| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 7 |
| Windscreen wiper does not clear the windscreen effectively | 6 |
| Registration plate lamp issues | 5 |
| Brakes imbalanced across an axle | 3 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 3 |
| Nearside Rear Stop lamp not working |1.2.1b| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Rear Outline marker lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Brake pipe excessively corroded | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Power steering fluid level below minimum |2.3.1| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 2 |
| All outline marker lamps not working (4.2.1 (a) (ii)) | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Prop shaft bearing excessively worn (6.1.7 (b) (i)) | 1 |
| Offside Front Vehicle structure is fractured and structural rigidity is significantly reduced (6.1.1 (a) (i)) | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Rear Position lamp adversely affected by the operation of another lamp (4.2.3 (c)) | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Stop lamp(s) not working N/S INOP (4.3.1 (a) (ii)) | 1 |
| Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Battery insecure and likely to fall from carrier BOTH BATTERIES HAD TO PUSH BACK INTO TRAY (4.13 (a) (ii)) | 1 |
| Nearside Steering linkage ball joint has excessive play track rod end |2.1.3 |b| |i|| | 1 |
| Central Front Steering linkage ball joint has excessive play steering arm out of steering box |2.1.3 |b| |i|| | 1 |
| Nearside Rear Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Prop shaft bearing excessively worn rubber mounting (6.1.7 (b) (i)) | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Front Brake pipe connection leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Nearside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Offside Outline marker lamp not working damaged (4.2.1 (a) (ii)) | 1 |
| Offside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Horn not working |1.6.2a| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Outer Prop shaft joint constant velocity boot no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Outer Prop shaft joint constant velocity boot no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Central Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i)) | 1 |
| Front Integral body structure has excessive corrosion which adversely affects braking or steering crossmember holed (6.1.1 (c) (ii)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt ball joint gaiter (5.3.4 (b) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt ball joint gaiter (5.3.4 (b) (ii)) | 1 |
| Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength crossmember (5.3.6 (a) (i)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Emissions unable to be completed (8.2.2.2 (e)) | 1 |
| Offside Side repeater incorrect colour (4.4.3 (a)) | 1 |
| Power steering component leaking steering rack (2.1.5 (a)) | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Offside Rear Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced sill (6.1.1 (c) (i)) | 1 |
| Offside Outer Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced sill (6.1.1 (c) (i)) | 1 |
| Offside Inner Integral body structure inadequately repaired such that structural rigidity is significantly reduced sill (6.1.1 (d) (i)) | 1 |
| Offside Rear Outer Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced sill (6.1.1 (c) (i)) | 1 |
| Nearside Rear Outer Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced sill (6.1.1 (c) (i)) | 1 |
| Offside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced wheel arch (6.1.1 (c) (i)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect KICKS UP TO RIGHT (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect KICKS UP TO RIGHT (4.1.2 (c)) | 1 |
| Exhaust emissions exceed manufacturers specified limit (8.2.2.2 (a)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Fuel hose excessively damaged Breather by tank |7.2.2| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Headlamp aim does not move downwards when dipped |British American headlamp| |1.8.C.4| | 1 |
| Nearside Rear Upper Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Stop lamp adversely affected by the operation of another lamp all offside rear light affected |1.2.1f| | 1 |
| Nearside Upper Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Windscreen washer not working | 1 |
| Offside Rear Position lamp not working passenger side |4.2.1 |a|| | 1 |
| Stop lamp|s| all not working |4.3.1 |a| |iii|| | 1 |
| Rear Prop shaft bearing excessively worn |6.1.7 |b| |i|| | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |