i)) | 1 |
| Offside Rear All direction indicators incorrect colour (4.4.3 (a)) | 1 |
| Offside Front Drive shaft bearing likely to break up c.v joint (6.1.7 (b) (ii)) | 1 |
| Front Exhaust has a major leak of exhaust gases flexi (6.1.2 (a)) | 1 |
| Nearside Front Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Position lamp showing white light to the rear lens damaged (4.2.3 (a) (ii)) | 1 |
| Nearside Rear Bumper damaged and likely to cause injury when grazed or contacted bumper end cap missing (6.1.4 (a) (i)) | 1 |
| Offside Front Headlamp are incorrectly positioned bulb (4.1.4 (a)) | 1 |
| Nearside Front Drive shaft bearing likely to break up joint (6.1.7 (b) (ii)) | 1 |
| Nearside Rear All direction indicators incorrect colour (4.4.3 (a)) | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Rear Stop lamp(s) showing white light to the rear (4.3.3 (a) (ii)) | 1 |
| Rear Bumper damaged and likely to cause injury when grazed or contacted 2x end caps missing (6.1.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Front Anti-roll bar pin or bush excessively worn 2x front D bush worn (5.3.4 (a) (i)) | 1 |
| Offside Front Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Offside Front Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Nearside Rear Position lamp showing white light to the rear |4.2.3 |a| |ii|| | 1 |
| Rear Body panel damaged and likely to cause injury o/s + n/s bumper end caps missing |6.2.1 |a| |i|| | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 1 |
| Nearside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength outer sill |5.3.6 |a| |i|| | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill |7.1.1 |a| |i|| | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Rear Upper Stop lamp not working |1.2.1b| | 1 |
| Offside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Inner Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Front Headlamp insecure |1.7.3| | 1 |
| Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear Outer Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Sill |6.1.B.2| | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
| Nearside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Wheel bearing play so excessive it is likely to break up (5.1.3 (a) (ii)) | 1 |
| Centre Rear Stop lamp not working |1.2.1b| | 1 |
| Windscreen washer not working | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Front Lower Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Lower Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Brake performance not tested leaking pipes (1.2.1 (g)) | 1 |
| Offside Obligatory mirror missing |8.1.1| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Nearside Outer Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced s[ll (6.1.1 (c) (i)) | 1 |
| Offside Outer Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced sill (6.1.1 (c) (i)) | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Windscreen has damage | 1 |
| Nearside Rear Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded Outer sill |5.2.6| | 1 |
| Vehicle structure has excessive corrosion which adversely affects braking or steering Nearside and offside outer sills (6.1.1 (c) (ii)) | 1 |
| Offside Front Anti-roll bar linkage ball joint likely to become detached (5.3.4 (a) (ii)) | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Exhaust has a major leak of exhaust gases Front and rear (6.1.2 (a)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint likely to become detached (5.3.4 (a) (ii)) | 1 |
| Nearside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced sill (6.1.1 (c) (i)) | 1 |
| Offside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced sill (6.1.1 (c) (i)) | 1 |