| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 13 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 12 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 12 |
| Registration plate lamp issues | 9 |
| Windscreen wiper does not clear the windscreen effectively | 8 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 6 |
| Brake pipe excessively corroded | 5 |
| Parking brake: efficiency below requirements |3.7.B.7| | 4 |
| Parking brake lever has no reserve travel |3.1.6b| | 4 |
| Windscreen washer not working | 4 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 3 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 3 |
| Registration plate issues | 3 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 2 |
| Electronic stability system warning lamp indicates a fault |3.4.1c| | 2 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Brake hose excessively deteriorated | 2 |
| Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 2 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Rear brake binding | 2 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Exhaust emissions likely to be affected by an exhaust leak |8.2.1.1 |b|| | 1 |
| Offside front brake recording little or no effort |3.7.B.5a| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Offside Ball joint has excessive play |2.2.B.1f| | 1 |
| Emissions not tested |8.2.1.2 |d|| | 1 |
| Offside Rear Brake hose leaking |3.6.A.1| | 1 |
| Centre Rear Brake pipe inadequately clipped chaffing rear anti roll bar |3.6.B.1| | 1 |
| Brake fluid warning lamp illuminated /parking brake stays on |3.6.G.2| | 1 |
| Nearside Front Track rod end loose |2.2.B.1d| | 1 |
| Offside Front Braking system leaking union on chassis leg |3.6.A.1| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Power steering component|s| leaking |2.3.3b| | 1 |
| Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Power steering inoperative |2.3.3a| | 1 |
| Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Nearside Front Headlamp does not operate immediately when selected on dipped beam |1.7.4a| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.3.D.1| | 1 |
| Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Position lamp adversely affected by the operation of another lamp |4.2.3 |c|| | 1 |
| Nearside Rear Anti-roll bar pin or bush excessively worn d bush |5.3.4 |a| |i|| | 1 |
| Offside Rear Anti-roll bar pin or bush excessively worn d bush |5.3.4 |a| |i|| | 1 |
| Nearside Front Steering system has a road wheel fouling a part of the vehicle |2.2.D.2a| | 1 |
| Nearside Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Nearside Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Offside Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Offside Front Braking system leaking |3.6.A.1| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Rear Wheel bolt|s| loose x5 |4.2.A.1e| | 1 |
| Offside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Offside Front Brake valve has an excessive discharge of oil |3.6.E.1| | 1 |
| Offside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Emissions not tested |7.0| | 1 |
| Nearside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
| Offside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
| Nearside Rear Brake hose bulging under pressure |3.6.B.3| | 1 |
| Offside Rear Brake hose bulging under pressure |3.6.B.3| | 1 |
| Nearside Rear Brake hose leaking |3.6.A.1| | 1 |
| Offside Direction indicators not working |1.4.A.2c| | 1 |
| Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Front Anti-roll bar linkage has excessive play in a ball joint both |2.4.G.2| | 1 |
| Fuel system component leaking left fuel filter area |7.2.3| | 1 |
| Rear Seat belt anchorage prescribed area is excessively corroded both inner wheel arches |5.2.6| | 1 |
| Rear Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| rear parking |secondary| brakes imbalanced | 1 |
| Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Statutory seat belt missing Buckle |5.1.1| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Front Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Front Service brake excessively fluctuating |1.2.1 |e|| | 1 |
| Boot lid cannot be secured in the closed position |6.2.1 |e|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Offside Headlamp are incorrectly positioned not lifting (4.1.4 (a)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Parking brake lever defective so that it cannot be satisfactorily operated Will not release, when park brake max effort is applied (1.1.6 (d)) | 1 |
| Nearside Rear Shock absorbers has a serious fluid leak | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Emissions unable to be completed excessive co (8.2.1.2 (d)) | 1 |
| Offside Front Brake pipe leaking on an air braking system (1.1.11 (b) (i)) | 1 |