| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 22 |
| Windscreen wiper does not clear the windscreen effectively | 21 |
| Headlamp aim out of alignment | 14 |
| Parking brake: efficiency below requirements |3.7.B.7| | 12 |
| Brake pipe excessively corroded | 12 |
| Registration plate issues | 10 |
| Rear fog lamp not working |1.3.2b| | 10 |
| Anti-lock braking system warning lamp indicates an ABS fault | 8 |
| Brake hose excessively deteriorated | 7 |
| Service brake: efficiency below requirements |3.7.B.7| | 7 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 6 |
| Offside Rear fog lamp not working |1.3.2b| | 6 |
| Brakes imbalanced across an axle | 6 |
| Parking brake lever has no reserve travel |3.1.6b| | 6 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 5 |
| Rear Rear fog lamp not working |1.3.2b| | 5 |
| Rear parking brake recording little or no effort | 5 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 4 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 4 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 4 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 4 |
| Horn not working |1.6.2a| | 4 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 3 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 3 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
| Rear brake application uneven | 3 |
| Windscreen has damage | 2 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 2 |
| Centre Stop lamp not working |1.2.1b| | 2 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 2 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
| Rear Mechanical brake component has restricted free movement | 2 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 2 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 2 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Nearside Side repeater not working |1.4.A.2c| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Rear fog lamp missing |1.3.2a| | 2 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Brake master cylinder fluid level below minimum level |3.6.G.1e| | 2 |
| Nearside Rear Stop lamp not working |1.2.1b| | 2 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Service brake: efficiency below requirements |3.7.C.1a| | 2 |
| Headlamp not working on main beam |1.7.5a| | 2 |
| Mechanical brake component has restricted free movement | 2 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 2 |
| Rear Seat belt retracting mechanism defective |5.2.5b| | 2 |
| Ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Front Side repeater incorrect colour |1.4.A.2f| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Lower Axle swivel joint has excessive play in a ball joint |2.5.A.3b| | 1 |
| Nearside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Front Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Brake cable guide defective and affecting operation (1.1.15 (d)) | 1 |
| Nearside Front Hydraulic brake calliper leaking (1.1.16 (b) (i)) | 1 |
| Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Rear fog lamp switch missing (4.5.3 (a)) | 1 |
| Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Front Service brake excessively binding both binding (1.2.1 (f)) | 1 |
| Offside Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Offside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Fuel system component insecure |7.2.1| | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Nearside Rear Leaf spring shackle bracket corroded and seriously weakened |2.4.B.6d| | 1 |
| Nearside Front Service brake excessively fluctuating |1.2.1 |e|| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Rear Electrical wiring damaged and bare wires exposed |1.9.2c| | 1 |
| Offside Front Lower Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Power steering pump leaking from a failed component |2.3.3b| | 1 |
| Nearside Rear Anti-roll bar linkage has excessive play in a pin/bearing |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar linkage has excessive play in a pin/bearing |2.4.G.2| | 1 |
| Nearside Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt top and bottom |2.4.G.2| | 1 |
| Offside Front suspension has excessive movement at a suspension ball joint top |2.5.A.1c| | 1 |
| Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt top and bottom |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar linkage fractured |2.4.G.1| | 1 |
| Offside Front Front drive shaft coupling is excessively worn |2.5.C.1c| | 1 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Upper Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Nearside Side repeater missing (4.4.1 (a) (ii)) | 1 |
| Offside Side repeater missing (4.4.1 (a) (ii)) | 1 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Trailer electrical socket insecure |1.9.3a| | 1 |
| Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Rear Shock absorber insecure |2.7.2b| | 1 |
| Front brake application uneven | 1 |
| Rear fog lamp switch missing |1.3.1a| | 1 |
| Rear fog lamp tell tale missing |1.3.1b| | 1 |
| Brake hose damaged | 1 |
| Brake hose has insufficient room to move | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Side repeater excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Emissions not tested missfire |8.2.1.2 |d|| | 1 |
| Nearside Front Shock absorbers has a serious fluid leak | 1 |
| Nearside Rear Hydraulic brake cylinder leaking hydraulic fluid (1.1.16 (b) (i)) | 1 |
| Emissions not tested (8.2.1.2 (d)) | 1 |
| Offside Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
| Nearside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Nearside Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Stop lamp obscured more than 50% |1.2.1c| | 1 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Headlamp aim not tested both due to not working (4.1.2 (b)) | 1 |
| Nearside Fuel hose insecure section with fuel filter attached (6.1.3 (a) (i)) | 1 |
| Nearside Front Upper Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Emissions not tested due to engine running poorly (8.2.1.2 (d)) | 1 |
| Emissions unable to be completed (8.2.1.2 (d)) | 1 |
| Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front Wheel stud|s| missing |4.2.A.1e| | 1 |
| Braking system leaking |3.6.A.1| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear wheel cylinder leaking |3.6.A.1| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Position lamp not working |4.2.1 |a|| | 1 |
| Rear fog lamp obviously incorrectly positioned |4.5.4 |a|| | 1 |
| Nearside Brake pipe at imminent risk of failure or fracture pipe from front to rear |1.1.11 |a|| | 1 |
| Nearside Front Steering component mounting prescribed area is excessively corroded chassis within 30cm of steering box mountings |2.1.2 |e| |i|| | 1 |
| Central Drag link end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Offside Rear Passengers seat insecure mounting bolt missing. (6.2.6 (a) (ii)) | 1 |
| Nearside Rear Lower Shock absorbers has an excessively worn bush and upper. |5.3.2 |c|| | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Offside Rear fog lamp missing |4.5.1 |a| |ii|| | 1 |
| Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Nearside Rear Direction indicator incorrect colour |4.4.3 |a|| | 1 |
| Offside Rear Direction indicator incorrect colour |4.4.3 |a|| | 1 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Rear fog lamp switch missing (4.5.3 (a) (ii)) | 1 |
| Offside Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Central Front Seat belt not functioning as intended (7.1.2 (c)) | 1 |
| Power steering component|s| leaking from a failed seal |2.3.3b| | 1 |
| Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Power steering component|s| leaking |2.3.3b| | 1 |
| Nearside Front Outer Drive shaft joint excessively worn (6.1.7 (c) (i)) | 1 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Ball joint has excessive play steering box drop arm |2.2.B.1f| | 1 |
| Offside Front coil spring fractured |2.4.C.1a| | 1 |
| Nearside Front Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Service brake efficiency less than 50% of the required value |1.2.2 |a| |ii|| | 1 |
| Front All position lamps not working |4.2.1 |a|| | 1 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |
| Nearside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Offside Front Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Nearside Front Upper Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Side repeater excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Nearside Front Steering component mounting prescribed area is excessively corroded chassis, near steering box location (2.1.2 (e) (i)) | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside rear brake excessively fluctuating |3.7.B.3| | 1 |
| Offside Upper Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Upper Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Ball joint has excessive play drop arm joint |2.2.B.1f| | 1 |
| Nearside Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Lower Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Headlamp aim projected beam image is obviously incorrect both (4.1.2 (c)) | 1 |
| Nearside Headlamp lens seriously defective inside (4.1.1 (b) (ii)) | 1 |
| Rear fog lamp light intensity significantly reduced (4.5.4 (a)) | 1 |
| Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting osf outer sill
nsf outer sill (6.2.2 (d) (i)) | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Power steering pipe/hose leaking (2.1.5 (a)) | 1 |
| Nearside Panhard rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Direction indicators not working |1.4.A.2c| | 1 |
| Power steering malfunctioning |2.3.3a| | 1 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
| Battery insecure |1.9.1| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Front Radius arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Upper Front suspension has excessive movement at a suspension ball joint |2.5.A.1c| | 1 |
| Front Position lamp not working both sides |4.2.1 |a| |ii|| | 1 |
| Steering column universal joint insecure centre |2.1.5| | 1 |