| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 52 |
| Registration plate issues | 18 |
| Parking brake: efficiency below requirements |3.7.B.7| | 12 |
| Windscreen wiper does not clear the windscreen effectively | 9 |
| Registration plate lamp issues | 5 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 5 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 4 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 4 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 4 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 3 |
| Parking brake lever has no reserve travel |3.1.6b| | 3 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Centre Rear Stop lamp not working |1.2.1b| | 2 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside Front Direction indicator incorrect colour (4.4.3 (a)) | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 2 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside Front Suspension arm has excessive play in a pin/bearing lower arm outer bush |2.4.G.2| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Offside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside Rear Outer Tie bar/rod ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Rear Outer Tie bar/rod ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Nearside Rear Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Offside Rear Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Rear Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Lower Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Offside Rear Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Centre Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Headlamp cleaning device inoperative offside & nearside |1.7.2| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt split |2.4.G.2| | 1 |
| Nearside Rear Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt split |2.4.G.2| | 1 |
| Offside Rear Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt split |2.4.G.2| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Nearside Rear Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Front brake application uneven | 1 |
| Offside Front Headlamps matched pair are incorrectly positioned |1.7.3| | 1 |
| Nearside Front Anti-roll bar linkage fractured |2.4.G.1| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturer`s specified limits |8.2.1.2 |a|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Electronic stability control warning lamp indicates a fault |7.12 |e|| | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 1 |
| Emissions not tested |7.0| | 1 |
| Nearside Power steering component leaking (2.1.5 (a)) | 1 |
| Windscreen washer not working | 1 |
| Offside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front coil spring broken |2.4.C.1a| | 1 |
| Offside Front coil spring broken |2.4.C.1a| | 1 |
| Emissions not tested Engine over heating. |7.3.A.1| | 1 |
| Parking brake efficiency below requirements |3.7.E.1| | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Offside Rear brake caliper leaking |3.6.A.1| | 1 |
| Nearside Rear Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Offside Rear Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Headlamp cleaning device inoperative |1.7.2| | 1 |
| Offside Headlamp cleaning device inoperative |1.7.2| | 1 |
| Offside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Front Valve stem seriously damaged |4.1.D.1e| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Offside Rear Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Fuel cap/sealing device mounting flange/sealing method defective |7.2.4c| | 1 |